Roadtrek 210 Chevrolet Owner's Manual

Hide thumbs Also See for 210 Chevrolet:

Owner's manual (78 pages)

Table Of Contents

Table of Contents

Quick Links

210 Chevrolet Models Owner's Manual

including

Limited Warranty Information

Table of Contents

Need help?

Do you have a question about the 210 Chevrolet and is the answer not in the manual?

Questions and answers

Summary of Contents for Roadtrek 210 Chevrolet

Page 1 210 Chevrolet Models Owner’s Manual including Limited Warranty Information...
Page 3: Table Of Contents
Propane & Safety System __________________________________________________________________________________ F-0 - F-1 Propane Tank ________________________________________________________________________________________________ F-2 Appliances __________________________________________________________________________________________________ F-2 Refueling Procedures __________________________________________________________________________________________ F-2 Regulator ____________________________________________________________________________________________________ F-2 Propane Leak Detector ________________________________________________________________________________________ F-3 Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 1...
Page 4 Address, Phone & Facsimile Numbers, and E-mail ____________________________________________________________________ K-2 Website ______________________________________________________________________________________________________K-2 Roadtrek International Chapter FMCA / A Roadtrek Owners’ Club Membership Forms __________________________________ L-1 Change of Owner Name or Address Form ____________________________________________________________________ M-1 - M-2 Potential Customer Referral Card __________________________________________________________________________ M-3 - M-4 Doc No: 21906532 Rev: 07 Copyright ©...
Page 5: Introduction
This manual has been written to provide you with the information required to properly operate and maintain your new Roadtrek. After reading this manual, be sure to keep it in your vehicle as a reference. Your Roadtrek dealer or Roadtrek Roadside Assistance (as found in the Coach Net/Roadtrek Roadside Assistance package provided in your vehicle if purchased after August 1, 2008) will be glad to answer any further questions about the operation of your vehicle.
Page 6: Weight Ratings
N/A if commercial scales or 4 portable scales used) 6) Place scales under the front wheels 7) Record scale readings 8) Repeat steps 4-6 for the rear wheels Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 A - 1...
Page 7: Warnings And Cautions
If you do not read the entire manual you may miss important information. Observe all Warnings & Cautions. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 A - 2...
Page 8 EXTERIOR ACCESS DOORS: Ensure that the power cord and city water line are disconnected and in their stored positions before the vehicle is put in motion. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 A - 3...
Page 9 GENERATOR: When launching a boat, using your Roadtrek, it is very important to know that the generator must not be submerged in water. When using the generator as the main power source to run the appliances, refer to the generator owners manual for proper use and maintenance.
Page 10: Customer Service Procedures
CUSTOMER SERVICE PROCEDURES OBTAINING MOTORHOME SERVICE The solution to all your Roadtrek concerns starts with your Roadtrek Dealer Roadtrek Dealer GM Dealer Roadtrek Dealer Advise the Service Department The dealership should always be given the that you have a opportunity to resolve your concerns prior to...
Page 11 VEHICLE SPECIFICATIONS 2010 STANDARD Roadtrek 210 models on 2010 2010 STANDARD Roadtrek 210 models on 2010 AND OPTIONAL Chevrolet Express 3500 MOTORHOME Chevrolet Express 3500 AUTOMOTIVE FEATURES Extended Van FEATURES Extended Van Air bag - driver & passenger with passenger on/off switch Air Conditioner - 110 ‘Dometic’recessed air conditioner...
Page 12: Manufacturer Contact Information
Water Heater, (Canada) Suburban c/o GL Products Oakville, ON 905-845-7558 Water Pump, (U.S. & Canada) SHURflo, LLC Cypress, CA 800-854-3218 Wheels - Aluminum American Racing Mississauga, ON 800-959-1969 Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 A - 7...
Page 14: Captain's Seats
Only forward facing seats equipped with factory installed seat belts are to be occupied while the vehicle is in motion. All passengers must be seated in these seats only, with the seat belts fastened while the vehicle is in motion. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 1...
Page 15: Cloverleaf Dining Table
Caution: Cloverleaf dining table is heavy, bend your knees while lifting. Picture B-P4B: Cloverleaf table leg is stored beside the driver side lounge or captain seat. (Versatile model). Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 2...
Page 16: Dinette Table
Picture B-P6: Storage location of dinette table, with (Popular model). the table leg base facing downward. Picture B-P5A: Location of assembled dining table, (Versatile model with power sofa). Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 3...
Page 17: Sleeping Facilities
(Popular model with Dinette). Picture B-7: Dinette as set up for traveling (Popular Picture B-8: Twin bed arrangement (Popular model Model with Dinette option) with Dinette). Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 4...
Page 18 Picture B-P11: Lay cushions flat. To convert back to a dinette, perform these steps in reverse order. Picture B-P13: Placement of filler cushion. Picture B-P12: Placement of back rest cushions. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 5...
Page 19: Front Lounge Seats
Picture B-P16: As viewed through passenger front door. Picture B-P14: Swiveled front captain seat. Picture B-P17: Front lounge bed. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 6...
Page 21 DAILY LIVING Back of Motorhome - Top View Back of Motorhome - Top View 210-Versatile Chevrolet Bed Layout (up to mid-2006) Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 8...
Page 22 DAILY LIVING Bed layout - 21PC Roadtrek with sofa Back of Motorhome Top View 90005000 Sofa in "flat" bed position 90211110 Bottom cushion 90149010 Bottom cushion 90102400 Back cushion (unfolded "flat") Uncontrolled Drawin Current Revision July 17,2007 e & Warranty\SF21PC-MY07-Bed...
Page 23 DAILY LIVING Bed layout - 21VC Roadtrek with sofa Back of Motorhome Top View 90005000 Sofa in "flat" bed position 90211150 Bottom cushion 90148650 Cushion 90149050 Bottom cushion 90102150 Cushion Uncontrolled Drawing Current Revision July 13,2007 & Warranty\SF21VC-MY07-Bed 210-Versatile Bed Layout (Power Sofa) Doc No: 21906532 Rev: 07 Copyright ©...
Page 24: Permanent Bathroom
GFCI outlet, it is always advisable to use caution when using appliances in wet environments. (May or may not be present depending on production dates) Picture B-P22 Picture B-P23 Picture B-P24 Picture B-P25 Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 11...
Page 25: Powered Sofa, (Optional)
Dinette table/bed (Versatile Units). support (Popular Units). Picture B-P28A: Table in Picture B-P28B: place as bed support Completed bed (Popular (Popular units). units). Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 12...
Page 26: Washroom Facilities
To prevent the grey water tank contents from spilling onto the floor while driving, keep the drain plug secured when not in use. Picture B-P30: Location of the shower head in the shower position. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 13...
Page 27: Extra Counter Space
(Vesatile model). top drawer fully open, (Vesatile model). Picture B-P34C: TV facing front of vehicle (Popular model shown). Picture B-P34A: Picture B-P34B: Flat Screen TV. "T" handle. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 14...
Page 28: Exterior Access Doors
Cable TV Hookup Picture B-P37: Exterior fresh water tank low point Picture B-P38: External connections, (city water, drain cap. cable TV) in driver side rear storage compartment. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 15...
Page 29: Propane Access Panel
(Posered Sofa seating) Storage trunk Picture B-P41: Curb side storage compartment. Picture B-P41A: Rear storage trunk. (Location same for both models, and for sofa or dinette) Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 16...
Page 30: Auxiliary Batteries
Ensure that the battery cable hex nuts are tightened to 10 ft-lbs, (see Picture B-P43). Ensure that the inverter and battery disconnect are disconnected prior to disconnecting the auxiliary batteries. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 B - 17...
Page 31: Spare Tire Storage
Mineraling: Due to the properties of natural Maple and Cherry wood, Roadtrek Motorhomes makes no warranty against the mineraling of wood components, (see Picture B-P48). Picture B-P48: Cherry cabinet showing mineraling. Doc No: 21906532 Rev: 07 Copyright ©...
Page 40: Inverter/Charger
The vehicle’s electrical system should not be subjected to changes and or additions to circuitry, appliances, etc. without consulting your dealer or Roadtrek for proper installation procedures. Failure to do this could result in serious safety issues or component damage. Changes to the electrical system run the risk of voiding the warranty.
Page 41: 110V / 12V Inverter/Charger/Distribution Panel
The generator is located and accessed on the underside behind the rear axle of your vehicle. CAUTION: When launching a boat, using your Roadtrek, it is very important to know that a generator must not be submerged in water. This will permanently damage the generator. If you cannot launch without submerging the generator, an alternate method would be to use a boat launching service.
Page 42: Monitor Panel
The panel also provides the switch for the water pump and a Location of porch disconnect switch for the auxiliary battery. light switch with optional armoire. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 E - 3...
Page 43: Automotive Battery
Refer to the Chevrolet’s Owner’s Manual for complete operation instructions. WATER HEATER : The Roadtrek is equipped with a water heater. The water heater operates on propane, but does require 12V power for the electronic circuitry. Please refer to the Suburban Owner’s Manual for complete operation instructions.
Page 48 WARNING: The auxiliary BBQ outlet is regulated to 10 P.S.I. If you are using an external grill with this hookup, ensure that the appliance is rated for that pressure or has its own regulator for lower pressure. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 F - 1...
Page 49: Propane Tank
These are not user serviceable items and should not be removed or modified by anyone but a licensed RV gas technician. Illegal or uncertified modification can lead to fire or explosion. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 F - 2...
Page 50: Propane Leak Detector
NOTE: Cleaning products may contaminate safety detectors. Detectors should be covered when using cleaning chemicals on the vehicles interior, (so that the sensors in the detection devices do not get contaminated). Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 F - 3...
Page 54: Winter Mode Valve Position
The dual tank system allows you to use the fresh water system under moderate subfreezing conditions by allowing you to isolate and drain the exterior fresh water tank. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 G - 1...
Page 55: Summer Mode Valve Position
Picture G-P1: Selector valve position for supply Picture G-P2: Selector valve position for supply from from the interior fresh water tank. the exterior fresh water tank. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 G - 2...
Page 56: To De-Winterize
Although the waste and fresh water systems have been designed for use in moderate subfreezing conditions, Roadtrek Motorhomes makes no warranty what so ever for damage to the water systems as a result of freezing. Doc No: 21906532 Rev: 07 Copyright ©...
Page 57: Fresh Water Tanks
This is evidenced by water dripping from the Picture G-P9 : The water fill for the external fresh underside of the van. water tank, (located at driver’s side front door post). Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 G - 4...
Page 58: City Water Connection
5. Note that this connection by-passes the water pump and fresh water tank. Therefore, the use of these items is not necessary when connected directly to an external water source. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 G - 5...
Page 59: Waste Water Storage And Dumping System
Antifreeze should be used at a 50-50 ratio. Picture G-P14: Access to sewer discharge assembly, black and grey gate valve handles. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 G - 6...
Page 60: Waste Water Tank Dumping
If macerator should get clogged you will have to push and turn the manual macerator crank "T" handle to dislodge any debris that might be blocking the macerator, (see picture G-P15). Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 G - 7...
Page 61: Waste Water Tank Flushing
If this procedure is followed, it is unnecessary to blow out the water system. Once the system is drained, be sure to close all taps before driving. NOTE: Do not allow water to remain in tanks when vehicle is not in use. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 G - 8...
Page 62: Potable Water System Sanitizing
To prepare your potable water system for use: 1. Drain the antifreeze from the system. 2. Sanitize the system if desired. 3. Fill the system with water. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 G - 9...
Page 65: Maintenance And Miscellaneous Information Including Limited Warranty
MISCELLANEOUS Maintenance and Miscellaneous Information including Limited Warranty Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 H - 0...
Page 66: Helpful Information
Do not check the oil level when the generator is running. The propane fueled generator (Roadtrek RS Adventurous model) does not have the same exercising demand or altitude adjustment. Avoid starting the generator while the vehicle engine is running. This (DC) load could trip the fuse in the auto battery circuit if charge demand is high.
Page 67 (a pen or a screw driver tip will do to push valve pin). Reminder, to prepare your Roadtrek for spring and summer use, ensure all fresh water tanks are drained and sanitized.
Page 69: Spring Start-Up
Add fuel stabilizer to the fuel tank. Flush and sanitize fresh water tank. Grease external drawer slides. (More often in moist climates or if Winter driven) Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 I - 2...
Page 70: At Least Twice A Year
Roadtrek Motorhomes shall not be held liable or assume any obligations or responsibilities whatsoever for any loss, damage or injury directly or indirectly caused by, arising or resulting from, or as a consequence of the use or nonuse of the information contained herein or the operation or non-operation of any items mentioned herein.
Page 71: Aluminum Wheel Maintenance
It is recommended to place Vaseline, or some type of oil based cooking grease and coat the wheels during the harsh winter and touch them up from time to time or have a set of winter wheels and tires. Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. 2010 I - 4...
Page 72: Limitedwarranty Information
It is very important that the Dealer complete the Roadtrek Motorhomes Inc. Limited Warranty Registration, (at the bottom of the “QualityCare” Pre-Delivery Report) on each Vehicle and fax it to Roadtrek within 48 hours from the date of retail delivery. Roadtrek Motorhomes uses the information on the Limited Warranty Registration 1.
Page 73: Limitedwarranty Information
Chevrolet dealer. See the General Motors Warranty Information booklet for details. Such items are not warranted by Roadtrek. Roadtrek will pay for the removal and reinstallation of motorhome components necessary to perform automotive recalls and warranty for 36 months or 36,000 miles, (in US) or 60,000 Km, (in Canada), which ever occurs first, from date of purchase by the first Purchaser.
Page 74: Roadtrek Motorhomes Limited Motorhome Warranty
Canada or Canada into the US. In-transit (travel) repairs are still warrantable per the terms of the Limited Warranty Policy. This warranty shall be fulfilled at a Roadtrek Motorhomes Dealer or authorized Roadtrek repair facility. For in transit emergency repairs, you may choose to deal with a non-authorized RV service facility. However all warranty repairs at non-authorized RV service facilities must be preauthorized by Roadtrek Motorhomes.
Page 75 Roadtrek Motorhomes Limited Motorhome Warranty is void unless the following conditions are adhered to: 1. Warranty Card on Vehicle must be completed by the Dealer and faxed to Roadtrek within 48 hours of date of retail delivery. When warranty applications are made and Warranty Card is not on file at Roadtrek,, reimbursement of claim will be delayed until proof of original purchase is submitted to Roadtrek.
Page 76: Customer Assistance
If these incentives weren’t enough, all Roadtrek Ambassadors referring more than 2 purchasing customers in a given year will be eligible for a draw to win the use of a new Roadtrek for a full year, (mileage restrictions will apply).
Page 77: Roadtrek Club International
CUSTOMER ASSISTANCE ROADTREK CLUB INTERNATIONAL As a new Roadtrek owner, you are cordially invited to join our family of Roadtrek owners as members of the “Roadtrek Club International”. An owners’ club offers its members an opportunity to meet other people with...
Page 78: Roadtrek International Chapter Fmca / A Roadtrek Owners' Club Membership Forms
E-mail Address ______________ Coach Manufacturer: Roadtrek Motorhomes Model: ______ Roadtrek year:_______ length: ________license plate number: __________________ I have applied for membership in the roadtrek International Chapter of the Family Motor Coach Association. ( ) If you are a former member, check here.
Page 81: Potential Customer Referral Card
Area Code Please send me a brochure and the name and address of Phone No. my nearest dealer REFERRED BY: Roadtrek Vehicle Identi cation Number (last 8 digits only) Area Code Phone No. PRINT Roadtrek Owner’s Name (including Jr., Sr., etc.)
Page 84 WebSite: http://www.roadtrek.com Printed In Canada Doc No: 21906532 Rev: 07 Copyright © Roadtrek Motorhomes Inc. Release Date: July 2010 ® “Roadtrek Motorhomes” and “Roadtrek” are registered trademarks of J.J. Hanemaayer of which Roadtrek Motorhomes Inc. is a licensee and/or registered user...

This manual is also suitable for:

210

Roadtrek 210 Chevrolet Owner's Manual

Quick Links

Need help?

Questions and answers

Related Manuals for Roadtrek 210 Chevrolet

Summary of Contents for Roadtrek 210 Chevrolet

This manual is also suitable for:

Table of Contents