Page 1
All manuals and user guides at all-guides.com DIRECT-VENT FIREPLACE OWNER’S OPERATION AND INSTALLATION MANUAL ® NATURAL GAS “TUDOR” MODELS (V)T32N-A SERIES, CGDV32NR AND CTDV32NR-HA PROPANE/LP GAS “TUDOR” MODELS (V)T32P-A SERIES AND CGDV32PR WARNING: If the information in this manual is not —...
Page 2
All manuals and user guides at all-guides.com TABLE OF CONTENTS SAFETY State of Massachusetts: The installation must alteration, service or maintenance can cause the Commonwealth of for correct installation chemicals known to the State additional information of California to cause cancer or stalled in an aftermarket,* www.fmiproducts.com 116646-01J...
Page 3
All manuals and user guides at all-guides.com SAFETY Continued Do not use any solid fuels (wood, dren when they are in the room adults away from hot surfaces to www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com SAFETY Continued National Electrical Code, ANSI/NFPA 70 Cleaning and Maintenance PRODUCT IDENTIFICATION Figure 1 - Direct-Vent Fireplace with Millivolt Ignition LOCAL CODES National Fuel Gas Code ANSI Z223.1/NFPA 54* PRODUCT FEATURES www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com PRODUCT FEATURES Continued PRE-INSTALLATION PREPARATION LOCATION AND SPACE REQUIREMENTS High Altitude Installation Figure 2 - Common Fireplace Locations " " " Figure 3 - Fireplace Bottom Dimensions CLEARANCES www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com PRE-INSTALLATION PREPARATION Continued " " " " " " " Nailing Tabs " Figure 5 - Framing Clearances for Corner Installation FRAMING AND FINISHING Wall Accessories Top of Louver Opening Note: Noncombustible mantels may discolor! Mantel from Mantel 14"...
All manuals and user guides at all-guides.com LOCATION OF TERMINATION CAP Fixed Openable Fixed Closed Closed Openable TERMINATION CAP GAS METER RESTRICTED AREA AIR SUPPLY INLET (TERMINATION PROHIBITED) A = clearance above grade, veranda, porch, deck, or I = clearance to service regulator vent outlet [*72" (182.9 cm) balcony [*12"...
All manuals and user guides at all-guides.com VENTING INSTALLATION NOTICE: Read these instruc- WARNING: Read all instruc- Failure to do so could result in NOTICE: Failure to follow these in- INSTALLATION PRECAUTIONS www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued INSTALLATION PLANNING Horizontal Termination Installation IMPORTANT: WARNING: Do not recess Figure 8 - Vent Pipe Connections Vent Opening Combustible Wall " Inside Framing Twist-Lock Procedure: " " (Framing Note: Horizontal runs of Detail) Vent Opening vent must be supported every three feet.
Page 10
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued " Note: The four wood screws provided should be replaced with appropriate fasteners for stucco, brick, concrete or other types of sidings. IMPORTANT: Figure 11 - Installing Siding Standoff (Combustible Exterior) "...
Page 11
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued " " Figure 13 - Typical Horizontal Termination Cap Mounting with Additional Siding Standoff Installed IMPORTANT: NOTICE: Do not seal termination Round Termination Figure 14 - Horizontal Termination WARNING: Never run vent Termination downward as this may cause www.fmiproducts.com...
Page 12
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued 90° Elbow www.fmiproducts.com 116646-01J...
Page 13
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued Horizontal (H Horizontal (H with Termination at 90° with Fireplace www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued INSTALLATION FOR VERTICAL TERMINATION Note: Vertical restrictor must be installed in all vertical installations. Note: Pay special attention to these installation instructions for required clearances (air space) to combustibles when passing through ceilings, walls, roofs, enclosures, attic rafters, etc.
Page 15
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued Note: You must increase vent height for steep roof pitches. Nearby roofs and other similar factors may cause poor draft or down-drafting in high winds. Increasing vent height may solve this problem.
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued 12" Figure 25 - Recommended 12" Extension for High Altitude Installation Note: Install restrictor into inner AND COMPONENTS as shown. PA58-712 E58-45 45 With No Horizontal Run (Vertical Round High Wind Termination Shown) HIGH ALTITUDE INSTALLATION IMPORTANT: For horizontal installations www.fmiproducts.com...
All manuals and user guides at all-guides.com VENTING INSTALLATION Continued ST-58-36 FIREPLACE INSTALLATION Accessories INSTALLING OPTIONAL BLOWER ACCESSORY electrical outlet installed in the Figure 26 - Blower Model BK www.fmiproducts.com 116646-01J...
Page 18
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued Figure 28 - Location of Wiring Diagram Decal (Model May Vary From Illustration) Note: When installing BKT thermostati- thermal switch bracket to blower if it has not already been factory installed. Note: Figure 27 - Attaching Speed Control to Firebox...
Page 19
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued Variable Fan Switch Fan Switch (N.O.) Black 110/115 Blue V.A.C. Black Blower Motor White Green Figure 30 - Blower Wiring Diagram for Thermostat-Controlled Models Figure 29 - Blower Model BKT www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued INSTALLING GAS PIPING TO FIREPLACE LOCATION CAUTION: Use only new, WARNING: For natural IMPORTANT: Installation Items Needed Figure 31 - External Regulator with Vent Pointing Down (Propane/LP Only) www.fmiproducts.com 116646-01J...
Page 21
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued Natural to Millivolt Valve and connections, internal and external to unit, for leaks after PRESSURE TESTING GAS SUPPLY PIPING SYSTEM CONNECTING FIREPLACE TO GAS SUPPLY Installation Items Needed Checking Gas Connections www.fmiproducts.com 116646-01J...
Page 22
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued PRESSURE TESTING FIREPLACE GAS CONNECTIONS Operation To Turn Off Gas to Appliance INSTALLING OPTIONAL WALL Figure 34 - Equipment Shutoff Valve Figure 37 - Connecting Wall Switch to Control Valve www.fmiproducts.com 116646-01J...
Page 23
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued INSTALLING OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL Figure 40 - Installing Battery in Hand- REMOVING/REPLACING GLASS DOOR Replacement Parts Figure 38 - Attaching Alkaline Battery to Receiver To Wall Thermostat Figure 39 - Control Valve Terminals Held Remote Control Unit Figure 41 - Removing Louver Panel www.fmiproducts.com...
Page 24
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued CAUTION: Always handle Removing/Replacing Glass Door Removing Louver Panels Unlock Lock Door Cleaning and Maintenance Figure 43 - Installing Rear Brick Panel www.fmiproducts.com 116646-01J...
Page 25
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued Removing Glass Door Figure 45 - Installing Log No. 1 Figure 44 - Installing Side Brick Panels AND GLOWING EMBERS Figure 46 - Installing Log No. 2 Removing Glass Door Figure 47 - Installing Log No.
All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued Removing Glass Door Figure 49 - Installing Logs No. 5 and No. 6 Figure 50 - Placing Ember Material on Figure 48 - Installing Log No. 4 Burner OPERATION FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS READ BEFORE LIGHTING WARNING: If you do not fol-...
All manuals and user guides at all-guides.com OPERATION Continued LIGHTING TO TURN OFF GAS INSTRUCTIONS TO APPLIANCE MANUAL LIGHTING PROCEDURE Removing/Re- placing Glass Door Lighting Instructions Lighting Instructions Removing/Re- placing Glass Door OPTIONAL HAND-HELD REMOTE OPERATION Note: All remote control accessories must be purchased separately (see Accessories, page 37).
Page 28
All manuals and user guides at all-guides.com OPERATION Continued Manual Mode Control Knob and Variable Control Knob for Remote Operation ON/OFF SERIES Note: Do not leave the hand-held remote in in the center of the room facing towards the Note: Do not hold the hand-held remote for a long time.
All manuals and user guides at all-guides.com OPERATION Continued Auto Shutoff Feature IMPORTANT: OPERATING OPTIONAL BLOWER ACCESSORY OPERATING OPTIONAL GWMT1 WALL MOUNTED THERMOSTAT WARNING: Do not con- Lighting Instructions INSPECTING BURNERS PILOT ASSEMBLY Figure 55 - Pilot Assembly www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com INSPECTING BURNERS Continued To Turn Off Gas to Appliance To Turn Off Gas to Troubleshooting Appliance, Troubleshooting BURNER FLAME PATTERN Figure 56 - Typical Flame Pattern CLEANING AND MAINTENANCE WARNING: Do not use GLASS DOOR Removing/Replacing Glass Door (see Replacement Parts...
All manuals and user guides at all-guides.com CLEANING AND MAINTENANCE Continued LOGS Installing Logs, Lava Rock and Glowing Embers Replacement Parts Removing/Replacing Glass Replacement Parts Door VENTING SYSTEM CAUTION: Do not vacuum if Replace- ment Parts Remov- ing/Replacing Glass Door unlatched, removed, cracked PILOT AND BURNERS www.fmiproducts.com...
All manuals and user guides at all-guides.com TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Cleaning and Maintenance www.fmiproducts.com 116646-01J...
Page 33
All manuals and user guides at all-guides.com TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Cleaning and Maintenance Cleaning and Maintenance Cleaning and Maintenance Cleaning and Maintenance www.fmiproducts.com 116646-01J...
Page 34
All manuals and user guides at all-guides.com TROUBLESHOOTING Continued POSSIBLE CAUSE OBSERVED PROBLEM REMEDY Cleaning and Maintenance, Light- ing Instructions Cleaning and Maintenance, Checking Gas Con- nections www.fmiproducts.com 116646-01J...
Page 35
All manuals and user guides at all-guides.com TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Checking Gas Con- nections Checking Gas Con- nections Checking Gas Con- nections Installing Logs, Lava Rock a n d G l o w i n g E m b e r s www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com REPLACEMENT PARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. SERVICE HINTS TECHNICAL SERVICE When Gas Pressure Is Too Low SPECIFICATIONS " " www.fmiproducts.com 116646-01J...
Page 37
All manuals and user guides at all-guides.com ACCESSORIES NOTICE: All accessories may THERMOSTATICALLY- PROPANE/NATURAL GAS RECEIVER AND HAND-HELD THERMOSTAT REMOTE CONTROL (Rolled Louvers DEFLECTION HOOD RECEIVER AND HAND-HELD ON/OFF WALL MOUNTED THERMOSTAT WALL MOUNTED ON/OFF SWITCH www.fmiproducts.com 116646-01J...
Page 38
All manuals and user guides at all-guides.com PARTS 22-3 22-5 22-4 22-6 22-2 22-1 www.fmiproducts.com 116646-01J...
Page 39
All manuals and user guides at all-guides.com PARTS Replacement Parts PART NUMBER DESCRIPTION 108892-01 108892-01 108892-02 108892-02 109155-01 108903-01 109155-02 108903-02 108885-01 108885-01 108885-02 108885-02 108890-01 108890-01 109082-03 109082-03 108897-01 108897-01 108901-01 108901-01 108901-02 108901-02 11418 11418 12125 12125 109479-01 109479-01 14123 14123...
Page 40
All manuals and user guides at all-guides.com PARTS www.fmiproducts.com 116646-01J...
Page 41
All manuals and user guides at all-guides.com PARTS Replacement Parts DESCRIPTION 11102 11105 11179 11237 14389 14390 117370-01 14492 14500 14253 14511 10 14528 104506-25 104506-02 12 104509-02 13 26808 14 26827 15 108886-01 16 108891-01 17 108084-02 108084-03 108084-05 19 27113 www.fmiproducts.com 116646-01J...
All manuals and user guides at all-guides.com WARRANTY KEEP THIS WARRANTY _____________________________ __________________________ __________________________ FMI PRODUCTS, LLC LIMITED WARRANTIES New Products Standard Warranty: Factory Reconditioned Products Limited Warranty: Terms Common to All Warranties 116646-01 1-866-328-4537 www.fmiproducts.com...
Need help?
Do you have a question about the VT32N-A Series and is the answer not in the manual?
Questions and answers