HWH 625 Series Operator's Manual
Touch panel-controlled stabilizing system
Hide thumbs
Also See for 625 Series:
- Operator's manual (41 pages) ,
- Checklist (3 pages) ,
- Operator's manual (17 pages)
Table of Contents
Advertisement
Quick Links
H H
W
CORPORATION
R
OPERATOR'S MANUAL
HWH TOUCH PANEL-CONTROLLED
R
625 SERIES STABILIZING SYSTEM
FEATURING:
Touch Panel Control
Hydraulic Stabilizing
Two Straight-Acting Jacks
HWH HYDRAULIC JACK CONTROL
R
ON
PARK BRAKE MUST
BE SET TO OPERATE
STORE
JACK DOWN
OFF
CAUTION!
UNDERSTAND OPERATOR'S MANUAL BEFORE USING. BLOCK FRAME AND TIRES
SECURELY BEFORE REMOVING TIRES OR CRAWLING UNDER VEHICLE.
HWH CORPORATION
(On I-80, Exit 267 South)
2096 Moscow Road | Moscow, Iowa 52760
Ph: 800/321-3494 (or) 563/724-3396 | Fax: 563/724-3408
www.hwh.com
ML38734/MP04.2523
AP38733
05MAR07
Advertisement
Table of Contents
Related Manuals for HWH 625 Series
Summary of Contents for HWH 625 Series
- Page 1 CORPORATION OPERATOR’S MANUAL HWH TOUCH PANEL-CONTROLLED 625 SERIES STABILIZING SYSTEM FEATURING: Touch Panel Control Hydraulic Stabilizing Two Straight-Acting Jacks HWH HYDRAULIC JACK CONTROL PARK BRAKE MUST BE SET TO OPERATE STORE JACK DOWN CAUTION! UNDERSTAND OPERATOR’S MANUAL BEFORE USING. BLOCK FRAME AND TIRES SECURELY BEFORE REMOVING TIRES OR CRAWLING UNDER VEHICLE.
-
Page 2: How To Obtain Warranty Service
HWH CORPORATION personnel will contact you to the problem quickly. If the dealer has difficulty solving determine whether or not your claim is valid. If it is, HWH the problem, he should immediately contact the Customer CORPORATION will authorize repair or replacement of the Service Department, at HWH CORPORATION. -
Page 3: Control Identification
CONTROL IDENTIFICATION LEFT SIDE EXTEND Button HWH HYDRAULIC JACK CONTROL POWER ON Light RIGHT SIDE "ON" EXTEND Button Button STORE PARK BRAKE MUST Indicator Light BE SET TO OPERATE "STORE" STORE Button JACK DOWN "OFF" CAUTION! Button RIGHT SIDE RETRACT UNDERSTAND OPERATOR’S MANUAL BEFORE USING. -
Page 4: Operating Procedures
OPERATING PROCEDURES GENERAL INSTRUCTIONS Maintain adequate clearance in all directions for vehicle, room If the hand / auto brake is not set when the "ON" button extensions, awnings, doors, steps, etc. Vehicle may move in is pressed, the system will not function. The manual UP any direction due to jacks extending or retracting, settling of and DOWN arrows will not work. - Page 5 THERE ARE NO OBJECTS UNDER THE VEHICLE AND pushing the "ON", "STORE" or the "OFF" button on the THAT ALL PEOPLE ARE CLEAR OF THE VEHICLE. HWH touch panel will stop the automatic store function. CAUTION: NOTE: When the jacks are stored with the ignition in...
- Page 6 OPERATING PROCEDURES MANUAL HYDRAULIC OPERATION 1. Place transmission in the recommended position for parking IMPORTANT: Do not continue to push an EXTEND the vehicle, and set the parking brake. Turn the ignition to the button for more than ten (10) seconds after a jack is "ACCESSORY"...
- Page 7 Use the manual valve release for retracting the jacks only removed to gain access. DO NOT turn the 1/4" valve if the STORE feature on the HWH control panel will not release nut more than 1 full turn . Turning the nut more retract the jacks.
-
Page 8: Maintenance
Dexron automatic transmission fluid contains red dye and can cause staining should a leak occur. DO NOT USE All jacks and any HWH room extension cylinders should be brake fluid or hydraulic jack fluid. Use of these can damage completely retracted before checking the oil level. The oil seals. - Page 9 CANNOT ROLL FORWARD OR BACKWARD. qualified RV repair center, your vehicle or coach manufacturer, or HWH CORPORATION for service or repair. Set the park/brake. Switch the ignition to the "ACC" or "ON" position. Push the "ON" switch. Release the parking brake.
- Page 10 BREATHER CAP - DIPSTICK - 1/4" NUT DRIVER 1 1/2" DIAMETER VALVE RELEASE SOLENOID VALVE NOTE: DO NOT turn the valve release nut more than 4 and 1/2 (four and one half) turns counter clockwise. Damage to the valve may result. VALVE RELEASE PLASTIC PLUG 2 1/4"...