Gree GWH18QD-K6DNA1C Series Service Manual page 56

Service Manual
Safety Precautions for Installing and Relocating the Unit:
To ensure safety, please be mindful of the following precautions.
Warnings
1. When installing or relocating the unit, be sure to keep the refrigerant circuit free from air or substances other than the
VSHFL¿HG UHIULJHUDQW
$Q\ SUHVHQFH RI DLU RU RWKHU IRUHLJQ VXEVWDQFH LQ WKH UHIULJHUDQW FLUFXLW ZLOO FDXVH V\VWHP SUHVVXUH ULVH RU FRPSUHVVRU UXSWXUH UHVXOWLQJ LQ
LQMXU\
2.When installing or moving this unit, do not charge the refrigerant which is not comply with that on the nameplate or
XQTXDOL¿HG UHIULJHUDQW
2WKHUZLVH LW PD\ FDXVH DEQRUPDO RSHUDWLRQ ZURQJ DFWLRQ PHFKDQLFDO PDOIXQFWLRQ RU HYHQ VHULHV VDIHW\ DFFLGHQW
3.When refrigerant needs to be recovered during relocating or repairing the unit, be sure that the unit is running in cooling
mode.Then, fully close the valve at high pressure side (liquid valve).About 30-40 seconds later, fully close the valve at low
pressure side (gas valve), immediately stop the unit and disconnect power. Please note that the time for refrigerant recovery
should not exceed 1 minute.
,I UHIULJHUDQW UHFRYHU\ WDNHV WRR PXFK WLPH DLU PD\ EH VXFNHG LQ DQG FDXVH SUHVVXUH ULVH RU FRPSUHVVRU UXSWXUH UHVXOWLQJ LQ LQMXU\
4.During refrigerant recovery, make sure that liquid valve and gas valve are fully closed and power is disconnected before
detaching the connection pipe.
,I FRPSUHVVRU VWDUWV UXQQLQJ ZKHQ VWRS YDOYH LV RSHQ DQG FRQQHFWLRQ SLSH LV QRW \HW FRQQHFWHG DLU ZLOO EH VXFNHG LQ DQG FDXVH SUHVVXUH
ULVH RU FRPSUHVVRU UXSWXUH UHVXOWLQJ LQ LQMXU\
5.When installing the unit, make sure that connection pipe is securely connected before the compressor starts running.
,I FRPSUHVVRU VWDUWV UXQQLQJ ZKHQ VWRS YDOYH LV RSHQ DQG FRQQHFWLRQ SLSH LV QRW \HW FRQQHFWHG DLU ZLOO EH VXFNHG LQ DQG FDXVH SUHVVXUH
ULVH RU FRPSUHVVRU UXSWXUH UHVXOWLQJ LQ LQMXU\
3URKLELW LQVWDOOLQJ WKH XQLW DW WKH SODFH ZKHUH WKHUH PD\ EH OHDNHG FRUURVLYH JDV RU ÀDPPDEOH JDV
,I WKHUH OHDNHG JDV DURXQG WKH XQLW LW PD\ FDXVH H[SORVLRQ DQG RWKHU DFFLGHQWV
7.Do not use extension cords for electrical connections. If the electric wire is not long enough, please contact a local service
center authorized and ask for a proper electric wire.
3RRU FRQQHFWLRQV PD\ OHDG WR HOHFWULF VKRFN RU ¿UH
8VH WKH VSHFL¿HG W\SHV RI ZLUHV IRU HOHFWULFDO FRQQHFWLRQV EHWZHHQ WKH LQGRRU DQG RXWGRRU XQLWV )LUPO\ FODPS WKH ZLUHV VR
that their terminals receive no external stresses.
(OHFWULF ZLUHV ZLWK LQVXI¿FLHQW FDSDFLW\ ZURQJ ZLUH FRQQHFWLRQV DQG LQVHFXUH ZLUH WHUPLQDOV PD\ FDXVH HOHFWULF VKRFN RU ¿UH
Safety Precautions for Refrigerant
7R UHDOL]H WKH IXQFWLRQ RI WKH DLU FRQGLWLRQHU XQLW D VSHFLDO UHIULJHUDQW FLUFXODWHV LQ WKH V\VWHP 7KH XVHG UHIULJHUDQW LV WKH
ÀXRULGH 5ZKLFK LV VSHFLDOO\ FOHDQHG 7KH UHIULJHUDQW LV ÀDPPDEOH DQG LQRGRURXV )XUWKHUPRUH LW FDQ OHDGV WR H[SORVLRQ
XQGHU FHUWDLQ FRQGLWLRQV %XW WKH ÀDPPDELOLW\ RI WKH UHIULJHUDQW LV YHU\ ORZ ,W FDQ EH LJQLWHG RQO\ E\ ¿UH
&RPSDUHG WR FRPPRQ UHIULJHUDQWV 5 LV D QRQSROOXWLQJ UHIULJHUDQW ZLWK QR KDUP WR WKH R]RQRVSKHUH 7KH LQÀXHQFH XSRQ
the greenhouse effect is also lower. R32 has got very good thermodynamic features which lead to a really high energy
HI¿FLHQF\ 7KH XQLWV WKHUHIRUH QHHG D OHVV ¿OOLQJ
WARNING:
'R QRW XVH PHDQV WR DFFHOHUDWH WKH GHIURVWLQJ SURFHVV RU WR FOHDQ RWKHU WKDQ WKRVH UHFRPPHQGHG E\ WKH PDQXIDFWXUH
6KRXOG UHSDLU EH QHFHVVDU\FRQWDFW \RXU QHDUHVW DXWKRUL]HG 6HUYLFH &HQWUH $Q\ UHSDLUV FDUULHG RXW E\ XQTXDOL¿HG
personnel may be dangerous. The appliance shall be stored in a room without continuously operating ignition sources. (for
H[DPSOH RSHQ ÀDPHV  DQ RSHUDWLQJ JDV DSSOLDQFH RU DQ RSHUDWLQJ HOHFWULF KHDWHU
'R QRW SLHUFH RU EXUQ
$SSOLDQFH VKDOO EH LQVWDOOHG RSHUDWHG DQG VWRUHG LQ D URRP ZLWK D ÀRRU DUHD ODUJHU WKDQ P RU P 
$SSOLDQFH ¿OOHG ZLWK ÀDPPDEOH JDV 5 )RU UHSDLUV VWULFWO\ IROORZ PDQXIDFWXUHUV LQVWUXFWLRQV RQO\%H DZDUH WKDW UHIULJUDQWV
not contain odour.
5HDG VSHFLDOLVWV PDQXDO
Installation and Maintenance
53