Related Manuals for Pentair AUTOTROL 360
Summary of Contents for Pentair AUTOTROL 360
- Page 1 AUTOTROL 360 MANUAL & 361 SEMI-AUTOMATIC FILTER VALVES SERVICE MANUAL waterpurification.pentair.com...
-
Page 2: Table Of Contents
• Water line connections with shutoff or bypass valves. • Room to access equipment for maintenance. CALIFORNIA PROPOSITION 65 WARNING This product contains chemicals known to the WARNING: State of California to cause cancer or birth defects or other reproductive harm. 2 • AUTOTROL 360/361 Filter Valves... -
Page 3: Typical Tools And Fittings Required
• Lead Free Solder • Bucket • Towel • Plumber Tape • Adjustable Wrench 2x 3.89” (98.68 mm) • Tube 100% Silicone Grease 4.00” (101.60 mm) .75” (19.05 mm) 2.00” (50.80 mm) 2.00” (50.80 mm) Figure 1 AUTOTROL 360/361 Filter Valves • 3... -
Page 4: Valve Layout
Operating Pressure ......20-125 psi (1.38–8.61 bar) Water Temperature ..........34-100°F (1-38°C) Ambient Temperature* ........34-120°F (1-49°C) * Recommended for indoor use only Drain Line Flow Controls 1" (22.5 mm) ..........8-20 gpm (30-76 lpm) 3/4" (1.9 cm) ..........4-7 gpm (15-29 lpm) 4 • AUTOTROL 360/361 Filter Valves... - Page 5 This will provide an adequate siphon trap. 4. Secure the discharge end of the drain line to prevent it from moving. AUTOTROL 360/361 Filter Valves • 5...
-
Page 6: Startup - 360
___ If metal pipe was used, did you restore the electrical ground? ___ Securely install both drain hoses to an approved drain? ___ Perform a leak test? ___ Move the bypass valve to service? ___ Start a cleaning cycle? 6 • AUTOTROL 360/361 Filter Valves... -
Page 7: Control Operation And Layout
Service icon (361) or "0" (360) on the cleaning cycle initiation. control knob. Figure 8 361 Valve In Service Figure 9 360 Valve In Service AUTOTROL 360/361 Filter Valves • 7... -
Page 8: Flow Diagrams
3. Closed 3. Open 4. Closed 4. Closed Media Tank Media Tank FAST RINSE Untreated Water Rinse Inlet Outlet Drain Drain Control Valve No. 1. Closed 2. Open 3. Closed 4. Open Media Tank 8 • AUTOTROL 360/361 Filter Valves... -
Page 9: Valve Assembly - 360/361
...1262524 ....Europe Cord Connect Trans - 240V ..4002485 .....Kit, DLFC, 15GPM, BSP, 360, Fltr ...1000814 ....Europe Wall Trans - 240V ..4002486 .....Kit, DLFC, 20GPM, BSP, 360, Fltr ...1000810 ....Japan Wall Trans - 100V AUTOTROL 360/361 Filter Valves • 9... -
Page 10: Troubleshooting
Debris is preventing camshaft from rotating. Remove debris. Defective motor. Replace motor. Backwashes or purges at excessively low or No drain line flow control. Install drain line flow control. high rate. Restricted drain line. Remove restriction. 10 • AUTOTROL 360/361 Filter Valves... -
Page 11: Flow Performance Data Charts
FLOW PERFORMANCE DATA CHARTS Service Cv = 5.43 FLOW IN GPM Cv = 3.74 FLOW IN GPM AUTOTROL 360/361 Filter Valves • 11... - Page 12 All Pentair trademarks and logos are owned by Pentair, Inc. or its affiliates. All other registered and unregistered trademarks and logos are the property of their respective owners. Because we are continuously improving our products and services. Pentair reserves the right to change specifications without prior notice.
Need help?
Do you have a question about the AUTOTROL 360 and is the answer not in the manual?
Questions and answers