Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Champion Power Equipment 92251-1
Summary of Contents for Champion Power Equipment 92251-1
- Page 1 OWNER’S MANUAL 22 Ton LOG SPLITTER MODEL NUMBER 92251-1 12039 Smith Ave. SAVE THESE INSTRUCTIONS Santa Fe Springs CA 90670 Important Safety Instructions USA / 1-877-338-0999 MADE IN CHINA are included in this manual. www.championpowerequipment.com REV 92251-1-20161116...
- Page 2 AN IMPORTANT MESSAGE ABOUT TEMPERATURE: Your Champion Power Equipment product is designed and rated for continuous operation at ambient temperatures up to 40°C (104°F). When your product is needed your product may be operated at temperatures ranging from -15°C (5°F) to 50°C (122°F) for short periods.
-
Page 3: Table Of Contents
92251-1 22 Ton LOG SPLITTER TABLE OF CONTENTS Introduction ......Maintenance and Storage . -
Page 4: Introduction
ENGLISH INTRODUCTION Congratulations on your purchase of a Champion Power Equipment product. Champion Power Equipment and Champion Engine Technology designs, builds, and supports all of our products to strict specifications and guidelines. With proper product knowledge, safe use, and regular maintenance, this product should bring years of satisfying service. -
Page 5: Manual Conventions
92251-1 ENGLISH MANUAL CONVENTIONS This manual uses the following symbols to help differentiate between different kinds of information. The safety symbol is used with a key word to alert you to potential hazards in operating and owning power equipment. Follow all safety messages to avoid or reduce the risk of serious injury or death. -
Page 6: Safety Rules
92251-1 ENGLISH SAFETy RULES WARNING DANGER Read this manual thoroughly before operating your Sparks can result in fire or electrical shock. log splitter. Failure to follow instructions could result in serious injury or death. When servicing the engine: Disconnect the spark plug wire and place it where it cannot contact the plug. - Page 7 92251-1 ENGLISH SAFETy RULES DANGER DANGER Fuel and fuel vapours are highly flammable and Skin Injection Hazard. High pressure hydraulic oil extremely explosive. can inject under your skin. Fire or explosion can cause severe burns or death. Unintentional startup can result in entanglement, Make sure all fittings are tightly secure before traumatic amputation or laceration.
-
Page 8: Training
92251-1 ENGLISH SAFETy RULES Training Preparation 1. Read the Operator’s Manual completely before 1. Be thoroughly familiar with all controls and with attempting to use this log splitter. proper use of the equipment. 2. Do not allow anyone to operate your log splitter who 2. -
Page 9: Operation
92251-1 ENGLISH SAFETy RULES Operation Maintenance and Storage 1. Before starting this log splitter, review all safety 1. Always shut off the power source while repairing or rules. Failure to follow these rules may result in adjusting the splitter except as recommended by the serious injury to the operator or bystanders. -
Page 10: Controls And Features
92251-1 ENGLISH CONTROLS AND FEATURES Read this owner’s manual before operating your log splitter. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. Log Splitter 2 in. (5.1 cm) Ball Coupler – For towing the log Engine –... -
Page 11: Assembly
92251-1 ENGLISH ASSEMBLy 2) Install the Wheels Cont’d. Your log splitter is requires some assembly. If you have any questions regarding the assembly of your NOTE log splitter, call our help line at 1-877-338-0999. Please have your serial number and model number available. -
Page 12: Install The Cylinder And Wedge
92251-1 ENGLISH ASSEMBLy 3) Install the Beam Cont’d. 4) Install the Cylinder and Wedge Cont’d. 3. Slowly lift the front of the tow bar to roll the frame NOTE toward the beam and carefully align the pivot holes on the bottom of the beam and the top of the The cylinder will support itself when slid all the way back into the mounting slots. -
Page 13: Install The Engine And Hoses
92251-1 ENGLISH ASSEMBLy 6) Install the Engine and Hoses 6) Install the Engine and Hoses Cont’d. 1. Attach the engine/pump to the engine mounting plate on the hydraulic oil tank. (A) 2. Place O-ring into the outlet fitting on the top of the pump. -
Page 14: Add Engine Oil
92251-1 ENGLISH ASSEMBLy Add Hyrdraulic Oil Cont’d. Add Engine Fuel hole away from the operator zone. 1. Use clean, fresh, regular unleaded fuel with a 6. Start Engine. Extend and retract the wedge to purge minimum octane rating of 85 and an ethanol content of less than 10% by volume. -
Page 15: Operation
92251-1 ENGLISH OPERATION Before Each Use Inspect the Log Splitter Log Splitter Location Cont’d. 1. Check the hydraulic oil level and visually inspect all hoses, attachments and cylinder for loose fittings, leaks, cracks, fraying or other damage. 2. DO NOT operate the log splitter if there is any indication of damage. -
Page 16: Starting The Engine
92251-1 ENGLISH OPERATION Log Splitter Location Cont’d. Starting the Engine Cont’d. Starting the Engine Cont’d. WARNING NOTE If the engine starts, but does not run, make certain ALWAYS use the log splitter for its intended use. The that the log splitter is on a flat, level surface. The... -
Page 17: Log Splitter Operation
92251-1 ENGLISH OPERATION Log Splitter Operation 1. ALWAYS wear ear and eye protection, protective clothing and safety gear. 2. Block tires and put both support legs in the DOWN position to prevent unintended movement of the log splitter during operation. -
Page 18: Maintenance And Storage
92251-1 ENGLISH MAINTENANCE AND STORAGE Oil Cont’d. The owner/operator is responsible for all periodic maintenance. DIPSTICK WARNING Never operate a damaged or defective log splitter. WARNING FILL FILL Improper maintenance will void your warranty. NOTE Spark Plugs For service or parts assistance, contact our help line 1. -
Page 19: Changing The Hydraulic Oil And Oil Filter
92251-1 ENGLISH MAINTENANCE AND STORAGE Changing the Hydraulic Oil and Oil Filter Changing the Hydraulic Oil and Oil Filter Cont’d. 10. Turn the fuel valve on, and start the engine. Purge NOTE the air from the system by extending and retracting Install a new hydraulic oil filter each time the the wedge several times until the motion is smooth. -
Page 20: Cleaning
Every 200 hours or per 2 years slowly to distribute the oil and lubricate the cylinder. Check/replace fuel line 9. Reattach the spark plug. Change spark plug *To be performed by knowledgeable, experienced owners or Champion Power Equipment certified dealers. - Page 21 92251-1 ENGLISH Log Splitter Storage Cont’d. WARNING Never store the log splitter inside next to appliances where there is a source of heat or open flame, spark or pilot light because they can ignite gasoline vapours. DO NOT store a log splitter near fertilizer or any corrosive material.
-
Page 22: Troubleshooting
92251-1 ENGLISH TROUBLESHOOTING Problem Cause Solution Engine will not start No fuel Add fuel Faulty spark plug Replace spark plug Unit loaded during startup Remove load from unit Engine starts but runs roughly Low oil level Fill crankcase to the proper level... -
Page 23: Specifications
92251-1 ENGLISH SPECIFICATIONS Hydraulic Oil System Log Splitter Specifications Oil capacity is 5 gallons (18.9 L). – Ram Force ...... -
Page 24: Parts Diagram
92251-1 ENGLISH SPECIFICATIONS Parts Diagram... -
Page 25: Parts List
92251-1 ENGLISH Parts List Part number Description Part number Description PMJ22J-02-00 Beam GB/T 77-2000 Screw M6×10 GB/T 5782-2000 BOLT M12×75(12.9) PMJ22G-26 Gear Pump Connector PMJ22J-04-00 Wedge Slide ASME B18.2.1 1996 Bolt 5/16 in.-24×1 in. GB/T 95-2000 Washer ø12 PMJ22G-29 Engine Bushing GB/T 889.1-2000... -
Page 26: Engine Parts Diagram
92251-1 ENGLISH SPECIFICATIONS Engine Parts Diagram... -
Page 27: Engine Parts List
92251-1 ENGLISH Engine Parts List Part Number Description Part Number Description B057890006001670X Flange Bolt M6×16,White 14311-LC90-0000CD Dipstick Assembly 11221-LC90-0500 Valve Cover B057890008003270X Flange Bolt M8×32,White 12104-KB01-0200 Breather Hose Assembly 12007-LG10-0700 Crankcase 90229-KB01-0400 Valve Cover Gasket 91302-91001516000 Washer 15400-LC90-0001 Rocker Arm Assembly... - Page 28 Warranty Qualifications – Failures due to acts of God and other force majeure events Champion Power Equipment (CPE) will register this warranty upon beyond the manufacturer’s control. receipt of your Warranty Registration Card and a copy of your sales –...
- Page 29 United States Environment Protection Agency (U.S. EPA) Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with U.S. EPA emission regulations. YOUR WARRANTY RIGHTS AND OBLIGATIONS: The US EPA AND CPE are pleased to explain the Federal Emission Control Systems Warranty on your 2016 small off-road engine and engine powered equipment.
- Page 30 EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System (ECS) Warranty Coverage. 1. APPLICABILITY: This warranty shall apply to 1997 and later model year small off-road engines. The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
- Page 31 You must take your CPE engine or the product on which it is installed, along with your warranty registration card or other proof of original purchase date, at your expense, to any Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc. to sell and service that CPE product during his normal business hours.
Need help?
Do you have a question about the 92251-1 and is the answer not in the manual?
Questions and answers
How can I get 2 log craddle for my splitter 92251. Unable to as a picture of the parts