Table of Contents
Advertisement
Quick Links
www.hatcocorp.com
Register Online!
(see page 2)
Installation and Operating Manual
WARNING
Do not operate this equipment unless you
have read and understood the contents of
this manual! Failure to follow the
instructions contained in this manual may
result in serious injury or death. This
manual
contains
important
information concerning the maintenance,
use, and operation of this product. If
you're unable to understand the contents
of this manual, please bring it to the
attention of your supervisor. Keep this
manual in a safe location for future
reference.
GLO-RAY
Merchandising Warmer
GRCMW-1D/H Series
P/N 07.04.448.00
ADVERTENCIA
No opere este equipo al menos que haya
leído y comprendido el contenido de este
manual! Cualquier falla en el seguimiento
de las instrucciones contenidas en este
manual puede resultar en un serio lesión
safety
o
muerte.
importante información sobre seguridad
concerniente al mantenimiento, uso y
operación de este producto. Si usted no
puede entender el contenido de este
manual
por
supervisor. Almacenar este manual en
una localización segura para la referencia
futura.
®
Este
manual
contiene
favor
pregunte
a
su
AVERTISSEMENT
Ne pas utiliser cet équipement sans avoir
lu et compris le contenu de ce manuel !
Le
non-respect
des
contenues dans ce manuel peut entraîner
de graves blessures ou la mort. Ce
manuel
contient
des
importantes
concernant
l'utilisation et le fonctionnement de ce
produit. Si vous ne comprenez pas le
contenu de ce manuel, veuillez le signaler
à votre supérieur. Conservez ce manuel
dans un endroit sûr pour pouvoir vous y
référer plus tard.
© 2012 Hatco Corporation
instructions
informations
l'entretien,
Advertisement
Table of Contents
Related Manuals for Hatco GLO-RAY GRCMW-1D Series
Summary of Contents for Hatco GLO-RAY GRCMW-1D Series
- Page 1 à votre supérieur. Conservez ce manuel manual in a safe location for future supervisor. Almacenar este manual en dans un endroit sûr pour pouvoir vous y reference. una localización segura para la referencia référer plus tard. futura. © 2012 Hatco Corporation...
-
Page 2: Table Of Contents
The Hatco Glo-Ray merchandising Warmer is a product of extensive research and field testing. The materials used were selected for maximum durability, attractive appearance, and optimum performance. -
Page 3: Important Safety Information
This unit has no “user-serviceable” parts. If service is size electrical receptacle. required on this unit, contact an Authorized Hatco Service • Turn OFF power switch, unplug power cord, and allow Agent or contact the Hatco Service Department at unit to cool before performing any cleaning, 800-558-0607 or 414-671-6350;... -
Page 4: Model Description
MODEL DESCRIPTION All Models The GRCmW-1D and GRCmW-1DH merchandising Warmers are ideal for holding food hot at customer serving points. These models feature pre-focused overhead infrared heating elements controlled by infinite switches as well as individual thermostatic temperature controls for the heated upper shelf, heated lower shelf, and humidity system. -
Page 5: Specifications
BS-1363 AS 3112 NOTE: Specification label located on the bottom of the unit. See label for serial number and verification of unit electrical information. NOTE: Receptacle not supplied by Hatco. CEE 7/7 Schuko Plug Configurations Electrical Rating Chart Model Voltage... -
Page 6: Installation
INSTALLATION General 3. Carefully lower the bottom edge of the side panel into the bottom bracket. The Glo-Ray merchandiser Warmer is shipped with most ® components pre-assembled. Care should be taken when unpacking shipping carton to avoid damage to unit and CAUTION components enclosed. -
Page 7: Operation
The switch will illuminate and the lights will SPECIFICaTIONS section for details. turn on. 2. For humidified units, fill the water reservoir with water. Hatco recommends the use of distilled water. NOTICE Use of distilled water in the water reservoir of humidified units is recommended to preserve the life of electrical and mechanical components. -
Page 8: Maintenance
This unit has no “user-serviceable” parts. If service is required on this unit, contact an Authorized Hatco Service Agent or contact the Hatco Service Department at 800-558- NOTE: Do not remove the rear mirror glass panel for cleaning. -
Page 9: Replacing Xenon Display Light Bulbs
Xenon display lamps to illuminate the warming area. Use the of the water reservoir in the GRCmW-1DH model. following procedure to replace the Xenon light bulbs (Hatco P/N 02.30.122.00). NOTE: The lime and mineral content of the water used for daily 1. -
Page 10: Troubleshooting Guide
Symptom Probable Cause Corrective Action Light bulb not working. Light bulb loose or defective. Tighten or replace light bulb. Use Hatco P/N 02.30.122.00. Power Switch turned OFF. move Power Switch to “On” position. Unit not plugged in or receptacle not Plug in unit, have receptacle repaired by a certified working. -
Page 11: Options And Accessories
Heating element(s) not working. Contact authorized Service agent or Hatco for assistance. Temperature control(s) not working properly. Contact authorized Service agent or Hatco for assistance. No heat and no lights. Power Switch turned off. - Page 12 OPTIONS AND ACCESSORIES Sign Holders and Door Locks Several sign holders and door locks are available for the Glo- Thumbscrew Sneeze merchandising Warmer. Guard Washer ® Top Sign Holder (P/N 04.49.057.00) The top sign holder mounts on the top of the unit and allows the display of custom signs.
- Page 13 OPTIONS AND ACCESSORIES Rear Access Doors Rear access doors can be installed on the Glo-Ray Left Upper Door Bracket ® merchandising Warmer in place of the glass mirror panel. The rear access doors will be installed at the factory if ordered at the Hinge Screw time of sale, but can be retro-fitted using the following procedure.
- Page 14 NOTES Form No. GRCmWDm-0412...
-
Page 15: Hatco Limited Warranty
Hatco’s written instructions or Without limiting the generality of the foregoing, SUCH 18 months from the date of shipment from Hatco. Buyer must WaRRaNTIES DO NOT COVER: Coated incandescent light establish the Product’s purchase date by registering the... -
Page 16: Authorized Parts Distributors
HATCO AUTHORIzED PARTS DISTRIBUTORS ALABAMA IOWA NEW YORK TEXAS Jones mcLeod appl. Svc. Electric motor Service Co. acme american Repairs, Inc. GCS Service Birmingham 205-251-0159 Davenport 319-323-1823 Brooklyn 718-456-6544 Fort Worth 800-433-1804 Goodwin Tucker Group alpro Service Co. armstrong Repair Service...