Roadtrek Sprinter Owner's Manual

Hide thumbs Also See for Sprinter:

Owner's manual (77 pages)

Table Of Contents

Table of Contents

Quick Links

Sprinter Models Owner's Manual

Including

Limited Warranty Information

Roadtrek Motorhomes Inc.

100 Shirley Avenue, Kitchener, Ontario,

Canada, N2B 2E1

Email: service@roadtrek.com

WebSite: http://www.roadtrek.com

Table of Contents

Need help?

Do you have a question about the Sprinter and is the answer not in the manual?

Questions and answers

Summary of Contents for Roadtrek Sprinter

Page 1 Sprinter Models Owner’s Manual Including Limited Warranty Information Roadtrek Motorhomes Inc. 100 Shirley Avenue, Kitchener, Ontario, Canada, N2B 2E1 Email: service@roadtrek.com WebSite: http://www.roadtrek.com...
Page 3: Table Of Contents
Propane & Safety System ______________________________________________________________________________________ F-1 Propane Tank __________________________________________________________________________________________________ F-1 Appliances ____________________________________________________________________________________________________ F-1 Refueling Procedures ____________________________________________________________________________________________ F-2 Regulator ____________________________________________________________________________________________________ F-2 Propane Leak Detector __________________________________________________________________________________________ F-2 Carbon Monoxide Leak Detector __________________________________________________________________________________ F-2 Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010 B - 1...
Page 4 Limited Warranty Information __________________________________________________________________________________ J-1 Limited Warranty Definitions ______________________________________________________________________________________ J-1 Roadtrek Limited Warranty Registration ____________________________________________________________________________ J-1 Automotive Warranty - Daimler Chrysler, (Dodge and Freightliner Sprinter Chassis)______________________________________ J-1 - J-2 Automotive Customer Service & Roadside Assistance Numbers __________________________________________________________ J-2 Appliance Warranty ____________________________________________________________________________________________ J-2...
Page 5 If you do not read the entire manual you may miss important information. Observe all Warnings & Cautions. Note: This manual applies to both the RS-Adventurous and SS-Agile models. Where differences occur, additional notes/pictures have been included. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 6 All passengers must be seated in these seats only, with the seat belts fastened while the vehicle is in motion. The flat screen TV should not be stored inside the Roadtrek in temperatures below -4°F, (-20°C). Remove it to reduce the chance of damage from the cold. The operating temperature of the monitor is recommended between 50°F and 104°F, (10°C and 40°C) with a humidity range of 10% to 80%, non condensing.
Page 7 Ensure that the inverter is disconnected prior to disconnecting the auxiliary battery. GENERATOR: When launching a boat using your Roadtrek, it is very important to note that the generator MUST NOT be submerged in water. When using the generator as the main power sorce to run the appliances, refer to the generator owners manual for proper use and maintinance.
Page 8 CUSTOMER SERVICE PROCEDURES OBTAINING MOTORHOME SERVICE The solution to all your Roadtrek concerns starts with your Roadtrek Dealer Roadtrek Dealer Dodge/Chrysler/Mercedes Dealer Roadtrek Dealer Advise the Service Department The dealership should always be given the that you have a opportunity to resolve your concerns prior to...
Page 9: Introduction
This manual has been written to provide you with the information required to properly operate and maintain your new Roadtrek. After reading this manual, be sure to keep it in your vehicle as a reference. Your Roadtrek dealer will be glad to answer any further questions about the operation of your vehicle.
Page 10: Weight Ratings
Sample of Canadian Weight label: the load carrying capacity of a single axle system, as measured at the tire-ground interfaces. Towing Guidelines: Consult Dodge Sprinter Owners Manual(s) for specific weighing instructions and towing guidelines, including auxiliary brake requirements for any towed trailer or towed vehicle.
Page 11 510 mm/20", (opt.) Water tank - fresh 105 L/27 US gal. Water tank - grey 80 L/21 US gal//75 L/20 US gal.. Water tank - black 40 L/10 US gal. Doc No: 21906540-RSAD Rev: 02 Copyright© Roadtrek Motorhomes Inc. 2008...
Page 12: Appliance Log
Progressive Dynamics PD5110610 TV (Flat Screen) Vizio, VA19L TV Antenna Winegard RV-7005 Water Heater Suburban SW6D Water Pump Shurflo 2088-403-144 Appliance manufacturers and model numbers subject to change without notice. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 13 Suburban c/o GL Products Oakville, ON 905-845-7558 Water Pump, (U.S.) Shurflo Santa Ana, CA 800-854-3218 Water Pump, (Canada) Shurflo Belmont, ON 519-727-6752 NOTE: Specifications and availability subject to change. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 15: Daily Living
All passengers must be seated in these seats only, with the seat belts fastened while the vehicle is in motion. Picture B-P2: Captain seats swiveled towards the rear of the Motorhome (RS Adventurous). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 16: Cloverleaf Dining Table
(Picture B-P4B). side closet. Picture B-P4B: Folding front table, (SS model) Picture B-P4A: Rear table leg located on the driver side, behind the drivers seat, (SS model stored position). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 17: Dinette Table
(see Picture B-P4). Table Picture B-P5: Location of assembled dinette table. Picture B-P6: Location of dinette table, (stored position). Picture B-P5A: Location of assembled dinette table, (Optional power rear sofa). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 18: Sleeping Facilities
Picture B-P8: Placement of the cushions for Twin beds (regular dinette). Dinette support table Picture B-P9: Dinette table and bed support for King size bed, (stored position). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 19: Rear King Bed
To convert back to a dinette, perform these steps in reverse order. Picture B-P11: Lay cushions flat. Picture B-P12: Placement of the back rest cushions. Picture B-P13: Placement of the filler cushion. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 20: Rear King Size Bed, (Optional Power Rear Sofa)
Picture B-P11A: Placement of the table top as the center bed support for the king size bed. Picture B-P12: Placement of the back rest cushions for the King size bed. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 21: Second Row Captain Seats
3. To adjust the arm rest, turn the adjustment screw under the arm rest, (see Picture BP16). Picture B-P14: Swivel lever handle. Picture B-P15: Slide adjustment handle. Picture B-P16: Arm rest adjustment screw. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 22: Washroom And Shower Area
“ON” position, (see Picture B-P20). Picture B-P19: Inside shower door latch (RS model). Picture B-P20: Bathroom exhaust vent. Picture B-P21: Front bathroom door, (in transit) locking pin in the locked position. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 23 Velcro™ strip (Picture B- P23B). Picture B-P23B: Washroom door interior Velcro strip (SS model). Picture B-P23C: Washroom door in use position (SS model). Doc No: 21906532-210C05 Rev: 03 Copyright © Roadtrek Motorhomes Inc. 2005...
Page 24: Permanent Bathroom Shower
3. Replace the floor drain plug when you are finished. (RS model shown). To prevent grey water tank contents from spilling onto the floor while driving, keep the drain plug secured when not in use. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010 B-10...
Page 25: Extra Counter Space
TV by turning the black “T” handle on the cabinet, (see Picture B-P28). Picture B-P27: Flat screen display. Picture B-P28: Flat screen display bracket locking “T” handle. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010 B-11...
Page 26: Exterior Access Doors
1. City water connection, (integrated at the driver side behind the side access door). 2. Propane Tank with fittings and connectors Warning: Before putting your Roadtrek into motion, ensure that the shore power cord and the city water supply line are disconnected and are stored properly.
Page 27: Propane Access Door
Picture B-P35A: Water heater bypass (SS model) in doors in the SS model. bypass mode. Picture B-P36: Rear storage area (SS model with Picture B-P36A: Rear storage trunk (RS model only). sofa) . Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010 B-13...
Page 28: Auxiliary Battery
The Battery Separator (Picture B-P37C) performs this duty. Picture B-P37C: Battery Separator and breakers Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010 B-14...
Page 29: Bbq Quick Connect
Continental tire carrier in the SS (Picture B- P39C). NOTE: The spare wheel on the 3500 Sprinter-based vehicles (RS) with the dual rear wheels is very heavy. In most cases it would be better to have a technician (CAA, AAA, garage, etc.) perform a wheel change...
Page 30: Tv Signal Selection Switch
Picture B-P43A: Automotive jack storage storage compartment cover, (see picture B-P43A). compartment cover securing screw. 3. Automotive tire jack, (stored position), (see picture B-P43B). Picture B-P43B: Automotive tire jack, (stored position). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010 B-16...
Page 33 12AWG 2CU W/GROUND W/GROUND 10AWG 2CU W/GROUND Shore Power Receptacle W/GROUND 10AWG 2CU W/GROUND Main Power Switch W/GROUND Circuit VOLTS AMPS WIRE SIZE LOADING CIRCUIT SCHEDULE RS00 Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010 B - 19...
Page 34: Floorplans
DAILY LIVING -INTERIOR FINISH MATERIALS HAVE A FLAME SPREAD RATING OF LESS THAN 200 FLOORPLAN - SS MODEL -INTERIOR TEXTILE MATERIALS COMPLY WITH FMVSS 302 -INTERIOR DOORS/PARTITIONS ARE NON-LOCKING MP / !" "# $% &# ") 0 #$ $13) &4 !"...
Page 35: Electrical System
110 volt GFCI receptacle locations: Picture E-P0A: 110V GFCI receptacle, Picture E-P0B: 110V GFCI receptacle, (Galley location). (side entry door location). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 36: Generator
This will permanently damage the generator. If you cannot launch without submerging the generator, an alternate method would be to use a boat launching service. Note: The Propane generator on the Sprinter units runs on Propane from the same Propane tank as the appliances. POWER STEP OVERRIDE SWITCH The power side entry step functions with the opening and closing of the sliding side entry door.
Page 37: Monitor Panel
“good”. The panel also provides the switch for the water pump and a disconnect switch for the auxiliary battery(s). Picture E-P3: Location of the crank up antenna handle. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 38: Auxiliary Batteries And Battery Separator
Refer to the Dodge Sprinter's Owner’s Manual for complete operation instructions. WATER HEATER : The Roadtrek is equipped with a Propane fueled water heater. The water heater must be operated on Propane but does require 12-volt power to operate the electronic circuitry. Please refer to the Suburban Owner’s Manual for complete operation instructions.
Page 41 Blue 18AWG To Fresh Water Tank (Exterior) Brown 22AWG Black 18AWG To Black Water Tank Grey 22AWG Grey 18AWG To Grey Water Tank Orange 22AWG Red 2AWG Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010 E -7...
Page 42: Propane & Safety System
WARNING: Portable fuel burning equipment, including wood and charcoal grills and stoves, should not be used inside your vehicle. Use of this equipment inside your vehicle, may cause fire or asphyxiation. See appropriate component Manufacturer’s Owner’s Manuals for operating instructions. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 43: Refueling Procedures
See Manufacturer’s Owner’s Manual for other operating instructions. WARNING: Battery disconnect switch must be in the “ON” Picture F-P2b: Combination Carbon- position for the carbon monoxide gas detector to operate. Monoxide/Propane gas detector. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 44: Smoke Detector
See Manufacturer’s Owner’s Manual for operating instructions. NOTE: Cleaning products, sealants, and some adhesives may contaminate safety detectors. All of the detectors should be covered when using cleaning chemicals or working on the vehicles interior. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 46 PROPANE & SAFETY SYSTEM Rev ECO# Revision By Ck.By Auth Date 21814 Released CZ DV AN 01/29/2008 22051 Description was "...SS00" DV CB - 01/07/2010 Doc No: 21906540-RSAD Rev: 02 Copyright © Hanmar Motor Corporation 2006...
Page 47: Water Systems
WATER SYSTEMS WATER HEATER BYPASS SYSTEM: Your Roadtrek is equipped with a water heater by-pass valve. open During normal use, all three valves will face the aisle, (see Picture G-P1). When winterized, the water line valve in the middle of the water line should be in the open position,...
Page 48: Fresh Water Tank
5. Overfilled tanks will spill out through the fresh water tank gravity fill vent. Picture G-P4: The gravity fresh water fill for the fresh water tank, (located on the passenger side front “B- pillar”). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 49: City Water Connection
Therefore, the use of these items is not necessary when connected directly to an external water source. Picture G-P7: Closed position of the city fresh water tank fill valve. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 50: Waste Water Storage And Dumping System
Picture G-P9: Access to the sewer discharge assembly, black (1) and grey (2) gate valve handle and the macerator manual crank handle (3). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 51: Waste Water Tank Dumping
(see picture G-P10). Picture G-P12: Sewage discharge manual cleanout. (As seen from below the vehicle) (See Drain/Sewage system drawings for exact locations) Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 52: Waste Water Tank Flushing
NOTE: Do not allow water to sit in the fresh or the waste tanks when vehicle is not in use. Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 53: Potable Water System Sanitizing
WATER SYSTEMS POTABLE WATER SYSTEM SANITIZING: Your potable water system should be sanitized if it is new, has not been used for a period of time, or may have become contaminated. To sanitize your fresh water system: 1. Prepare a chlorine solution using 4 L, (1 gallon) of water and 60 ml, (1/4 cup) of household bleach, (5% sodium hypochlorite solution).
Page 59: Spring Start-Up
AT LEAST ONCE EVERY THREE MONTHS: Flush the black water holding tank. Flush the grey water holding tank. Flush and sanitize the fresh water tank, (when the coach is in use). Doc No: 21906540-RSAD Rev: 02 Copyright © Roadtrek Motorhomes Inc. 2010...
Page 60: At Least Twice A Year
Roadtrek shall not be held liable or assume any obligations or responsibilities whatsoever for any loss, damage or injury directly or indirectly caused by, arising or resulting from, or as a consequence of the use or nonuse of the information contained herein or the operation or non-operation of any items mentioned herein.
Page 61: Aluminum Wheel Maintenance
NOTE: The Aluminum Wheels used for the Sprinter Aluminum Wheel Option are OEM Sprinter wheels and are covered by the Daimler Chrysler warranty.
Page 62: Limitedwarranty Information
It is very important that the Dealer complete the Roadtrek Limited Warranty Registration, (at the bottom of the “QualityCare” Pre-Delivery Report) on each Vehicle and fax it to Roadtrek within 48 hours from the date of retail delivery. Roadtrek uses the information on the Limited Warranty Registration to: 1.
Page 63: Automotive Customer Service & Roadside Assistance Numbers
All automotive service, maintenance and repairs are to be performed by any Daimler Chrysler, Sprinter or Plymouth dealer. See the Daimler Chrysler Warranty Information booklet for details. Such items are not warranted by Roadtrek.
Page 64: Roadtrek Limited Motorhome Warranty
ROADTREK LIMITED MOTORHOME WARRANTY: Roadtrek warrants to the Purchaser that the Vehicle is free from defects in material and workmanship on the portion manufactured by Roadtrek, under normal use and service, for four, (4) years or 48,000 miles, (U.S). or 80,000 Km, (Canadian) whichever occurs first, from date of purchase by the first Purchaser or the date the Vehicle was first put into service, (for example, as a demo or rental), whichever is earlier.
Page 65 48 hours of the date of retail delivery. When warranty applications are made and the Warranty Card is not on file at Roadtrek, reimbursement of the claim will be delayed until proof of original purchase is submitted to Roadtrek.
Page 66: Customer Assistance
If these incentives weren’t enough, all Roadtrek Ambassadors referring more than 2 purchasing customers in a given year will be eligible for a draw to win the use of a new Roadtrek for a full year, (mileage restrictions will apply).
Page 67: Roadtrek Club International
CUSTOMER ASSISTANCE ROADTREK CLUB INTERNATIONAL As a new Roadtrek owner, you are cordially invited to join our family of Roadtrek owners as members of the “Roadtrek Club International”. An owners’ club offers its members an opportunity to meet other people with...
Page 69: Roadtrek International Chapter Fmca / A Roadtrek Owners' Club Membership Forms
E-mail Address ______________ Coach Manufacturer: Roadtrek Motorhomes Model: ______ Roadtrek year:_______ length: ________license plate number: __________________ I have applied for membership in the roadtrek International Chapter of the Family Motor Coach Association. ( ) If you are a former member, check here.
Page 73: Potential Customer Referral Card
Area Code Please send me a brochure and the name and address of my nearest dealer Phone No. REFERRED BY: Roadtrek Vehicle Identification Number (last 8 digits only) Area Code Phone No. Roadtrek Owner’s Name (including Jr., Sr., etc.) PRINT Optional Mailing Address: House/Building Number and Street Name (including St., Ave., Rd., Ct., etc.)
Page 76 Canada, N2B 2E1 Telephone: 519-745-1169 or Toll Free: 1-888-ROADTREK (1-888-762-3873) Fax: 519-745-1160 Email: service@roadtrek.com WebSite: http://www.roadtrek.com Copyright © Roadtrek Motorhomes Inc. Release Date: February 2008 Printed In Canada ® “Roadtrek” and “Roadtrek Motorhomes Inc.” are registered trademarks of J.J. Hanemaayer...

Roadtrek Sprinter Owner's Manual

Introduction

Weight Ratings

Specifications, (Automotive/Motorhome) ________________________________________________________________________ A-3

Appliance Log

Appliance Manufacturer Warranty Contact Information ____________________________________________________________ A-5

Daily Living

Sleeping Facilities

Washroom and Shower Area

Washroom Facilities __________________________________________________________________________________________ B-10

Exterior Access Doors

Electrical System

Propane & Safety System

Water Systems

Owner Maintenance

Limitedwarranty Information

Customer Assistance

Roadtrek International Chapter FMCA / a Roadtrek Owners' Club Membership Forms

Change of Owner Name or Address Form ____________________________________________________________________M-1 - M-2

Potential Customer Referral Card

Quick Links

Need help?

Questions and answers

Related Manuals for Roadtrek Sprinter

Summary of Contents for Roadtrek Sprinter

Table of Contents