Related Manuals for Nilfisk-Advance BR 850S SBG SPECIAL 56380630 850SC
Summary of Contents for Nilfisk-Advance BR 850S SBG SPECIAL 56380630 850SC
- Page 1 BR 850S SBG SPECIAL Instructions For Use MODELS 56380630(850SC) 6/09 FORM NO. 56041805 A-English Printed in USA...
-
Page 2: Table Of Contents
A-2 / ENGLISH TABLE OF CONTENTS page Introduction ................... A-2 Cautions and Warnings ................ A-3 Know Your Machine ................A-4 Control Panel ..................A-5 Prepare the Machine for Use Install the Batteries ................A-6 Install the Brushes ................A-7 Install the Squeegee ................A-7 Fill the Solution Tank ................ -
Page 3: Cautions And Warnings
ENGLISH / A-3 CAUTIONS AND WARNINGS SYMBOLS Nilfi sk uses the symbols below to signal potentially dangerous conditions. Always read this information carefully and take the necessary steps to protect personnel and property. DANGER! Is used to warn of immediate hazards that will cause severe personal injury or death. WARNING! Is used to call attention to a situation that could cause severe personal injury. -
Page 4: Know Your Machine
A-4 / ENGLISH KNOW YOUR MACHINE As you read this manual, you will occasionally run across a bold number or letter in parentheses - example: (2). These numbers refer to an item shown on these pages unless otherwise noted. Refer back to these pages whenever necessary to pinpoint the location of an item mentioned in the text. NOTE: Refer to the service manual for detailed explanations of each item illustrated on the next 2 pages. - Page 5 ENGLISH / A-5 CONTROL PANEL Key Switch Scrub OFF Indicator Battery Condition Indicator Scrub OFF Switch Speed Select Switch Scrub Pressure Decrease Indicator Speed Select Indicator Scrub Pressure Decrease Switch Horn Switch Scrub Pressure Increase Indicator Vacuum Switch Scrub Pressure Increase Switch Vacuum System Indicator Scrub Pressure / Hourmeter Display Solution System Indicator...
-
Page 6: Install The Batteries
A-6 / ENGLISH DESCRIPTION OF THE BATTERY CONDITION INDICATORS The battery condition indicator (K) consists of three lights, a green, a yellow, and a red. The voltage indication will change based on the cutoff level (standard or alternate) selected in the control unit. The battery voltage ranges for the various indications are listed below: Standard Alternate Green... -
Page 7: Install The Brushes
ENGLISH / A-7 INSTALL THE BRUSHES CAUTION! Turn the key switch off (O) and remove the key, before changing the brushes, and before opening any access panels. Make sure the Key Switch (J) is off (O). To access the brushes, swing both side skirt assemblies open. Note: The skirts are held in place by a large cotter pin on each side, remove the pins and swing the skirt assemblies out of the way. -
Page 8: Detergent (Eds™) System
A-8 / ENGLISH DETERGENT SYSTEM PREPARATION AND USE (EDS MODELS ONLY) COMMON INSTRUCTIONS: NON-DISPOSABLE CARTRIDGE SPECIFIC INSTRUCTIONS: The system should be purged of previous detergent when switching to a different Fill the detergent cartridge with a maximum of 1.25 gallons (4.73 Liters) of detergent. detergent. - Page 9 ENGLISH / A-9 DETERGENT SYSTEM PREPARATION AND USE (EDS MODELS ONLY) FRONT FORM NO. 56041805 - BR 850S SBG SPECIAL - A-9...
-
Page 10: Operating The Machine
A-10 / ENGLISH OPERATING THE MACHINE WARNING! Be sure you understand the operator controls and their functions. While on ramps or inclines, avoid sudden stops when loaded. Avoid abrupt sharp turns. Use low speed down hills. Clean only while ascending (driving up) the ramp. To Scrub... -
Page 11: After Use
ENGLISH / A-11 AFTER USE When fi nished scrubbing, press the Scrub Off Switch (B) twice, this will automatically raise, retract and stop all the machine systems (brush, squeegee, vacuum, solution and detergent (EDS models)). Then drive the machine to a service area for daily maintenance and review of other needed service up keep. -
Page 12: Charging The Batteries
A-12 / ENGLISH CHARGING THE BATTERIES Charge the batteries each time the machine is used, or whenever the Battery Condition Meter (K) is showing a yellow , red or fl ashing red indicator light(s). To Charge the Batteries... Depress the Battery Disconnect (13). Open the Battery Compartment Cover (16) to provide proper ventilation. -
Page 13: Squeegee Maintenance
ENGLISH / A-13 SQUEEGEE MAINTENANCE If the squeegee leaves narrow streaks or water, the blades may be dirty or damaged. Remove the squeegee, rinse it under warm water and inspect the blades. Reverse or replace the blades if they are cut, torn, wavy or worn. To Reverse or Replace the Rear Squeegee Wiping Blade... -
Page 14: Side Skirt Maintenance
A-14 / ENGLISH SIDE SKIRT MAINTENANCE The side skirts function is to channel the waste water to the squeegee, helping contain the water within the machines cleaning path. During normal use the blades will wear in time. The operator will notice a small amount of water leaking out underneath the side skirts. Skirt height adjustment is automatic on this system. -
Page 15: Troubleshooting
ENGLISH / A-15 GENERAL MACHINE TROUBLESHOOTING Problem Possible Cause Remedy Poor water pick-up Worn or torn squeegee blades Reverse or replace Squeegee out of adjustment Adjust so blades touch fl oor evenly across entire width Recovery tank full Empty recovery tank Recovery tank drain hose leak Secure drain hose cap or replace Recovery tank cover gasket leak... -
Page 16: Technical Specifi Cations
A-16 / ENGLISH TECHNICAL SPECIFICATIONS (as installed and tested on the unit) Model BR 850S SBG Special Model No. 56380630 Voltage, Batteries Battery Capacity Protection Grade IPX3 Sound Pressure Level (IEC 60704-1) dB(A)/20μPa Gross Weight lbs / kg 1,732 / 785 Vibrations at the Hand Controls 1.12m/s (ISO 5349-1) - Page 17 Инструкция по использованию низких напряжений: 73/23/EEC 93/68/EEC Harmonizált szabványok: EN 60 335-2-72 Согласованные стандарты: EN 60 335-2-72 4.3.2004 . Larry Doerr, Vice President Operations Nilfisk-Advance, Inc. Nilfisk-Advance A/S 14600 21st Avenue North Sognevej 25 Plymouth, MN 55447 USA DK-2605 Brøndby, Denmark ©Nilfisk-Advance Incorporated, 4/05 pas...
- Page 18 Nilfi sk-Advance A/S Sognevej 25 DK-2605 Brøndby Denmark Tel: +45 43 23 81 00 Fax: +45 43 43 77 00 www.nilfi sk-advance.com...