Cal Flame G4 2008 Owner's Manual
  1. Manuals
  2. Brands
  3. Cal Flame Manuals
  4. Grill
  5. G4 2008
  6. Owner's manual

Cal Flame G4 2008 Owner's Manual

Barbecue grill
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
LTR20081050, Rev. B
8/4/08

Advertisement

Table of Contents
loading

Related Manuals for Cal Flame G4 2008

Summary of Contents for Cal Flame G4 2008

  • Page 1 LTR20081050, Rev. B 8/4/08...

  • Page 2: Table Of Contents

    Copyright 2008 LMS, Inc. All rights reserved. Duplication dealer immediately. If you need additional information without written consent is strictly prohibited. and/or assistance, please contact: Cal Flame™ is registered trademark. LMS Customer Service Department Due to continuous improvement programs, all models, op- 1462 East Ninth Street eration, and/or specifications are subject to change without Pomona, CA 91766.

  • Page 3: Safety Instructions

    • To prevent fire and smoke damage, remove all pack- • Cal Flame™ grills are not intended for installation in aging material before operating grill. or on recreational vehicles or boats. • Before you start cooking, clean the entire grill thor- •...

  • Page 4: Maintenance And Repair

    Safety Instructions Maintenance and Repair • Gas sources to the grill must be regulated. Do not operate grill if regulators have been removed, fire or • Spiders and other i nsects can nest in the burners of explosion can occur. the grill and block the gas and airflow to the burner •...

  • Page 5: Installation / Assembly

    Without it you will not be able to as fencing and/or self-closing gates on property to pre- attach your tank to your Cal Flame™ grill or refill the vent unsupervised access to the property by children tank at your local propane refill station.

  • Page 6: Leak Testing Procedure

    Installation / Assembly Leak Testing Procedure in the soap solution indicates that a leak is pres- Perform a leak test at least once a year whether the ent. gas supply cylinder has been disconnected or not. In Stop a leak by tightening the loose joint or by re- addition, whenever the gas cylinder is connected to the placing the faulty part with a replacement part rec- regulator or whenever any part of the gas system is...

  • Page 7: Natural Gas

    10 square inch- cess of 0.5 psi (3.5 kPa). es (64.5 cm²). Your Cal Flame™ grill for use with natural gas comes Ventilation openings shall be provided at floor equipped with its own regulator that MUST NOT be re- level and shall have a total free area of not less moved.

  • Page 8: Installing The Grill In A Barbecue Island

    Installation / Assembly Check the grill controls to ensure all control valves are in the full OFF position. Turn on the main gas supply and check all connec- tions for leaks using soapy water as described in the leak testing procedure section. Warning: If you see bubbles in the soapy solution at any of the connections, turn off the gas supply and tighten the connection.

  • Page 9: Using Your Grill

    Never put combustible material such as paper, cloth, grill. or flammable liquids on your grill at any time. Do not Remember to use your Cal Flame grill safely by follow- use grill or any area around grill to store flammable ing these reminders: materials.

  • Page 10: Lighting The Grill

    If you • Ensure the propane cylinder, regulator, and need a replacement hose, contact your Cal Flame rubber hose are installed in a location not dealer. subject to heating above 125º F (51º C) .

  • Page 11: Cleaning And Maintenance

    CLEANING ANY PART OF THE GRILL. our full length, zippered side canvas cover. (See your Burners local Cal Flame dealer for details.) The cover will help protect your grill from detrimental effects of weather and Spiders and small insects occasionally inhabit or make environmental pollutants.

  • Page 12: Appendix

    Appendix Appendix Troubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perform a leak test following the procedure described in this manual. Problem Burner does not ignite Solution Use the following procedure with the figure below. Check the position of the sparker tip.

  • Page 13: Replacement Cover

    • Replace all cotter pins. • Replace cooking components and grease collectors. If an obstruction is suspected in the control valve, contact your local Cal Flame dealer for assis- tance. Problem: Misalignment of Igniter on Burner Solution: •...

  • Page 14: Removing And Replacing Burners

    Appendix Removing and Replacing Burners Disconnect or shut off the gas line connect to the Carefully remove the locking pin with your fingers. grill. Wait until the burners cool down. Raise the stud from the locking hole and move the Open the hood and remove the grate and flame burner forward carefully to release it from the igni- tamer on top of the burner you want to replace.

  • Page 15: 2008 Warranty

    Extent of Warranty This 2008 Cal Flame Warranty is only valid on Cal Flame models delivered in the United States or Canada and extends through the selling dealer to the original purchaser at the original site of installation. This warranty becomes valid at time of purchase and ends either by specified time-frame listed above or upon owner transfer or reloca- tion.

  • Page 16: Location Of Serial Number Plate

    Locating the product serial number The serial number of your Cal Flame grill is located on the back and is visible when the hood is down. You will need this number to properly register your grill and activate coverage. Write this information in the space provided below.

Table of Contents