Operation; General; Start-Up - Hatco GLO-RAY Holiday Inn Express GRCMW-1DH Installation & Operating Manual & Replacement Parts List

GENERAL

WARNING
Unit is not waterproof. DO NOT submerge in
water. To prevent any injury or damage do not
operate if it has been submerged in water.
WARNING
Some exterior surfaces on the unit will get hot.
Use caution when touching these areas to avoid
injury.
CAUTION
Standard and approved manufacturing oils will
smoke up to 30 minutes during initial set up.
This is a temporary condition. To assure safe
operation operate unit without food product
until smoke dissipates.

START-UP

1. Plug unit into a properly grounded electrical
outlet of the correct voltage, size and plug
configuration. See SPECIFICATIONS for details.
NOTE: For proper operation Hatco recommends
using the unit with water in the reservoir. When no
water is being used, Hatco recommends adjusting
the water temperature to lowest setting.
2. Fill the water reservoir with softened or distilled
water.
• To fill the reservoir, lift the bottom access door
fully open.
• Lift the reservoir cover up and off of the
water reservoir. (See Figure 8.)
• Slowly pour the water into the water reservoir
(reservoir holds a maximum of 5 cups of
water).
• Re-install water reservoir cover onto water
reservoir.
• Allow 30 minutes to preheat a full reservoir of
water.
Water Reservoir Cover
Figure 8. Water Reservoir
Use of softened
recommended to preserve the life of the
electrical and mechanical components in the
reservoir. Do not use deionized water. If "hard"
water is used, the reservoir will require periodic
cleaning and deliming. (See MAINTENANCE for
removing lime and mineral deposits.)
NOTE: Product failure due to lime or mineral
deposits is not covered under warranty.
The reservoir capacity permits uninterrupted
operation for approximately 8 hours, depending on
the settings and how frequently the door is opened.
7

OPERATION

Water Reservoir
or distilled water
Form No. GRCMWDHHIM-0907
is