Roadtrek SS-Ideal Owner's Manual

Hide thumbs Also See for SS-Ideal:

Owner's manual (73 pages)

Table Of Contents

Table of Contents

Quick Links

Download this manual

SS-Ideal Model Owners Manual

Including

Limited Warranty Information

Table of Contents

Need help?

Do you have a question about the SS-Ideal and is the answer not in the manual?

Questions and answers

Summary of Contents for Roadtrek SS-Ideal

Page 1 SS-Ideal Model Owners Manual Including Limited Warranty Information...
Page 3 CUSTOMER SERVICE PROCEDURES OBTAINING MOTORHOME SERVICE The solution to all your Roadtrek concerns starts with your Roadtrek Dealer Roadtrek Dealer Dodge/Chrysler Dealer Roadtrek Dealer Advise the Service Department The dealership should always be given the that you have a opportunity to resolve your concerns prior to...
Page 4: Table Of Contents
Smoke Detector ________________________________________________________________________________________________ F-3 Fire Extinguisher ________________________________________________________________________________________________F-3 propane System Diagrams ________________________________________________________________________________________F-4 Water Systems ________________________________________________________________________________________________G-1 Water Heater Bypass System ______________________________________________________________________________________G-1 Fresh Water Tank Drain __________________________________________________________________________________________G-1 Fresh Water Tank________________________________________________________________________________________________G-2 Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 B - 1...
Page 5 Address, Phone & Facsimile Numbers, and E-mail ____________________________________________________________________ K-2 Website ______________________________________________________________________________________________________K-2 Roadtrek International Chapter FMCA / A Roadtrek Owners’ Club Membership Forms __________________________________ L-1 Change of Owner Name or Address Form ____________________________________________________________________ M-1 - M-2 Potential Customer Referral Card __________________________________________________________________________ M-3 - M-4...
Page 6: Introduction
This manual has been written to provide you with the information required to properly operate and maintain your new Roadtrek. After reading this manual, be sure to keep it in your vehicle as a reference. Your Roadtrek dealer will be glad to answer any further questions about the operation of your vehicle.
Page 7: Weight Ratings
4) Place wooden ramps below rear wheels, (using lift or driving onto ramps for levelling vehicle; N/A if commercial scales used). 5) Place scales under front wheels. 6) Record scale readings. 7) Repeat for rear wheels. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 8: Warnings And Cautions
If you do not read the entire manual you may miss important information. Please observe all Warnings & Cautions. Note: This manual applies only to the SS-Ideal model. Doc No: 21906550 Rev: 00...
Page 9 All passengers must be seated in these seats only, with the seat belts fastened while the vehicle is in motion. The flat screen TV should not be stored inside the Roadtrek in temperatures below -4°F, (-20°C). Remove it to reduce the chance of damage from the cold. The operating temperature of the monitor is recommended between 50°F and 104°F, (10°C and 40°C) with a humidity range of 10% to 80%, non...
Page 10 Ensure that the inverter is disconnected prior to disconnecting the auxiliary batteries. GENERATOR: When launching a boat using your Roadtrek, it is very important to note that the generator MUST NOT be submerged in water. When using the generator as the main power sorce to run the appliances, refer to the generator owners manual for proper use and maintinance.
Page 11: Appliance Log
Progressive Dynamics PD5110610 TV (Flat Screen) Viewsonic N1930W TV Antenna Winegard RV-7005 Water Heater Suburban SW6D Water Pump SHURflo 2088-403-144 Appliance manufacturers and model numbers subject to change without notice. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 12 Suburban Mfg. Elkhart, IN 423-775-2131 Water Heater, (Canada) Suburban c/o GL Products Oakville, ON 905-845-7558 Water/Macerator Pump, (U.S.) SHURflo Santa Ana, CA 800-854-3218 Water/Macerator Pump, (Cda) SHURflo Belmont, ON 519-727-6752 Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009A-5...
Page 13: Daily Living
6. Swivel the seats to the desired positions, (see Picture B-P3). 7. Once completed, you may lower the tilt steering wheel and adjust the recline and slide controls as desired. Picture B-P3: Captain seats slide bar. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 14: Slide Out Room Operation
30 seconds before trying again. There is an automatically resetting breaker in the system to Picture B-P5: Slideout in/out switch. protect the motor that needs to cool before it will reset. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 16: Dinette Table
Turn Button Picture B-P11: Ensure that the turn button is holding the table in place before driving Picture B-P12: Location of assembled dinette table at rear of cabin. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 17: Dashboard Radio/Dvd
Please see the Eclipse manual for radio operation. Picture B-P14: Placement of seat back for bed support. Eclipse radio iPod and USB connectors. Picture B-P15: Placement of cushions for slide out bed. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 18 4. AC and microwave 110 V receptacles.. position. Picture B-P20: TV can be viewed from the front seats also by rotating it.(Watch your head when Picture B-P19: TV in stored position. moving about the cabin) Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 19 Surround Sound (from the DVD player); off; or Automotive, for the automotive radio. Picture B-P23: Additional storage in A/V cabinet. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 B - 8...
Page 20: Washroom And Shower Area
“ON” position, (see Picture B-P26). Picture B-P25: Inside shower door latch (RS model). Picture B-P26: Bathroom exhaust vent. Picture B-P27: Front bathroom door, (in transit) locking pin in the locked position. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 21 DAILY LIVING WASHROOM (SS Model): The washroom door on the SS-Ideal model is somewhat different than that of the RS-Adventurous or SS-Agile (aside from being on the opposite side of the vehicle). The two door s are held closed by the exterior travel latch (Picture B-P24) to keep them out of the way when not in use.
Page 22: Washroom Facilities
3. Replace the floor drain plug when you are finished. other supplies). To prevent grey water tank contents from spilling onto the floor while driving, keep the drain plug secured when not in use. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 B-10...
Page 23: Extra Counter Space
This type of failure is not covered by the Roadtrek or Shurflo warranties. To keep the pump and waste valves lubricated, ShurFlo recommends running a small amount of mineral oil through the system periodically. Please see the ShurFlo manual for more.
Page 24: Exterior Access Doors
7. City water tank filling valve. 8. Shore power connector. 9. Propane Tank with fittings and connectors Warning: Before putting your Roadtrek into motion, ensure that the shore power cord, sewer discharge hose, TV cable, and the city water supply line are disconnected and are stored properly.
Page 25: Propane Access Door
(shown with right side in open position). door clips Picture B-P43: Rear storage area door clip location. Picture B-P44: Rear storage area door hold up clip. (Location may be slightly different) Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 B-13...
Page 26: Replacing The Auxiliary Battery
The Battery Separator (Picture B-P37C) performs this duty. Picture B-P47: Battery Separator and breakers Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 B-14...
Page 27 Remove jack storage compartment cover, (see picture B-P50). 3. Automotive tire jack, (stored position), (see picture B-P51). Picture B-P51: Automotive tire jack, (stored position). See the Sprinter Owners Manual for vehicle jacking locations. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 B-15...
Page 28: Bbq Quick Connect
Auto (the default position) (See Picture B-P54) Picture B-P53: BBQ propane supply line in-use location. Picture B-P54: Location of inverter and Auto-Off- Charge Only switch. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 B-16...
Page 29 !0 #$# '(!)"% !% // &* %1 ALL MASTER DRAWINGS, WHICH REPRESENT THE CURR REVISION, ARE STORED ELECTRONICALLY, AND ALL SUBSEQUENT COPIES ARE CONSIDERED UNCONTROLLE SS-Ideal Elevations Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 B -17...
Page 32: Inverter/Charger Shut Down
110 volt GFCI receptacle locations: Picture E-P1: 110V GFCI protected Picture E-P2: 110V GFCI receptacle, receptacles, (Galley location). (side entry door location). Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 33: Generator
The generator is located and accessed from the underside of the van behind the rear axle of your vehicle. CAUTION: When launching a boat, (using your Roadtrek), it is important to note that the generator must not be submerged in water. This will permanently damage the generator. If you cannot launch without submerging the generator, an alternate method would be to use a boat launching service.
Page 34: Monitor Panel
“good”. The panel also provides the switch for the water pump and a disconnect switch for the auxiliary batteries. Picture E-P7: Location of the crank up antenna handle. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 35: Auxiliary Batteries And Battery Separator
Refer to the Dodge Sprinter's Owner’s Manual for complete operation instructions. WATER HEATER : The Roadtrek is equipped with a propane fueled water heater. The water heater must be operated on propane but does require 12-volt power to operate the electronic circuitry. Please refer to the Suburban Owner’s Manual for complete operation instructions.
Page 37 Blue 18AWG To Fresh Water Tank (Exterior) Brown 22AWG Black 18AWG To Black Water Tank Grey 22AWG Grey 18AWG To Grey Water Tank Orange 22AWG Red 2AWG Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 E -7...
Page 38: Propane & Safety System
WARNING: Portable fuel burning equipment, including wood and charcoal grills and stoves, should not be used inside your vehicle. Use of this equipment inside your vehicle, may cause fire or asphyxiation. See appropriate component Manufacturer’s Owner’s Manuals for operating instructions. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 39: Refueling Procedures
See Manufacturer’s Owner’s Manual for other operating instructions. WARNING: Battery disconnect switch must be in the Picture F-P1: Propane/Carbon Monoxide detector. “ON” position for the detector to operate. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 40: Smoke Detector
Your vehicle is equipped with a Kidde fire extinguisher. This is located below the rear of the passenger side front seat. Please familiarize yourself with the location and operation of this device. Picture F-P3: Fire Extinguisher location. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 42: Water Systems
WATER SYSTEMS WATER HEATER BYPASS SYSTEM: Your Roadtrek is equipped with a water heater by-pass valve. During normal use, all three valves will face the aisle, (see Picture G-P1). When winterized, the water line valve in the middle of the water line should be in the open position,...
Page 43: Fresh Water Tank
5. Overfilled tanks will spill out through the fresh water tank gravity fill vent. Picture G-P5: The gravity fresh water fill for the fresh water tank, (located on the passenger side front “B- pillar”). Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 44: City Water Connection
Therefore, the use of these items is not necessary when connected closed directly to an external water source. Picture G-P8: Closed position of the city fresh water tank fill valve. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 45: Waste Water Storage And Dumping System
Picture G-P10: Access to the sewer discharge assembly, black (1) and grey (2) gate valve handle. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 46: Waste Water Tank Dumping
(black water tank gate Picture G-P11: Macerator manual crank handle is valve has a black handle), (see Picture G-P9#1). not available on the SS-Ideal model, however the 6. Open the driver’s door, press and hold the macerator pump itself is easily accessible.
Page 47: Waste Water Tank Flushing
NOTE: Do not allow water to sit in the fresh or the waste tanks when vehicle is not in use. Water can become stagnant over time and create odors. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 48: Potable Water System Sanitizing
1. Drain the antifreeze from the fresh water system and then flush out the fresh water system. 2. Sanitize the fresh water system if desired. 3. Fill the fresh water system with potable fresh water. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 G -7...
Page 52: Spring Start-Up
AT LEAST ONCE EVERY THREE MONTHS: Flush the black water holding tank. Flush the grey water holding tank. Flush and sanitize the fresh water tank, (when the coach is in use). Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009...
Page 53: At Least Twice A Year
Roadtrek shall not be held liable or assume any obligations or responsibilities whatsoever for any loss, damage or injury directly or indirectly caused by, arising or resulting from, or as a consequence of the use or nonuse of the information contained herein or the operation or non-operation of any items mentioned herein.
Page 54: Aluminum Wheel Maintenance
Regular maintenance, and the degradation or failure of components resulting from a lack of such maintenance will not be covered by the Roadtrek Motorhomes warranty. Please review the chassis, appliance, and other component manuals for maintenance schedules and procedures.
Page 55: Slideout Troubleshooting
Roadtrek dealer for repair Some of the early units had only an arrangement with a motor cover under the vehicle just in front of the hitch receiver: 1.
Page 56 Low battery, poor ground, extremely low Charge battery, check ground wire temperature Room in bind Adjust to proper room setting Incorrect height adjustment Check for proper room height Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 I - 6...
Page 57 Power Unit without assuring a full 12V DC charge. NOTE: The motor has no field serviceable parts, and so if the motor fails the only repair is to replace the motor. Doc No: 21906550 Rev: 00 Copyright © Roadtrek Motorhomes Inc. 2009 I - 7...
Page 59: Limitedwarranty Information
It is very important that the Dealer complete the Roadtrek Limited Warranty Registration, (at the bottom of the “QualityCare” Pre-Delivery Report) on each Vehicle and fax it to Roadtrek within 48 hours from the date of retail delivery. Roadtrek uses the information on the Limited Warranty Registration to: 1.
Page 60: Automotive Customer Service & Roadside Assistance Numbers
Canada), which ever occurs first, from date of purchase by the first Purchaser. After this period such costs are considered to be inherent in the ownership of such a vehicle. Roadtrek will not pay for the removal and reinstallation of motorhome components necessary to perform automotive service or maintenance. Such costs are considered to be inherent in the ownership of such a vehicle.
Page 61: Roadtrek Limited Motorhome Warranty
ROADTREK LIMITED MOTORHOME WARRANTY: Roadtrek warrants to the Purchaser that the Vehicle is free from defects in material and workmanship on the portion manufactured by Roadtrek, under normal use and service, for four, (4) years or 48,000 miles, (U.S). or 80,000 Km, (Canadian) whichever occurs first, from date of purchase by the first Purchaser or the date the Vehicle was first put into service, (for example, as a demo or rental), whichever is earlier.
Page 62 48 hours of the date of retail delivery. When warranty applications are made and the Warranty Card is not on file at Roadtrek, reimbursement of the claim will be delayed until proof of original purchase is submitted to Roadtrek.
Page 63: Customer Assistance
If these incentives weren’t enough, all Roadtrek Ambassadors referring more than 2 purchasing customers in a given year will be eligible for a draw to win the use of a new Roadtrek for a full year, (mileage restrictions will apply).
Page 64: Roadtrek Club International
CUSTOMER ASSISTANCE ROADTREK CLUB INTERNATIONAL As a new Roadtrek owner, you are cordially invited to join our family of Roadtrek owners as members of the “Roadtrek Club International”. An owners’ club offers its members an opportunity to meet other people with...
Page 65 E-mail Address ______________ Coach Manufacturer: Roadtrek Motorhomes Model: ______ Roadtrek Year:_______ Length: ________License Plate Number: __________________ I have applied for membership in the Roadtrek International Chapter of the Family Motor Coach Association. ( ) If you are a former member, check here.
Page 69: Potential Customer Referral Card
Area Code Please send me a brochure and the name and address of my nearest dealer Phone No. REFERRED BY: Roadtrek Vehicle Identification Number (last 8 digits only) Area Code Phone No. Roadtrek Owner’s Name (including Jr., Sr., etc.) PRINT Optional Mailing Address: House/Building Number and Street Name (including St., Ave., Rd., Ct., etc.)
Page 72 100 Shirley Avenue, Kitchener, Ontario, Canada, N2B 2E1 Contacts: (See page K-2) WebSite: http://www.roadtrek.com Copyright © Roadtrek Motorhomes Inc. Release Date: January 2010 Printed In Canada ® “Roadtrek” and “Roadtrek Motorhomes Inc.” are registered trademarks of J.J. Hanemaayer...

Roadtrek SS-Ideal Owner's Manual

Introduction

Weight Ratings

Warnings and Cautions

Appliance Log

Appliance Manufacturer Warranty Contact Information ____________________________________________________________ A-7

Daily Living

Slide out Room Operation

Sleeping Facilities

Washroom and Shower Area

Washroom Facilities

Exterior Access Doors

Electrical System

Propane & Safety System

Water Systems

Owner Maintenance

Limitedwarranty Information

Appliance Warranty

Customer Assistance

Change of Owner Name or Address Form ____________________________________________________________________ M-1 - M-2

Roadtrek International Chapter FMCA/ Aroadtrek Owners' Club Membership Forms __________________________________ L-1

Potential Customer Referral Card

Quick Links

Need help?

Questions and answers

Related Manuals for Roadtrek SS-Ideal

Summary of Contents for Roadtrek SS-Ideal

Table of Contents