Table of Contents
Advertisement
TABLE OF CONTENTS
SECTION 1: Introduction........................................................1
1.1 Safety ...........................................................................1
1.2 Safety Labels and Their Placement..............................1
1.3 California Proposition 65 ..............................................1
Modulating Heating Control? .......................................1
Modulating Heating Control? .......................................1
1.6 General Requirements .................................................2
®
Systems) ......................................................................2
®
1.8 CORAYVAC
®
CTHN Multiburner Systems .......................2
1.10 Unitary Design Requirements.....................................2
1.11 Control Board and Sensor Power ...............................2
1.12 Example Site Layout...................................................3
1.13 Carton Contents .........................................................8
SECTION 2: Specifications .................................................. 10
Heating Control and COMPLETE™ Modulating
Heating Control (Unitary Heaters).............................. 10
2.2 Terminating Resistor, BT485...................................... 10
2.3 Repeater .................................................................... 10
2.4 Load Reactor ............................................................. 11
2.5 Temperature Sensors................................................. 11
2.6 Touchscreen (HMI) (Located on Central Controller:... 11
®
Modulating Heating Control) ................ 11
SECTION 3: Installation........................................................ 13
3.1 Preparation ................................................................ 13
Control ....................................................................... 15
3.3 Cable Requirements: ................................................. 16
®
and COMPLETE™ Modulating Heating
Control Installation Materials...................................... 16
Modulating Heating Control ....................................... 19
3.6 Pump Requirements .................................................. 19
3.7 Variable Frequency Drive Requirements....................20
3.8 Indoor Sensor Placement and Mounting ...................20
3.9 Indoor Sensor Addressing .........................................20
3.10 Outdoor Sensor (P/N 10081500) Placement ...........21
3.11 Outside Air Supply (P/N 90707501K) .......................21
SECTION 4: Typical Wiring Diagrams ..................................23
SECTION 5: Communications..............................................38
®
.................................................................38
5.2 BACnet/IP Connection ...............................................38
System (BMS)............................................................39
Modulating Heating Controls......................................40
5.5 Setting Baud Rate......................................................41
5.6 Terminating Resistors.................................................41
5.7 Control Board Setup ..................................................42
5.8 Touchscreen...............................................................45
5.9 The REP485 Repeater (P/N 10060156) .....................47
All rights reserved. No part of this work covered by the copyrights herein may be reproduced
or copied in any form or by any means - graphic, electronic, or mechanical, including
photocopying, recording, taping or information storage and retrieval systems - without the
written permission of Roberts-Gordon LLC.
®
®
®
®
®
Modulating
®
®
© 2019
Roberts-Gordon LLC
SECTION 6: Variable Frequency Drive Programming ........ 48
®
GORDON
Control ....................................................................... 48
6.2 Altering VFD Parameters ........................................... 49
Heating Control ......................................................... 52
System.............................................................. 58
8.1 Passwords ................................................................. 58
8.2 Home Screen and Programming the System ............ 59
8.3 Home Screen System Configuration ......................... 59
8.4 Zone Temperature Setpoints ..................................... 60
8.5 Schedule Creation..................................................... 60
8.6 Edit Existing Schedule .............................................. 62
8.7 Zone Configuration (Zone Setup).............................. 62
8.8 Maintenance.............................................................. 63
8.9 Alarms ....................................................................... 63
8.10 Alarm Configuration................................................. 63
8.11 VFD Status .............................................................. 63
8.12 Unit Configuration.................................................... 64
8.13 Adjust Time.............................................................. 64
SECTION 9: Troubleshooting............................................... 66
SECTION 10: Controls Start-Up Checklist ......................... 83
SECTION 11: Replacement Parts ........................................ 84
®
Replacement Parts.................................................... 85
Replacement Parts.................................................... 86
11.3 Repeater Replacement Parts ................................... 87
11.4 Replacement Parts Instructions ............................... 88
System (BMS) ................................................ 89
®
12.1 BACnet over ARC156 .............................................. 89
12.2 BACnet MS/TP ........................................................ 91
12.3 BACnet PTP ............................................................ 93
12.4 BACnet Over IP ....................................................... 94
12.5 BACnet over Ethernet.............................................. 96
12.6 Modbus ................................................................... 97
Port 1......................................................................100
12.8 LonWorks ...............................................................102
SECTION 13: Touchscreen Tree..........................................104
Limited Warranty .........................................113
®
Modulating Heating
®
®
System .... 55
®
End Burner Vacuum.......... 55
®
®
/
Advertisement
Table of Contents
Troubleshooting
