Table of Contents
Advertisement
4.1 LIGHT INDICATORS
The freezer has two lights that will alert the user if a problem occurs: an ADD MIX light and a Diagnostic Light.
The ADD MIX light will flash to alert the operator to a low mix condition. It does so by monitoring the mix level in the
hopper. When the ADD MIX light is flashing, refill hopper immediately.
The Diagnostic Light will flash if an error occurs. Refer to the chart below for details.
Indication
On
Conditions
Defrost Mode
Self
N/A
Correction
Every 7 minutes
the auger will
Operation
run for 90
seconds.
Corrective
N/A
Action
4.2 TROUBLESHOOTING
PROBLEM
1. Power to freezer is off.
2. Blown fuse or tripped circuit.
3. Freeze-up (auger will not turn).
Freezer does not
run.
4. High pressure cut-out tripped.
5. Front door not in place.
1. Drive belt failure.
2. Consistency temperature setting is too
Freezer will not
firm.
shut off.
3. Refrigeration problem.
1. Consistency temperature setting is too
Product is too firm.
firm.
SECTION 4
TROUBLESHOOTING
One Blink
Torque is not
met after 20
minutes
(22 minutes for
shake)
The freezer attempts to sense drive
current with a 3 second pre-stir. If current
is sensed, the freezer will return to normal
operation. If current is not sensed, the
N/A
freezer will wait 7 minutes and try to
sense current with another 3 second pre-
stir. After the third attempt, the
compressor will run on timers.
Timers
Contact Service
Contact Service Technician
Technician
POSSIBLE CAUSE
17
Two Blinks
Drive current is not sensed
Timers
1. Supply power to freezer.
2. Replace or reset.
3. Turn CLEAN-OFF-ON switch to OFF (middle)
position for 15 minutes, then restart.
4. Wait until automatic reset for freezer to start.
5. Assemble front door in place.
1. Replace drive belt.
2. Turn Consistency Adjustment knob counter-
clockwise.
3. Check system. (Call distributor for service)
1. Turn Consistency Adjustment knob counter-
clockwise.
Three Blinks
Freezer left in clean
mode for over 20
minutes
N/A
Off
Turn CLEAN-OFF-ON
switch to OFF
(middle) position then
turn the switch to ON.
REMEDY
Advertisement
Table of Contents
