Advertisement
Table of Contents
TOYOTA 4RUNNER
PREPARATION
Part #: PK6A3-33HT1 and PK6A4-33HW1
Conflicts:
Kit Contents
Dash Camera Kit: PK6A3-33HT1
Dash Camera
Side Cover
Dash Camera
x1
PK6A4-33HT1
PK6A4-33HC0
Wire Harness Kit: PK6A4-33HW1
Wire Channel
Wire Harness
x1
Additional Items
(may be required)
Item#
Description
Recommended Sequence
of Application
Item#
Description
Issue D: 11/06/19
MicroSD Card
Owner's Manual
with Adapter
x1
x1
PK6A4-33HS0
Wire Tie
x18
x1
Recommended Tools
Personal & Vehicle Protection
Vehicle Protection
Special Tools
Dash Camera Mounting Template
Installation Tools
Screwdriver
Panel Removal Tool
Side Cutters
Torque Wrench
Pliers
Scissors
Tape Measure / Ruler
Ratchet
Tape
Socket
Special Chemicals
Cleaner
Glass Cleaner
2020 –
x1
PK6A4-33HM1
Foam Tape
Vinyl sheet
x2
Description
Blankets, Part Boxes
IADS# 4RU20-0011
#2 Phillips, Flat Blade Jeweler's
Toyota SST# 00002-06001-01
Battery: 48 in•lbf (5.4 N•m),
Ground Bolt: 75 in•lbf (8.5 N•m)
Knee Airbag: 88.5 in•lbf (10 N•m)
Needle-nose, Universal
Electrical, Masking
10mm, Extension
VDC Approved Cleaner
Toyota Touch Glass Cleaner
Page 1 of 24
DASH CAMERA
X
Harness Clip
x2
x1
Not used - Discard
Service Part #'s
Advertisement
Table of Contents
Related Manuals for Toyota PK6A3-33HT1
Summary of Contents for Toyota PK6A3-33HT1
- Page 1 TOYOTA 4RUNNER 2020 – DASH CAMERA PREPARATION Part #: PK6A3-33HT1 and PK6A4-33HW1 Conflicts: Kit Contents Dash Camera Kit: PK6A3-33HT1 Dash Camera MicroSD Card Side Cover Owner’s Manual with Adapter Dash Camera PK6A4-33HM1 PK6A4-33HT1 PK6A4-33HC0 PK6A4-33HS0 Wire Harness Kit: PK6A4-33HW1 Harness Clip Foam Tape Wire Channel Wire Harness...
-
Page 2: Table Of Contents
The installation of this accessory should follow approved has been completed. guidelines to ensure a quality installation. Follow steps carefully to These guidelines can be found in the “Toyota and Scion Accessory Installation avoid damaging the Practices” or “Lexus Accessory Installation Practices” document. Vehicle or Accessory. -
Page 3: Preparation
TOYOTA 4RUNNER 2020 – DASH CAMERA PREPARATION Issue D: 11/06/19 Page 3 of 24... -
Page 4: Procedure
TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE Disassembly Overview Front No.1 Assist Grip Plugs No. 1 Assist Grip Front Pillar Garnish RH No. 1 Forward Recognition Cover Drive Motor Switch (if equipped) Map Light Assembly Door Scuff Plate Assembly Cowl Side Trim Board RH No. - Page 5 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE c. Remove Front No. 1 Assist Fig. 1-2 Panel Removal Tool, Flat Blade Screwdriver Grip Plug RH. • Using a protective tape wrapped screwdriver (*1), detach the 2 claws and remove the front No. 1 assist grip plug RH.
- Page 6 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE Remove No.1 Forward Fig. 1-5 Recognition cover. • Detach the 2 clips and 2 guides to remove the cover as shown in the illustration. Clip Guide Downward g. Remove Drive Monitor Switch Fig. 1-6 Panel Removal Tool (w/ Drive Monitor Switch).
- Page 7 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE Remove Door Scuff Plate Fig. 1-8 Flat Blade Screwdriver, Panel Removal Tool Assembly RH. • Put protective tape (*1) around the door scuff plate assembly RH. • Using a protective tape wrapped screwdriver, detach the 4 clips, 10 claws and 2 guides to remove the door scuff plate assembly RH.
- Page 8 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE Remove No. 2 Instrument Fig. 1-11 Panel Removal Tool Panel Under Cover Sub- Assembly. • Detach the 3 clips and 2 guides and disconnect the connector to remove the No. 2 instrument panel under cover sub-assembly.
- Page 9 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE o. Remove Lower No. 2 Fig. 1-14 10mm Socket, Extension, Panel Removal Tool Instrument Panel Airbag Assembly. • Remove the 3 bolts. • Detach the 8 claws and remove the instrument panel airbag.
-
Page 10: Dash Camera Installation
TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE Remove Lower Instrument Fig. 1-17 Phillips Screwdriver, 10mm Socket, Panel Removal Tool Panel Sub-Assembly. • Remove the 3 screws and 2 bolts. • Detach the 10 clips and guide. • Remove wires for glove box lamp, and remove the lower instrument panel. - Page 11 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE NOTE: Do not touch the camera lens during install. Tape Measure/Ruler, Scissors, Phillips Screwdriver Fig. 2-3 c. Measure the Wire Channel to 90mm length and cut to size Camera Angle as shown. d. Insert the Dash Camera Wire into the Wire Channel, then...
- Page 12 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE NOTE: Be careful not to damage the Headliner. Panel Removal Tool Fig. 2-6 NOTE: To achieve maximum bond strength of adhesive, the attachment surface temperature must be at 60°F or higher. k. Attach the Dash Camera on the Windshield as shown.
-
Page 13: Wire Harness Installation
TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE p. Route the Dash Camera wire Side Cutters Fig. 2-9 along and behind the vehicle harness, then secure using 2 vehicle harness clips and 2 Wire Ties (#1, #2). • Rotate the Wire Tie Ratchet away from the A-pillar cover. - Page 14 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE b. Route the Wire Harness Ground Wire behind the 10mm Socket, Torque Wrench Fig. 3-2 reinforcement, locate “G1” Ground attachment upper right side of the Glove box area and remove the Bolt. c. Place the Wire Harness...
- Page 15 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE Wire Splicing Connector Fig. 3-5 Example (steps g-i) g. Place the Vehicle Wire in the Vehicle Wire Splicing Connector housing. h. Fold the Splicing Connector Dash Camera Housing along the pleat line. Harness Wire Pinch the Splicing Connector’s...
- Page 16 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE Route the Wire Harness with Pliers Fig. 3-7 T-taps to the Connector F42. NOTE: Reference steps g-i for Splicing Connector Hinges Wire Splicing Connector example. k. Install the Wire Harness with the Red Wire Splicing...
- Page 17 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE o. Reconnect Connector F42 to Fig. 3-10 the ECU. p. Route the Wire Harness with Fuses along the vehicle harness going towards underneath the blower motor. q. Secure one of the Wire Har- Fig.
- Page 18 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE w. Secure the Wire Harness Fuse Fig. 3-13 Side Cutters and the excess Wire Harness to the vehicle harness using 1 Wire Tie (#10) as shown. x. Bundle up as necessary the Fig. 3-14...
-
Page 19: Vehicle Reassembly
TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE 4. Vehicle Reassembly. Reassembly Overview Fig. 4-1 a. Reassemble the Vehicle. Lower Instrument Panel Sub- Assembly Instrument Panel Box Door Cover (3 pcs.) Lower No. 2 Instrument Panel Airbag Assembly Lower Instrument Cover LH Front No. 2 Console Box Insert No. - Page 20 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE d. Install the Lower No. 2 Fig. 4-3 10mm Socket, Extension, Torque Wrench Instrument Panel Airbag Assembly. • Attach the 8 claws to install the instrument panel airbag. • Install the 3 bolts.
- Page 21 TOYOTA 4RUNNER 2020 – DASH CAMERA PROCEDURE q. Position the Negative Battery Torque Wrench Fig. 4-6 Cable at the original factory position and torque the nut. Torque: 48 in•lbf (5.4 N•m) CAUTION: Do not touch the positive terminal with any tool when replacing the cable.
-
Page 22: Checklist
TOYOTA 4RUNNER 2020 – DASH CAMERA CHECKLIST – these points MUST be checked to ensure a quality installation. Accessory Function Checks Check Look For Vehicle Appearance Check Perform Look For □ After accessory installation and removal Ensure no damage (including scuffs and scratches) was of protective cover(s), perform a visual caused during the installation process. -
Page 23: Vehicle Function Checks
TOYOTA 4RUNNER 2020 – DASH CAMERA CHECKLIST – these points MUST be checked to ensure a quality installation. Vehicle Function Checks Function Function Enter the Vehicle □ □ Dome/Courtesy Lights Horn Start the Vehicle □ □ Starter Gauges □ Check Engine Light ABS Light (if equipped) □... - Page 24 TOYOTA 4RUNNER 2020 – DASH CAMERA CHECKLIST – these points MUST be checked to ensure a quality installation. Function Function □ □ Front Wiper/Washer Rear Wiper/Washer (if equipped) □ □ Power Sun/Moon Roof (if equipped) Rollover Side Curtain Air Bag Switch (RSCA) (if equipped) □...