Advertisement
Quick Links
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Instruction No
Instruction No
Version
Version
8670993
8670993
1.0
1.0
© Volvo Car Corporation
Part. No.
Part. No.
Lowered sports chassis
Lowered sports chassis
Lowered sports chassis- 8670993 - V1.0
Page 1 / 18
Advertisement
Related Manuals for Volvo 8670993
Summary of Contents for Volvo 8670993
- Page 1 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Instruction No Instruction No Version Version Part. No. Part. No. 8670993 8670993 Lowered sports chassis Lowered sports chassis © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 1 / 18...
- Page 2 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Equipment A0000162 A0000161 A0000197 D0000219 M0000264 A0800088 A0800625 M0000265 M7600425 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 2 / 18...
- Page 3 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden M7600426 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 3 / 18...
- Page 4 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden M7600427 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 4 / 18...
- Page 5 Remove: the front floor hatch. First lift the rear edge up slightly. Pull the floor hatch backwards out of the mountings the front insulation panel. M8502796 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 5 / 18...
- Page 6 If the anti-roll bar is to be replaced, carry out points - . Remove: the nut (1) for the shock absorber the screws (2) for the upper shock absorber bearing. M7600370 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 6 / 18...
- Page 7 Relieve the load from the lower trailing arm (1). Use a mobile jack Remove the screw (2) for the trailing arm Carefully lower the mobile jack Remove the spring (3) by pressing the trailing arm down. D7600186 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 7 / 18...
- Page 8 (3) for the anti-roll bar mountings (4) from the base plate on the left and right-hand sides the anti-roll bar (5) by pulling the anti roll bar out from the side while twisting it. D7600187 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 8 / 18...
- Page 9 Install the new upper shock absorber bearing in the spring turret. Use the three screws from the kit and the two washers. Do not tighten fully yet. E6500370 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 9 / 18...
- Page 10 (5). Adjust the position of the trailing arm so that the screw can be threaded all the way into the trailing arm. Do not tighten the screw yet. M7600346 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 10 / 18...
- Page 11 (P/N 999 5740B-1) on the control arm the tensioner (1) A6500361 Ensure that the rollers are against the rails on both sides of the control arm. © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 11 / 18...
- Page 12 Reinstall the foam rubber seals over the rear shock absorber mountings Reinstall the front insulation panel and the floor hatch. Sports chassis kit, front Note! Carry out points - on both sides. © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 12 / 18...
- Page 13 Measure the position of the stub axle and spring strut (A) as illustrated Remove the ABS sensor cable (1) from the bracket on the spring strut. D7600300 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 13 / 18...
- Page 14 Pull the spring strut forward over the brake hose and down. Note! Do not damage the brake hose, ABS sensor cable or painted surfaces. D7600301 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 14 / 18...
- Page 15 (1) on the shock absorber. Use socket (P/N 9995469) and a Torx socket as a counterhold the spring seat (2) the spring (3) the rubber bump stop (4) including the boot. M7600372 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 15 / 18...
- Page 16 (2). Align the lower end of the spring in the slot (3) in the lower section of the shock absorber the washer (4) the spring seat (5) the retaining nut (6). D7600304 © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 16 / 18...
- Page 17 Tighten to 105 Nm (78.5 lbf.ft.) Angle-tighten to 90°. Use the protractor (P/N 9512050) Reinstall the bracket for the ABS sensor cable. See point Reinstall the ABS sensor cable in its bracket. © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 17 / 18...
- Page 18 Reinstall both the front wheels. Tighten the wheel nuts crosswise Lower the car completely. Tighten the wheels nuts on all wheels. Tighten to 140 Nm (104 lbf.ft.) Check the wheel alignment. © Volvo Car Corporation Lowered sports chassis- 8670993 - V1.0 Page 18 / 18...