Table Of Contents - Heat & Glo 6000CMOD-IFT Installation And Appliance Setup

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Note: The term "recommend" or "recommended" does not indicate a requirement. It is a best practice suggested by
Hearth & Home Technologies
 Installation Standard Work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Specific and Important Safety Information
A. Appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Glass Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. BTU Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
E. Non-Combustible Materials Specification. . . . . . . . . . . . . . 4
F. Combustible Materials Specification . . . . . . . . . . . . . . . . . 4
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
H. California . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
I. Requirements for the Commonwealth of Massachusetts . . 5
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 6
B. Good Faith Wall Surface . . . . . . . . . . . . . . . . . . . . . . . . . . 6

C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 6
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . . 7
3 Framing and Clearances
A. Appliance/Decorative Front Dimension Diagrams . . . . . . . 8

B. Clearances to Combustibles . . . . . . . . . . . . . . . . . . . . . . 14
C. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 16
4 Termination Location and Vent Information
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 17
B. Vent Terminal Clearances . . . . . . . . . . . . . . . . . . . . . . . . 18
C. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
D. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
E. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
F. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
5 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 29
B. Wall Penetration Framing . . . . . . . . . . . . . . . . . . . . . . . . . 29
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 30
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 30
6 Appliance Preparation
A. Vent Collar Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . 31
B. Installing Optional Heat Management Systems . . . . . . . . 32
C. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 33
D. Installing the Non-combustible Board. . . . . . . . . . . . . . . . 33
2
® .
Heat & Glo • 6000CMOD-IFT, 8000CMOD-IFT Installation Manual • 2509-980 Rev. L • 6/20

Table of Contents

7 Venting and Chimneys
A. Assemble Vent Sections (DVP Pipe) . . . . . . . . . . . . . . . . 34
B . Assemble Vent Sections (SLP Pipe) . . . . . . . . . . . . . . . . 35
C. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 36
D. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 37
E. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 37
F. Vertical Termination Requirements . . . . . . . . . . . . . . . . . . 38
G. Horizontal Termination Requirements . . . . . . . . . . . . . . . 39
8 Electrical Information
A. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
9 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 44
E. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
10 Finishing
A. Facing Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
B. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 47
C. Decorative Fronts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
11 Appliance Setup
A. Remove Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . 51
B. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . . 51
C. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
D. Glass Panel Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 52
E. Media Placement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
F. IntelliFire Touch
G. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
H. Install Decorative Front . . . . . . . . . . . . . . . . . . . . . . . . . . 54
12 Reference Materials
A. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 55
B. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
 = Contains updated information.
Control System Setup . . . . . . . . . . . . . . 54
®
