Table of Contents
Advertisement
The replacement procedure for the filter cartridge is as
follows:
1.
Unhook the lower module of the separator by raising
the bin handle.
2.
Extract the lower module of the separator by allowing
it to slide on its wheels with the assistance of the specific
handle.
3.
Unscrew the black knob holding the filter cartridge in
position.
4.
Extract the filter cartridge.
5.
When replacing the filter cartridge and make sure it is
correctly installed (tighten the black knob accordingly).
6.
Hook the dust bin back onto the separator by
lowering the handle. If it becomes necessary to remove the
dust bin from the separator, to empty the collection bag, the vacuum tube that allows the bag to be kept in
the correct position must be unscrewed.
6.4 Cleaning of the filter cartridge (filter)
The filter cartridge should be regenerated at the envisaged intervals (see section 6.1).
Before proceeding with replacement operations, a protective mask and gloves must be
put on. Use only original spare bags supplied by General D'Aspirazione.
Failure to use these items of personal protection equipment may expose the operator to
the risk of inhalation of dust that is harmful to health, or of the contact of allergenic
substances with the skin.
While the dust container is being hooked up, there is the risk of cutting injuries to the
fingers.
Extract the filter cartridge to be regenerated (see details of this operation in previous section), and if a
replacement cartridge is available, use it to replace the cartridge to be cleaned. Clean the dirty cartridge
with the vacuum unit, using the brush accessory for corners, taking care to avoid damage to the filter
fabric. As an alternative, the filter can be washed with water.
If the filter fabric is damaged during cleaning operations, it is essential to replace the cartridge with a new
one.
Use the filter cartridge only when it is completely dry.
After completing any kind of maintenance operation, remember the suction unit must
not be restarted without first having inserted the filter cartridge inside the separator.
31
Advertisement
Table of Contents
