Subscribe to Our Youtube Channel
Related Manuals for LELY Grazeway R
Summary of Contents for LELY Grazeway R
- Page 1 Lely Grazeway R Return Box Operator Manual EN - English Original 5.1531.8501.0 A Lely Industries N.V. www.lely.com...
- Page 2 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK...
- Page 3 Lely reserves all rights with respect to its trademarks. Any unauthorized use of any Lely-owned trademark or any use of a trademark that is confusingly similar to, or likely to cause confusion with a Lely-owned trademark, would constitute infringement of Lely’s exclusive rights. All rights reserved.
- Page 4 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK Trademarks, Copyright and Disclaimer...
- Page 5 in n o vato rs in ag ric u ltu re List of included Amendments Issue Date Chapter(s) Remarks (yyyy/mm) 2018/02 Initial issue 2019/02 Removed: Installation Added: EC declaration and WEE Changed: Structure and layout List of included Amendments...
- Page 6 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK List of included Amendments...
- Page 7 All information in this manual has been compiled with care. Lely shall not be liable for errors or faults in this manual. The recommendations are meant to serve as guidelines. All instructions, pictures and specifications in this manual are based on the latest information that was available at the time of publication.
- Page 8 in n o vato rs in ag ric u ltu re Figure 1. Type and serial number plate We suggest that you complete the table below with the type and serial numbers of your machine. This makes sure that you can easily find the information. Type number Serial number Preface...
-
Page 9: Table Of Contents
Table of Contents The Lely Grazeway Return Box ............... 1-1 The Grazeway R . - Page 10 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK Table of Contents...
-
Page 11: The Lely Grazeway Return Box
Cows can only open the gates of the Grazeway R in one direction. Each cow has an identification tag. The Grazeway R has a cow identification system and detects the ID of each cow returning into the barn (or going to the pasture). This ID is sent to T4C, the Lely farm management software. - Page 12 INTENTIONALLY BLANK The Lely Grazeway Return Box...
-
Page 13: Safety
in n o vato rs in ag ric u ltu re Safety Signal Icons Note the use of the signal words DANGER, WARNING and CAUTION with the safety messages. The signal word for each message uses the following guidelines: Danger Indicates a hazardous situation which, if not avoided, will result in death or serious injury. -
Page 14: Safety Instructions
• box. • Know the emergency medical center number for your area. Contact your local Lely service provider if you have any questions. • 2.2.2 Electrical Safety Only an authorized electrician must install the electrical power supply for the return box. -
Page 15: Specifications
in n o vato rs in ag ric u ltu re Specifications Specifications and Requirements General Operational Conditions Ambient temperature -15 to +40 °C (5 to 104 °F) Humidity 5 - 99% non condensing Power Supply 24 VDC Power supply Current Connected to Power box 24 VDC power supply... -
Page 16: Dimensions And Weight
Dimensions and Weight Dimensions Figure 2. Dimensions Grazeway R, portal and entrance KEY: A: Width: 109 cm (43 in) B: Length: 327 cm (129 in) C: Height: 209 cm (82 in) (Portal) -
Page 17: Description
ISO identification reader • Portal, Frames and Gates The Grazeway R has a portal and an entrance made of several frames and plates and two sets of Texas gates. All frames and gates are galvanised. Control Box The control box is installed on top of the portal under a cover. Inside the control box the PCB on which the Lely software runs is installed. -
Page 18: Iso Identification Reader
in n o vato rs in ag ric u ltu re ISO Identification Reader The ISO identification reader has a Velos control box and an antenna PCB, which both are installed inside the control box. The antenna is a ring through which the cow steps before she goes through the second Texas gate. Description... -
Page 19: Operating Instructions
Operating Instructions General Instruction There are no operating instructions for the Grazeway R other than adjustments in T4C. For more information see the online instruction guide “Your guide”. Operating Instructions... - Page 20 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK Operating Instructions...
-
Page 21: Preventive Maintenance
in n o vato rs in ag ric u ltu re Preventive Maintenance Clean the Return Box Unexpected cow movement. Risk of being crushed or trampled. Block the cow traffic. Do not spout water on the control box this can cause damage to the electronics. Preventive Maintenance... - Page 22 Figure 4. How to clean the parts of the Grazeway R KEY: 1. Do not spout water on the control unit with the control box - 2. Frames, plates and gates, cleaning with a high pressure cleaner is allowed Use a high pressure cleaner to clean the portal and gates (2).
-
Page 23: Troubleshooting
A Texas gate does not move The gate is tied. Untie the gate. (easily). If the problem persists. Call your local Lely service provider. Cow ISO tags are not identified The ring antenna is not Tighten the bolts of the ring connected correctly. - Page 24 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK Troubleshooting...
-
Page 25: Disposal
Lubricants and fluids must be disposed correctly to prevent pollution of the environment. Read the safety data sheets of the used lubricants and fluids for correct disposal. All lubricants and fluids must be disposed in compliance with the local rules and regulations. Contact your local authority or local Lely service provider for further details. Disposal... - Page 26 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK Disposal...
-
Page 27: Weee
WEEE directive, require special reuse and recycling processing. For this reason, Lely Industries N.V. has arranged that this product can be recycled at the local recycling/ disposal companies to collect and recycle this product at no cost to you. - Page 28 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK WEEE...
-
Page 29: 10 Ec Declaration Of Conformity
in n o vato rs in ag ric u ltu re 10 EC Declaration of Conformity EC Declaration of Conformity 10-1... - Page 30 in n o vato rs in ag ric u ltu re INTENTIONALLY BLANK 10-2 EC Declaration of Conformity...
- Page 32 Lely Industries N.V. CornelisFvanFderFLelylaanF1 NL-3147FPB FMaassluis Tel +31F(0)88F-F12F28F221 Fax +31F(0)88F-F12F28F222 www.lely.com...
Need help?
Do you have a question about the Grazeway R and is the answer not in the manual?
Questions and answers