Linhai HY740STL 2018 Service Manual page 18

CHAPTER 2 MAINTENANCE
(H/L/R/N)
Brake fluid Level
DL
Brake fluid
Idle Speed
Toe adjustment
DL
Headlight Aim
▲
Front drive chain
sprockets) in transmission;
DL
▲
Ball joint (A arm- strut)
DL
LUBRICANT AND FLUID
Item
1. Engine Oil
2. Brake Fluid
3. Transmission Oil
4.Rear Gear case oil
5. Front Gear case
oil ( SDX30-0 )
▲
6. Front A-arm
pivot Shaft
▲
7.Steering
Post Bushings
▲
8.Front Wheel
bearings
9.Tie rods
10.Shift
Linkages
▲
11.Ball joints
▲
12.Rear Axle
Bearing
/ Pre-ride
200 hrs 24 months
/ As
Required
/ As
Required
/ As
Required
(and 300 hrs (full time in
4X4), or 1000 hrs ( in
2X4 alternate 4X4 )
10 hrs monthly
Lube Rec
SAE 15W/40 SE
DOT 3 Only
SEA 80W/90GL5
SEA 80W/90GL5
SEA 80W/90GL5
Grease
Grease
Grease
(high temperature
resist)
Grease
Grease
Inspect
Grease
M750L SERVICE MANUA 18.0
I
Change every two years
A
Periodic inspection, adjust when parts are
replaced
Adjust if necessary
I, Replace if necessary
I, (for damage, wear, and play)
R. Replace if necessary
Method
Add to proper
level on dipstick
Maintain level
Between fill lines.
"7.CONTROL"
Add to proper
level on dipstick
Add to proper
level
Add to proper
level
Locate fitting on pivot shaft
and grease with grease gun
Locate fitting on
pivot shaft and
grease with grease gun
Inspect and replace bearings if
necessary
Locate fittings and grease
Locate fittings and grease
Inspect and replace
necessary
Locate fittings and grease
CHAPTER 2
Frequency
Check level daily
As require; change
See every two years or 200
hours
Change annually or at
100 hours
Change annually or
at 100 hours
Change annually or
at 100 hours
Every 3 months or 50
hours
(
Maintenance-Free
A-arm pivot )
Every 3 months or 50
hours
Semi-annually
Semi-annually
Semi-annually
it if Semi-annually
Every 3 months or 50
hours
MAINTENANCE PAGE. 2- 5
Except