Safety Rules - Carrier ASPASICCA012 Owner's Manual

SAFETY RULES
IMPORTANT SAFETY INSTRUCTIONS
Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators
SAVE THESE INSTRUCTIONS - The manufacturer suggests that these rules for safe
operation be copied and posted near the unit's installation site. Safety should be stressed to all
operators and potential operators of this equipment.
GENERAL HAZARDS
Study these SAFETY RULES carefully before installing,
operating or servicing this equipment. Become familiar
with this Owner's Manual and with the unit. The generator
can operate safely, efficiently and reliably only if it is
properly installed, operated and maintained. Many
accidents are caused by failing to follow simple and
fundamental rules or precautions.
Carrier cannot anticipate every possible
circumstance that might involve a hazard. The warnings
in this manual, and on tags and decals affixed to the unit
are, therefore, not all-inclusive. If using a procedure,
work method or operating technique Carrier does not
specifically recommend, ensure that it is safe for others.
Also make sure the procedure, work method or operating
technique chosen does not render the generator unsafe.
_ Despite the safe design of this generator,
operating this equipment imprudently, neglecting
its maintenance or being careless can cause
possible injury or death. Permit only responsible
and capable persons to operate or maintain this
equipment.
_ Potentially lethal voltages are generated by
these machines. Ensure all steps are taken to
render the machine safe before attempting to
work on the generator.
_ Parts of the generator are rotating and/or hot
during operation. Exercise care near running
generators.
• For safety reasons, Carrier recommends that the
installation, initial start-up and maintenance of this
equipment is carried out by a Carrier Dealer.
• The engine exhaust fumes contain carbon monoxide,
which can be DEADLY. This dangerous gas, if
breathed in sufficient concentrations, can cause
unconsciousness or even death. This exhaust system
must be installed properly, in strict compliance with
applicable codes and standards. Following
installation, do nothing that might render the system
unsafe or in noncompliance with such codes and
standards.
• Keep hands, feet, clothing, etc., away from drive belts,
fans, and other moving or hot parts. Never remove any
drive belt or fan guard while the unit is operating.
• Adequate, unobstructed flow of cooling and ventilating
air is critical to correct generator operation. Do not
alter the installation or permit even partial blockage of
ventilation provisions, as this can seriously affect safe
operation of the generator. The generator MUST be
installed outdoors.
• When working on this equipment, remain alert at all
times. Never work on the equipment when physically
or mentally fatigued.
• Inspect the generator regularly, and contact the
nearest Carrier Dealer for parts needing repair or
replacement.
• Before performing any maintenance on the generator,
disconnect its battery cables to prevent accidental
start up. Disconnect the cable from the battery post
indicated by a NEGATIVE, NEG or (-) first. Reconnect
that cable last.
• Never use the generator or any of its parts as a step.
Stepping on the unit can stress and break parts, and
may result in dangerous operating conditions from
leaking exhaust gases, fuel leakage, oil leakage, etc.
2 Carrier