FMI Tudor T32N-A Series Owner's Operation And Installation Manual
Hide thumbs
Also See for Tudor T32N-A Series:
- Owner's operation and installation manual (44 pages) ,
- Owner's operation and installation manual (44 pages) ,
- Owner's operation and installation manual (44 pages)
Table of Contents
Advertisement
Quick Links
DIRECT-VENT FIREPLACE
OWNER'S OPERATION AND INSTALLATION MANUAL
PFS
®
C
US
NATURAL GAS "TUDOR" MODELS (V)T32N-A SERIES,
CGDV32NR AND CTDV32NR-HA
PROPANE/LP GAS "TUDOR" MODELS (V)T32P-A SERIES
AND CGDV32PR
WARNING: If the information in this manual is not
— WHAT TO DO IF YOU SMELL GAS
-
For more information, visit www.fmiproducts.com
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for FMI Tudor T32N-A Series
Summary of Contents for FMI Tudor T32N-A Series
- Page 1 DIRECT-VENT FIREPLACE OWNER’S OPERATION AND INSTALLATION MANUAL ® NATURAL GAS “TUDOR” MODELS (V)T32N-A SERIES, CGDV32NR AND CTDV32NR-HA PROPANE/LP GAS “TUDOR” MODELS (V)T32P-A SERIES AND CGDV32PR WARNING: If the information in this manual is not — WHAT TO DO IF YOU SMELL GAS For more information, visit www.fmiproducts.com...
- Page 2 TABLE OF CONTENTS SAFETY State of Massachusetts: The installation must alteration, service or maintenance can cause the Commonwealth of for correct installation chemicals known to the State additional information of California to cause cancer or stalled in an aftermarket,* www.fmiproducts.com 116646-01J...
- Page 3 SAFETY Continued Do not use any solid fuels (wood, dren when they are in the room adults away from hot surfaces to www.fmiproducts.com 116646-01J...
-
Page 4: Product Identification
SAFETY Continued National Electrical Code, ANSI/NFPA 70 Cleaning and Maintenance PRODUCT IDENTIFICATION Figure 1 - Direct-Vent Fireplace with Millivolt Ignition LOCAL CODES National Fuel Gas Code ANSI Z223.1/NFPA 54* PRODUCT FEATURES www.fmiproducts.com 116646-01J... -
Page 5: Pre-Installation Preparation
PRODUCT FEATURES Continued PRE-INSTALLATION PREPARATION LOCATION AND SPACE REQUIREMENTS High Altitude Installation Figure 2 - Common Fireplace Locations " " " Figure 3 - Fireplace Bottom Dimensions CLEARANCES www.fmiproducts.com 116646-01J... -
Page 6: Framing And Finishing
PRE-INSTALLATION PREPARATION Continued " " " " " " " Nailing Tabs " Figure 5 - Framing Clearances for Corner Installation FRAMING AND FINISHING Wall Accessories Top of Louver Opening Note: Noncombustible mantels may discolor! Mantel from Mantel 14" 16" "... -
Page 7: Location Of Termination Cap
LOCATION OF TERMINATION CAP Fixed Openable Fixed Closed Closed Openable TERMINATION CAP GAS METER RESTRICTED AREA AIR SUPPLY INLET (TERMINATION PROHIBITED) A = clearance above grade, veranda, porch, deck, or I = clearance to service regulator vent outlet [*72" (182.9 cm) balcony [*12"... -
Page 8: Venting Installation
VENTING INSTALLATION NOTICE: Read these instruc- WARNING: Read all instruc- Failure to do so could result in NOTICE: Failure to follow these in- INSTALLATION PRECAUTIONS www.fmiproducts.com 116646-01J... -
Page 9: Installation Planning
VENTING INSTALLATION Continued INSTALLATION PLANNING Horizontal Termination Installation IMPORTANT: WARNING: Do not recess Figure 8 - Vent Pipe Connections Vent Opening Combustible Wall " Inside Framing Twist-Lock Procedure: " " (Framing Note: Horizontal runs of Detail) Vent Opening vent must be supported every three feet. Noncombustible Wall Use wall straps for this purpose. - Page 10 VENTING INSTALLATION Continued " Note: The four wood screws provided should be replaced with appropriate fasteners for stucco, brick, concrete or other types of sidings. IMPORTANT: Figure 11 - Installing Siding Standoff (Combustible Exterior) " Figure 10 - Installing Horizontal Vent Cap (Noncombustible Exterior) Figure 12 - Connecting Vent Cap with Horizontal Vent Pipe...
- Page 11 VENTING INSTALLATION Continued " " Figure 13 - Typical Horizontal Termination Cap Mounting with Additional Siding Standoff Installed IMPORTANT: NOTICE: Do not seal termination Round Termination Figure 14 - Horizontal Termination WARNING: Never run vent Termination downward as this may cause www.fmiproducts.com 116646-01J...
- Page 12 VENTING INSTALLATION Continued 90° Elbow www.fmiproducts.com 116646-01J...
- Page 13 VENTING INSTALLATION Continued Horizontal (H Horizontal (H with Termination at 90° with Fireplace www.fmiproducts.com 116646-01J...
-
Page 14: Installation For Vertical Termination
VENTING INSTALLATION Continued INSTALLATION FOR VERTICAL TERMINATION Note: Vertical restrictor must be installed in all vertical installations. Note: Pay special attention to these installation instructions for required clearances (air space) to combustibles when passing through ceilings, walls, roofs, enclosures, attic rafters, etc. Do not pack air spaces with insulation. - Page 15 VENTING INSTALLATION Continued Note: You must increase vent height for steep roof pitches. Nearby roofs and other similar factors may cause poor draft or down-drafting in high winds. Increasing vent height may solve this problem. Note: If vent pipe passes through any occu- Note: Install restrictor into inner collar of spaces and closets, you must enclose pipe.
-
Page 16: High Altitude Installation
VENTING INSTALLATION Continued 12" Figure 25 - Recommended 12" Extension for High Altitude Installation Note: Install restrictor into inner as shown. AND COMPONENTS PA58-712 E58-45 45 With No Horizontal Run (Vertical Round High Wind Termination Shown) HIGH ALTITUDE INSTALLATION IMPORTANT: For horizontal installations www.fmiproducts.com 116646-01J... -
Page 17: Fireplace Installation
VENTING INSTALLATION Continued ST-58-36 FIREPLACE INSTALLATION Accessories INSTALLING OPTIONAL BLOWER ACCESSORY electrical outlet installed in the Figure 26 - Blower Model BK www.fmiproducts.com 116646-01J... - Page 18 FIREPLACE INSTALLATION Continued Figure 28 - Location of Wiring Diagram Decal (Model May Vary From Illustration) Note: When installing BKT thermostati- thermal switch bracket to blower if it has not already been factory installed. Note: Figure 27 - Attaching Speed Control to Firebox www.fmiproducts.com 116646-01J...
- Page 19 FIREPLACE INSTALLATION Continued Variable Fan Switch Fan Switch (N.O.) Black 110/115 Blue V.A.C. Black Blower Motor White Green Figure 30 - Blower Wiring Diagram for Thermostat-Controlled Models Figure 29 - Blower Model BKT www.fmiproducts.com 116646-01J...
-
Page 20: Installing Gas Piping To Fireplace Location
FIREPLACE INSTALLATION Continued INSTALLING GAS PIPING TO FIREPLACE LOCATION CAUTION: Use only new, WARNING: For natural IMPORTANT: Installation Items Needed Figure 31 - External Regulator with Vent Pointing Down (Propane/LP Only) www.fmiproducts.com 116646-01J... -
Page 21: Connecting Fireplace To Gas Supply
FIREPLACE INSTALLATION Continued Natural to Millivolt Valve and connections, internal and external to unit, for leaks after PRESSURE TESTING GAS SUPPLY PIPING SYSTEM CONNECTING FIREPLACE TO GAS SUPPLY Installation Items Needed Checking Gas Connections www.fmiproducts.com 116646-01J... - Page 22 FIREPLACE INSTALLATION Continued PRESSURE TESTING FIREPLACE GAS CONNECTIONS Operation To Turn Off Gas to Appliance INSTALLING OPTIONAL WALL Figure 34 - Equipment Shutoff Valve Figure 37 - Connecting Wall Switch to Control Valve www.fmiproducts.com 116646-01J...
-
Page 23: Replacement Parts
FIREPLACE INSTALLATION Continued INSTALLING OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL Figure 40 - Installing Battery in Hand- REMOVING/REPLACING GLASS DOOR Replacement Parts Figure 38 - Attaching Alkaline Battery to Receiver To Wall Thermostat Figure 39 - Control Valve Terminals Held Remote Control Unit Figure 41 - Removing Louver Panel www.fmiproducts.com 116646-01J... - Page 24 FIREPLACE INSTALLATION Continued CAUTION: Always handle Removing/Replacing Glass Door Removing Louver Panels Unlock Lock Door Cleaning and Maintenance Figure 43 - Installing Rear Brick Panel www.fmiproducts.com 116646-01J...
- Page 25 FIREPLACE INSTALLATION Continued Removing Glass Door Figure 45 - Installing Log No. 1 Figure 44 - Installing Side Brick Panels AND GLOWING EMBERS Figure 46 - Installing Log No. 2 Removing Glass Door Figure 47 - Installing Log No. 3 www.fmiproducts.com 116646-01J...
-
Page 26: For Your Safety Read Before Lighting
FIREPLACE INSTALLATION Continued Removing Glass Door Figure 49 - Installing Logs No. 5 and No. 6 Figure 50 - Placing Ember Material on Figure 48 - Installing Log No. 4 Burner OPERATION FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS READ BEFORE LIGHTING WARNING: If you do not fol- low these instructions exactly,... -
Page 27: Lighting Instructions
OPERATION Continued LIGHTING TO TURN OFF GAS INSTRUCTIONS TO APPLIANCE MANUAL LIGHTING PROCEDURE Removing/Re- placing Glass Door Lighting Instructions Lighting Instructions Removing/Re- placing Glass Door OPTIONAL HAND-HELD REMOTE OPERATION Note: All remote control accessories must be purchased separately (see Accessories, page 37). - Page 28 OPERATION Continued Manual Mode Control Knob and Variable Control Knob for Remote Operation ON/OFF SERIES Note: Do not leave the hand-held remote in in the center of the room facing towards the Note: Do not hold the hand-held remote for a long time.
-
Page 29: Inspecting Burners
OPERATION Continued Auto Shutoff Feature IMPORTANT: OPERATING OPTIONAL BLOWER ACCESSORY OPERATING OPTIONAL GWMT1 WALL MOUNTED THERMOSTAT WARNING: Do not con- Lighting Instructions INSPECTING BURNERS PILOT ASSEMBLY Figure 55 - Pilot Assembly www.fmiproducts.com 116646-01J... -
Page 30: Burner Flame Pattern
INSPECTING BURNERS Continued To Turn Off Gas to Appliance To Turn Off Gas to Troubleshooting Appliance, Troubleshooting BURNER FLAME PATTERN Figure 56 - Typical Flame Pattern CLEANING AND MAINTENANCE WARNING: Do not use GLASS DOOR Removing/Replacing Glass Door (see Replacement Parts www.fmiproducts.com 116646-01J... -
Page 31: Venting System
CLEANING AND MAINTENANCE Continued LOGS Installing Logs, Lava Rock and Glowing Embers Replacement Parts Removing/Replacing Glass Replacement Parts Door VENTING SYSTEM CAUTION: Do not vacuum if Replace- ment Parts Remov- ing/Replacing Glass Door unlatched, removed, cracked PILOT AND BURNERS www.fmiproducts.com 116646-01J... -
Page 32: Troubleshooting
TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Cleaning and Maintenance www.fmiproducts.com 116646-01J... - Page 33 TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Cleaning and Maintenance Cleaning and Maintenance Cleaning and Maintenance Cleaning and Maintenance www.fmiproducts.com 116646-01J...
- Page 34 TROUBLESHOOTING Continued POSSIBLE CAUSE OBSERVED PROBLEM REMEDY Cleaning and Maintenance, Light- ing Instructions Cleaning and Maintenance, Checking Gas Con- nections www.fmiproducts.com 116646-01J...
- Page 35 TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Checking Gas Con- nections Checking Gas Con- nections Checking Gas Con- nections Installing Logs, Lava Rock a n d G l o w i n g E m b e r s www.fmiproducts.com 116646-01J...
-
Page 36: Replacement Parts
REPLACEMENT PARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. SERVICE HINTS TECHNICAL SERVICE When Gas Pressure Is Too Low SPECIFICATIONS " " www.fmiproducts.com 116646-01J... - Page 37 ACCESSORIES NOTICE: All accessories may THERMOSTATICALLY- PROPANE/NATURAL GAS RECEIVER AND HAND-HELD THERMOSTAT REMOTE CONTROL (Rolled Louvers DEFLECTION HOOD RECEIVER AND HAND-HELD ON/OFF WALL MOUNTED THERMOSTAT WALL MOUNTED ON/OFF SWITCH www.fmiproducts.com 116646-01J...
- Page 38 PARTS 22-3 22-5 22-4 22-6 22-2 22-1 www.fmiproducts.com 116646-01J...
- Page 39 PARTS Replacement Parts PART NUMBER DESCRIPTION 108892-01 108892-01 108892-02 108892-02 109155-01 108903-01 109155-02 108903-02 108885-01 108885-01 108885-02 108885-02 108890-01 108890-01 109082-03 109082-03 108897-01 108897-01 108901-01 108901-01 108901-02 108901-02 11418 11418 12125 12125 109479-01 109479-01 14123 14123 21171 21171 24353 24353 24460 24460 109222-01...
- Page 40 PARTS www.fmiproducts.com 116646-01J...
- Page 41 PARTS Replacement Parts DESCRIPTION 11102 11105 11179 11237 14389 14390 117370-01 14492 14500 14253 14511 14528 104506-25 104506-02 104509-02 26808 26827 108886-01 108891-01 108084-02 108084-03 108084-05 27113 www.fmiproducts.com 116646-01J...
- Page 42 NOTES _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ www.fmiproducts.com 116646-01J...
- Page 43 NOTES _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ _____________________________________________________ www.fmiproducts.com 116646-01J...
-
Page 44: Warranty
WARRANTY KEEP THIS WARRANTY _____________________________ __________________________ __________________________ FMI PRODUCTS, LLC LIMITED WARRANTIES New Products Standard Warranty: Factory Reconditioned Products Limited Warranty: Terms Common to All Warranties 116646-01 1-866-328-4537 www.fmiproducts.com...
Need help?
Do you have a question about the Tudor T32N-A Series and is the answer not in the manual?
Questions and answers