Installation Requirements; Fuel; Engine Oil - Prochem BLAZER PLUS Operating Instructions Manual

INSTALLATION REQUIREMENTS

NOTE: Your distributor from whom you
purchased this mobile cleaning unit is
responsible for the correct installation of this
machine. The dealer is also responsible for
initial training of your operators and
maintenance personnel in the proper operation
and maintenance of this unit.
1. The unit should NOT be mounted in any motor
vehicle of less than 1/2 ton capacity.
The console with waste tank and accessories
must NOT exceed the vehicle's axle weight limit.
2. If mounting in a trailer, make certain that the
trailer is rated for the total weight of the UNIT
AND TRAILER. Electric or hydraulic brakes
should be provided, and a strict compliance with
any State and Federal vehicle laws must be
maintained.
3. The vehicle tires should have a load rating
above the combined vehicle and unit weight.
4. We do not recommend using flooring materials
that absorb water. This could result in rust and
corrosion of the vehicle floor and equipment.
5. Padding under rubber floor mats should be
removed before installing this unit.
6. We highly recommend using a galvanized drip
tray under the console (Part #56-501607).
7. If using a trailer, the BLAZER PLUS console
should be positioned so that it balances properly
with respect to the axle. Ten percent (10%) of
the overall unit weight (without accessories or
water) should be on the tongue.
Example: If loaded trailer weight is 2,000 lbs.,
tongue weight needs to be a minimum of 200
lbs. to tow properly.
FUEL REQUIREMENTS
Use unleaded gasoline ONLY. DO NOT use any
gasoline additives. We recommend the use of clean,
fresh, unleaded gasoline intended for automotive
use. High octane gasoline should NOT be used with
the engine on this unit.
ENGINE OIL REQUIREMENTS
Use high quality detergent oil of API (American
Petroleum Institute) service class SF or SG. Select
the viscosity based on the air temperature at the
time of operation as shown in the following table.
NOTE: Using other than service class SF or SG
oil or extending oil change intervals longer than
recommended can cause engine damage.
NOTE: Refer to Engine Manufacturers owners
Manual for oil use requirements.
BLAZER 980073 09/16/02
OPERATION
3-3