Page 1
CARE CLINER COLLECTION OWNERS OPERATING AND MAINTENANCE MANUAL Care Cliner & XL Care Cliner Drop-Arm & XL Drop-Arm Care Cliner (6530 Shown) (6550 Shown) Designer Care Cliner (6710 Shown) Elite & XL Elite Care Cliner Swing-Arm & XL Swing-Arm Care Cliner (6910 Shown) (6940 Shown) PLEASE DO NOT DISCARD THIS MANUAL.
Page 2
this page has been left blank intentionally.
Page 3
IF YOU HAVE ANY QUESTIONS OR CONCERNS, PLEASE CONTACT WINCO MFG., LLC. Winco assumes no responsibility for damage or injury caused by improper assembly, installation, use, or maintenance of these products. No part of this manual may be duplicated in any form without the prior consent of Winco Mfg., LLC.
The information contained in this manual is subject to change without notice. Save these instructions for future reference. No part of this manual may be duplicated in any form without the prior consent of Winco Mfg., LLC. Unauthorized duplication or distribution of these materials may result in civil prosecution to the maximum extent allowed by law.
DO NOT MODIFY THE PLUG OR USE AN ADAPTER WITH THIS PRODUCT. 14. For an added level of safety; Winco recommends the use of a 120 volt GFCI (ground fault circuit interrupter) outlet and circuit.
Page 6
Care Cliner Collection GENERAL CARE & CLEANING It is Winco Mfg., LLC's recommendation to inspect tightness of all screws, bolts, nuts, or other fasteners at minimum on an annual basis. Winco Mfg., LLC’s full-line of products are built to provide durability and reliability when properly cared for. In general,...
Page 7
Owners Operating & Maintenance Manual: Care Cliner Collection Important: Please Read For "Heat" and "Heat & Massage" Chairs: This equipment is marked with the industry recognized symbol indicating it is a “Class II Double-Insulated” device as defined by IEC 60601-1. As such, it does NOT require a three conductor power cord (i.e.
Page 8
8. LOCK casters at all times when chair is stationary. UNLOCK casters when moving or transporting chair. 9. DO NOT use recliner for transporting in or with ANY type of vehicle or trailer. Winco recliners have not been tested or approved for use by an occupant in any type of vehicle or trailer.
Owners Operating & Maintenance Manual: Care Cliner Collection Back Assembly Instructions Remove back assembly and chair frame from carton. NOTE: "Heat Only" and "Heat & Massage" chairs. AVOID disconnecting any "chair to back" wires. NOTE: Make sure the footrest is in closed position before installing the back. 2.
Care Cliner Collection Operating Instructions Fig. 1 Reclining the Care Cliner All Winco 6 Series chairs have three standard recline positions plus Trendelenburg positioning on select models (When gas spring is engaged with release handles from third recline position). From the #1 (SEATED UPRIGHT) position, grip the arm rests and simultaneously lean body weight back.
Page 11
Owners Operating & Maintenance Manual: Care Cliner Collection Returning Care Cliner to the Upright Position FIG. 2 FIG. 1 From the RECLINED position, grip the arm rests and simultaneously lift body weight upward while pulling on armrests. Continue until desired position is reached (FIG.
Page 12
Owners Operating & Maintenance Manual: Care Cliner Collection LOCK/ UNLOCK CASTERS (FIG. 1 - FIG. 4) * For 3" and 5" Nylon Casters and 5" Steel Casters. Total-Lock Casters will lock wheel and swivel mechanism by using your foot and pushing down on the tab. Location: •...
Page 13
Owners Operating & Maintenance Manual: Care Cliner Collection RAISE / LOWER DROP-ARMS (FIG. 1) (For Drop-Arm Care Cliner Models ONLY) BEFORE RAISING OR LOWERING, VERIFY THAT OCCUPANT AND ATTENDANT ARE CLEAR OF DROP-ARM. To Lower: Grasp armrest in center; use free hand to LIFT the drop-arm release handle.
Page 14
Owners Operating & Maintenance Manual: Care Cliner Collection SWING-ARM OPERATION Fig. 1 (For Models: 6740, 6750, 6940, and 6950 only) Remove any items from tables and lower tables. 2. To open, depress the red latch handle to unlock the swing-arm (FIG.
Owners Operating & Maintenance Manual: Care Cliner Collection General Maintenance Adjusting the Gas Spring NOTE: Tension or "stiffness" of the gas spring is set by factory and cannot be changed. The following instruction is for adjusting the gas spring "release and engagement points" for trendelenburg or "deep recline" positions only.
Page 16
Owners Operating & Maintenance Manual: Care Cliner Collection Fig. 1 Replacing the Recliner Mechanism Keep hands and fingers clear of moving parts when replacing the mechanism. Use caution when handling the mechanism to ensure that it does not retract in your hands.
• If switch displays a flashing light, check all accessible wire connectors under chair for possible loose connections, then contact Winco customer service: 1-800-237-3377. Cord Storage (Models with Heat or Massage only) Before transporting chair or when heat & massage is not in use, power cord should be coiled and stored in the hook and loop fastener provided as shown, to prevent tripping on cord, damage to cord, damage to recliner, etc.
Owners Operating & Maintenance Manual: Care Cliner Collection Care Cliner Options Heat / Heat & Massage IV Pole & Attachment Leg Extensions HM ......Heat & Massage IV ....... IV Pole & Attachment RE00 ....Round Leg Extension Fits: 653 & 654 Models HT ........
Winco Mfg., LLC shall not be liable for any labor, shipping or any other costs incurred as a result of or in conjunction with a warranty claim.
Page 22
this page has been left blank intentionally.
Page 23
this page has been left blank intentionally.
Page 24
CONTACT US To arrange a demonstration or to speak with one of our associates, please feel free to contact us at: 800-237-3377 | WincoMfg.com | 5516 SW 1st Lane, Ocala, FL 34474 | Info@WincoMfg.com...