Yaesu DR-1X Technical Supplement
  1. Manuals
  2. Brands
  3. Yaesu Manuals
  4. Repeater
  5. DR-1X
  6. Technical supplement

Yaesu DR-1X Technical Supplement

Vhf/uhf ams digital repeater
Hide thumbs Also See for DR-1X:
Table of Contents

Advertisement

Quick Links

See also: Operating Manual
144/430 MHz 50 W VHF/UHF AMS DIGITAL REPEATER
DR-1X/XE

Introduction

This manual provides the technical information necessary for servicing the DR-1X/XE 144/430 MHz 50 W VHF/UHF AMS DIGI-
TAL REPEATER.
Servicing this equipment requires expertise in handing surface-mount chip components. Attempts by non-qualified persons to
service this equipment may result in permanent damage not covered by the warranty, and may be illegal in some countries.
Two PCB layout diagrams provided for each double-sided board in this transceiver. Each side of the board is referred to by the
type of the majority of components installed on that side ("Side A" or "Side B"). In most cases one side has only chip compo-
nents, and the other has either a mixture of both chip and leaded components (trimmers, coils, electrolytic capacitors, ICs, etc.),
or leaded components only.
While we believe the information in this manual to be correct, YAESU assumes no liability for damage that may occur as a result
of typographical or other errors that may be present. Your cooperation in pointing out any inconsistencies in the technical infor-
mation would be appreciated.
Exploded View & Miscellaneous Parts
Board Unit (Schematics, Layouts & Parts)
TX-MAIN Unit
PANEL-1 Unit
PANEL-2 Unit
RX-MAIN Unit
RELAY-Unit
FILTER-Unit
DSP Unit
1) This transceiver was assembled using Pb (lead) free solder, based on the RoHS specification.
Only lead-free solder (Alloy Composition: Sn-3.0Ag-0.5Cu) should be used for repairs performed on this apparatus. The solder stat-
ed above utilizes the alloy composition required for compliance with the lead-free specification, and any solder with the above alloy
composition may be used.
2) Risk of explosion if battery is replaced by an incorrect type. Dispose of used batteries according to the instructions.
Technical Supplement
C4FM FDMA/FM

Contents

Important Note

Advertisement

Table of Contents
loading

Related Manuals for Yaesu DR-1X

Summary of Contents for Yaesu DR-1X

  • Page 1 While we believe the information in this manual to be correct, YAESU assumes no liability for damage that may occur as a result of typographical or other errors that may be present. Your cooperation in pointing out any inconsistencies in the technical infor- mation would be appreciated.

  • Page 2: Specifications

    AC 100 to 240 V (DR-1X, except AUS version) DC 11.7 to 15.8 V , negative ground Current Consumption: AC: 2 A (max) (@ 117 V Input) (DR-1X, except AUS version) DC: 1.5 A (receive) 10 A (50 W TX, 144 MHz band)
  • Page 11 Alignment Introduction and Precautions Required Test Equipment The DR-1X/DR-1XE has been carefully aligned at RF Signal Generator with calibrated output lev- the factory for performance across the specified el at 1 GHz amateur bands. Realignment should therefore Deviation Meter (linear detector)
  • Page 12 [ 0 ] à [ 3 ] à [ 4 ] à [ 0 ] à [ 3 ] à [ 4 ] 8. Press the [ POWER ( LOCK )] key. "UNLOCK" will appear in the display. 9. The transceiver is now in the "Alignment mode". MIC Jack ALIGNMENT-2 DR-1X/XE Technical Supplement...
  • Page 13 TX-MAIN-UNIT Tune to: TX/RX 440.05 MHz 2.1 ± 0.4 V 146.05 MHz 2.0 ± 0.4 V RX-MAIN-UNIT Tune to: TX/RX 440.05 MHz 2.6 ± 0.4 V 146.05 MHz 1.2 ± 0.4 V TP1503 TP5502 TX-MAIN-UNIT RX-MAIN-UNIT ALIGNMENT-3 DR-1X/XE Technical Supplement...
  • Page 14 18. Press the [ P2 ] key of the Microphone to set the 39. Press the [ P2 ] key of the Microphone to set the alignment menu Item to "Adj 02 DRV". alignment menu Item to "Adj 02 PWR". 19. Adjust the DIAL knob to set the DRV to "D0". ALIGNMENT-4 DR-1X/XE Technical Supplement...
  • Page 15 DIAL knob, if necessary, so the count- the0.001μF capactor to the TP5509. er frequency is within 100 Hz of 435.050MHz. 12. Adjust adjust the DIAL knob, as needed, so that 6. Set the RX-MAIN-UNIT frequency to 435.050 thecounter frequency reading is 387.800 MHz MHz. (±100Hz). TP5509 TP5501 RX-MAIN-UNIT ALIGNMENT-5 DR-1X/XE Technical Supplement...
  • Page 16 5. Set the RX-MAIN-UNIT and RF signal genera- drops slightly lower than maximum. tor frequency to 145.050 MHz. 6. Adjust the DIAL knob for maximum deflection on the DC Voltmeter and then turn the dialin the opposite direction until the meter deflection drops slightly lower than maximum. TP5001 TP5002 RX-MAIN-UNIT ALIGNMENT-6 DR-1X/XE Technical Supplement...
  • Page 17 23. Increase the output level of the signal genera- 23. Increase the output level of the signal genera- torup to -3 dBμV. torup to +23 dBμV. 24. Press the [ P3 ] key to save the new setting. 24. Press the [ P3 ] key to save the new setting. ALIGNMENT-7 DR-1X/XE Technical Supplement...
  • Page 18 0.65 kHz ~ 0.75 kHz. to select "LO". 10. Press the [ F ( MW )] key. 11. Press the PTT switch to activate the transmitter, adjust the DIAL knob so that the DeviationMe- ter reading is 4.5 kHz (±0.2 kHz) (USA Version: 4.2 kHz (±0.2 kHz). ALIGNMENT-8 DR-1X/XE Technical Supplement...
  • Page 19 [ POWER ( LOCK )] switch for two seconds. Press and hold in the [ D ( X )] and [ DISP )] keys while turning the transceiver on. The transceiver is now in the "Repeater mode". ALIGNMENT-9 DR-1X/XE Technical Supplement...
  • Page 23 0.001uF GRM155B11H102KA01D K22178809 C 1067 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1068 CHIP CAP. GRM1553C1H3R0BA01D K22178290 C 1069 CHIP CAP. GRM1552C1H6R0BA01D K22178293 C 1070 CHIP CAP. 12pF GRM1552C1H120JA01D K22178214 C 1071 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 TX-MAIN-4 DR-1X/XE Technical Supplement...
  • Page 24 GRM155B11H102KA01D K22178809 C 1143 CHIP CAP. 0.5pF GRM1554C1HR50BA01D K22178285 C 1144 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1145 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1146 CHIP CAP. 47pF GRM1552C1H470GA01D K22179709 C 1147 CHIP CAP. GRM1554C1H2R0BA01D K22178289 TX-MAIN-5 DR-1X/XE Technical Supplement...
  • Page 25 K22088802 C 1222 CHIP CAP. GRM1554C1H2R0BA01D K22178289 C 1223 CHIP CAP. 0.01uF GRM155B11E103KA01D K22148834 C 1224 CHIP CAP. 22pF GRM1552C1H220GA01D K22179707 C 1225 CHIP CAP. 100pF GRM1552C1H101JA01D K22178236 C 1226 CHIP TA.CAP. 22uF 6.3V TMCMA0J226MTRF K78080047 TX-MAIN-6 DR-1X/XE Technical Supplement...
  • Page 26 K22108802 C 1293 CHIP CAP. 0.0022uF GRM155B11H222KA01D K22178813 C 1294 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 1295 CHIP CAP. 0.01uF GRM155B11E103KA01D K22148834 C 1296 CHIP CAP. 0.047uF GRM155B11A473KA01D K22108801 C 1297 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 TX-MAIN-7 DR-1X/XE Technical Supplement...
  • Page 27 GRM155B11C223KA01D K22128806 C 1358 CHIP CAP. 6.3V GRM155B30J105KE18D K22088803 C 1359 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 1360 CHIP CAP. 0.047uF GRM155B11A473KA01D K22108801 C 1362 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 1364 AL.ELECTRO.CAP. 470uF RVZ-10V471M K48100010 TX-MAIN-8 DR-1X/XE Technical Supplement...
  • Page 28 K22088803 C 1427 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1428 CHIP CAP. 0.01uF GRM155B11E103KA01D K22148834 C 1429 CHIP CAP. 0.01uF GRM155B11E103KA01D K22148834 C 1430 CHIP CAP. 0.01uF GRM155B11E103KA01D K22148834 C 1431 CHIP CAP. 0.01uF GRM155B11E103KA01D K22148834 TX-MAIN-9 DR-1X/XE Technical Supplement...
  • Page 29 CHIP CAP. GRM1552C1H8R0BA01D K22178295 C 1559 CHIP CAP. 12pF 200V GRM2192C2D120JV01D K22230217 C 1560 CHIP CAP. 33pF 250V GQM2195C2E330GB12D K22240231 C 1561 CHIP CAP. 33pF 250V GQM2195C2E330GB12D K22240231 C 1562 CHIP CAP. 27pF 250V GQM2195C2E270GB12D K22240230 TX-MAIN-10 DR-1X/XE Technical Supplement...
  • Page 30 GRM155B11H102KA01D K22178809 C 1640 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1641 CHIP CAP. GRM1552C1H7R0BA01D K22178294 C 1642 CHIP CAP. 100pF GRM1552C1H101JA01D K22178236 C 1643 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1644 CHIP CAP. 0.01uF GRM155B11E103KA01D K22148834 TX-MAIN-11 DR-1X/XE Technical Supplement...
  • Page 31 GRM1552C1H160JA01D K22178217 C 1717 CHIP CAP. 20pF GRM1552C1H200GA01 K22179702 C 1718 CHIP CAP. 0.001uF GRM188B11H102KA01D K22174821 C 1719 CHIP CAP. GRM1552C1H9R0BA01D K22178296 C 1720 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1721 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 TX-MAIN-12 DR-1X/XE Technical Supplement...
  • Page 32 GRM155B11H102KA01D K22178809 C 1795 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 1796 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 1797 CHIP CAP. GRM1552C1H5R0BA01D K22178292 C 1798 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1799 CHIP TA.CAP. 10uF TAJA106M010Y K78100072 TX-MAIN-13 DR-1X/XE Technical Supplement...
  • Page 33 GRM188B11C104KA01D K22124805 C 1869 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 1870 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 1871 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 1872 CHIP CAP. GRM1554C1H2R0BA01D K22178289 C 1873 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 TX-MAIN-14 DR-1X/XE Technical Supplement...
  • Page 34 HVC131TRF-E G2070676 D 1038 DIODE HVC131TRF-E G2070676 D 1039 DIODE HVC131TRF-E G2070676 D 1040 DIODE 1SS400 TE61 G2070634 D 1041 DIODE 1SS400 TE61 G2070634 D 1042 DIODE 1SS400 TE61 G2070634 D 1043 DIODE 1SS400G T2R G2070934 TX-MAIN-15 DR-1X/XE Technical Supplement...
  • Page 35 EDZ TE-61 5.1B G2070998 D 1558 DIODE EDZ TE-61 5.1B G2070998 D 1559 DIODE EDZ TE-61 5.1B G2070998 D 1560 DIODE EDZ TE-61 5.1B G2070998 D 1561 SURGE ABSORBER P6KA18A-E3 Q9000721 D 1561 SURGE ABSORBER P6KA18A-HE3 Q9000721A TX-MAIN-16 DR-1X/XE Technical Supplement...
  • Page 36 L 1003 M.RFC 0.01uH TFL0510-10N L1690811 L 1003 M.RFC 0.01uH LL1005-FHL10NG L1691797 L 1004 M.RFC 0.1uH C1608CB-R10G-RF L1691045 L 1005 M.RFC 0.01uH C1608CB-10NG-RF L1691032 L 1006 COIL E2 0.28-1.0-4T-R L0022365 L 1007 COIL E2 0.28-1.0-4T-R L0022365 TX-MAIN-17 DR-1X/XE Technical Supplement...
  • Page 37 L 1065 M.RFC 0.39uH C1608CB-R39G-RF L1691107 L 1066 M.RFC 0.39uH C1608CB-R39G-RF L1691107 L 1067 M.RFC 0.39uH C1608CB-R39G-RF L1691107 L 1068 M.RFC LK1608 1R0K-T L1690687 L 1069 M.RFC 0.1uH C1608CB-R10G-RF L1691045 L 1070 M.RFC 0.01uH TFL0510-10N L1690811 TX-MAIN-18 DR-1X/XE Technical Supplement...
  • Page 38 LK1608 1R0K-T L1690687 L 1560 M.RFC 6.8uH KQ1008TE6R8G L1691214 L 1561 M.RFC 0.47uH LK1608 R47K-T L1690414 L 1562 M.RFC LK1608 1R0K-T L1690687 L 1563 M.RFC LK1608 1R0K-T L1690687 Q 1001 3SK296ZQ-TL-E G4802968 Q 1002 3SK296ZQ-TL-E G4802968 TX-MAIN-19 DR-1X/XE Technical Supplement...
  • Page 39 G1094009 Q 1501 TRANSISTOR DTC143EE TL G3070114 Q 1502 TRANSISTOR DTC143EE TL G3070114 Q 1503 TRANSISTOR DTC143EE TL G3070114 Q 1504 RD70HUF2 G3090157 Q 1505 RD07MVS1-T12 G3070320 Q 1506 RQA0004PXDQS G3070391 Q 1507 TRANSISTOR 2SC5585-TL G3355858 TX-MAIN-20 DR-1X/XE Technical Supplement...
  • Page 40 G3070341 Q 1577 TRANSISTOR 2SA2029 T2L Q/R G3120298 Q 1578 TRANSISTOR DTC144EM T2L G3070309 Q 1579 TRANSISTOR EMD12 T2R G3070341 Q 1580 NJM2831F03-TE1 G1094902 Q 1581 TRANSISTOR DTA144EE TL G3070074 Q 1582 TRANSISTOR DTC144EE TL G3070075 TX-MAIN-21 DR-1X/XE Technical Supplement...
  • Page 41 J24189050 R 1061 CHIP RES. 220k 1/16W RMC1/16S 224JTH J24189053 R 1062 CHIP RES. 1/16W RMC1/16S 151JTH J24189015 R 1063 CHIP RES. 1.8k 1/16W RMC1/16S 182JTH J24189028 R 1064 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 TX-MAIN-22 DR-1X/XE Technical Supplement...
  • Page 42 1/16W RMC1/16S JPTH J24189070 R 1134 CHIP RES. 1/16W RMC1/16S JPTH J24189070 R 1135 CHIP RES. 1/16W RMC1/16S JPTH J24189070 R 1136 CHIP RES. 1/16W RMC1/16S JPTH J24189070 R 1137 CHIP RES. 1/16W RMC1/16S JPTH J24189070 TX-MAIN-23 DR-1X/XE Technical Supplement...
  • Page 43 J24189051 R 1216 CHIP RES. 1/16W RMC1/16S JPTH J24189070 R 1217 CHIP RES. 150k 1/16W RMC1/16S 154JTH J24189051 R 1218 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 R 1219 CHIP RES. 2.2k 1/16W RMC1/16S 222JTH J24189029 TX-MAIN-24 DR-1X/XE Technical Supplement...
  • Page 44 1/16W RMC1/16S 101JTH J24189013 R 1293 CHIP RES. 1/16W RMC1/16S 563JTH J24189046 R 1294 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 R 1295 CHIP RES. 1/16W RMC1/16S 103JTH J24189037 R 1296 CHIP RES. 1/16W RMC1/16S 103JTH J24189037 TX-MAIN-25 DR-1X/XE Technical Supplement...
  • Page 45 RMC1/16S 224JTH J24189053 R 1369 CHIP RES. 1/16W RMC1/16S 223JTH J24189041 R 1370 CHIP RES. 1/16W RMC1/16S 103JTH J24189037 R 1371 CHIP RES. 6.8k 1/16W RMC1/16S 682JTH J24189035 R 1372 CHIP RES. 1/16W RMC1/16S 223JTH J24189041 TX-MAIN-26 DR-1X/XE Technical Supplement...
  • Page 46 1/16W RMC1/16S 103JTH J24189037 R 1505 CHIP RES. 1/16W RMC1/16S 103JTH J24189037 R 1506 CHIP RES. 1/16W RMC1/16S 330JTH J24189007 R 1507 CHIP RES. 1/16W RMC1/16S 330JTH J24189007 R 1508 CHIP RES. 1/16W RMC1/16S 103JTH J24189037 TX-MAIN-27 DR-1X/XE Technical Supplement...
  • Page 47 RMC1/16S 334JTH J24189055 R 1580 CHIP RES. 2.2M 1/16W RMC1/16S 225JTH J24189065 R 1581 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 R 1582 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 R 1583 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 TX-MAIN-28 DR-1X/XE Technical Supplement...
  • Page 48 RMC1/16S 471JTH J24189021 R 1654 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 R 1655 CHIP RES. 120k 1/16W RMC1/16S 124JTH J24189050 R 1656 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 R 1657 CHIP RES. 1/16W RMC1/16S 470JTH J24189009 TX-MAIN-29 DR-1X/XE Technical Supplement...
  • Page 49 RMC1/16S 100JTH J24189001 R 1742 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 R 1743 CHIP RES. 1/16W RMC1/16S 823JTH J24189048 R 1744 CHIP RES. 1/16W RMC1/16S 823JTH J24189048 R 1745 CHIP RES. 1/16W RMC1/16S 823JTH J24189048 TX-MAIN-30 DR-1X/XE Technical Supplement...
  • Page 50 RMC1/16S 221JTH J24189017 R 1817 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 R 1818 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 R 1819 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 R 1820 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 TX-MAIN-31 DR-1X/XE Technical Supplement...
  • Page 51 RMC1/16S 221JTH J24189017 R 1891 CHIP RES. 1/16W RMC1/16S 102JTH J24189025 R 1892 CHIP RES. 1/16W RMC1/16S 102JTH J24189025 R 1893 CHIP RES. 470k 1/16W RMC1/16S 474JTH J24189057 R 1894 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 TX-MAIN-32 DR-1X/XE Technical Supplement...
  • Page 52 H9501460 X 1503 XTAL VT-200 32.768KHZ 20PPM/6PF H0103267 X 1504 XTAL U4B 12.288MHz 12.288MHZ H0103411 XF1001 XTAL FILTER 47R15A9 47.250MHZ H1102400 XF1002 XTAL FILTER 47R15A9 47.250MHZ H1102400 XF1003 XTAL FILTER MFT44R 44.85MHZ H1102443 GASKET (6612) RA1058400 TX-MAIN-33 DR-1X/XE Technical Supplement...
  • Page 53 TX-MAIN Unit Parts List DESCRIPTION VALUE TOL. MFR'S DESIG YAESU P/N VERS. LOT SIDE LAY ADR GASKET (10x15) RA1262000 SPACER (5X5) RA1564100 SHEET (11X20) RA6001900 SHEET (102004) RA6016200 TX-MAIN-34 DR-1X/XE Technical Supplement...
  • Page 57 K22108802 C 2067 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 2068 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 2069 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 2070 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 2071 CHIP CAP. 100pF GRM1552C1H101JA01D K22178236 PANEL-1-4 DR-1X/XE Technical Supplement...
  • Page 58 NJM2370U33-TE1 G1094564 Q 2021 TRANSISTOR 2SC4617 TL R G3346178R Q 2022 TRANSISTOR 2SB1132 T100 R G3211327R Q 2023 TRANSISTOR 2SC4617 TL R G3346178R Q 2024 TRANSISTOR 2SC5006-T1-A/YFB G3350068 R 2001 CHIP RES. 1/16W RMC1/16S 473JTH J24189045 PANEL-1-5 DR-1X/XE Technical Supplement...
  • Page 59 RMC1/16S 103JTH J24189037 R 2072 CHIP RES. 2.2k 1/16W RMC1/16S 222JTH J24189029 R 2073 CHIP RES. 4.7k 1/16W RMC1/16S 472JTH J24189033 R 2074 CHIP RES. 1/16W RMC1/16S 103JTH J24189037 R 2075 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 PANEL-1-6 DR-1X/XE Technical Supplement...
  • Page 60 RB2005 BLOCK RES. MNR04M0ABJ102 J42900039 RB2006 BLOCK RES. MNR04M0ABJ102 J42900039 S 2007 SLIDE SWITCH SSSS820201 N6090107 S 2008 SLIDE SWITCH SSSS820201 N6090107 X 2001 XTAL 12.288MHz 7M12280001 12.288MHZ H0103413 SHIELD CASE COVER (DRAM) RA1438500 CAPTON TAPE (15X10) RA1145500 PANEL-1-7 DR-1X/XE Technical Supplement...
  • Page 64 K22108802 C 3067 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 3068 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 3069 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 3070 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 3071 CHIP CAP. 100pF GRM1552C1H101JA01D K22178236 PANEL-2-4 DR-1X/XE Technical Supplement...
  • Page 65 NJM2370U33-TE1 G1094564 Q 3021 TRANSISTOR 2SC4617 TL R G3346178R Q 3022 TRANSISTOR 2SB1132 T100 R G3211327R Q 3023 TRANSISTOR 2SC4617 TL R G3346178R Q 3024 TRANSISTOR 2SC5006-T1-A/YFB G3350068 R 3001 CHIP RES. 1/16W RMC1/16S 473JTH J24189045 PANEL-2-5 DR-1X/XE Technical Supplement...
  • Page 66 RMC1/16S 103JTH J24189037 R 3072 CHIP RES. 2.2k 1/16W RMC1/16S 222JTH J24189029 R 3073 CHIP RES. 4.7k 1/16W RMC1/16S 472JTH J24189033 R 3074 CHIP RES. 1/16W RMC1/16S 103JTH J24189037 R 3075 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 PANEL-2-6 DR-1X/XE Technical Supplement...
  • Page 67 MNR04M0ABJ102 J42900039 RB3005 BLOCK RES. MNR04M0ABJ102 J42900039 RB3006 BLOCK RES. MNR04M0ABJ102 J42900039 S 3007 SLIDE SWITCH SSSS820201 N6090107 S 3008 SLIDE SWITCH SSSS820201 N6090107 X 3001 XTAL 12.288MHz 7M12280001 12.288MHZ H0103413 SHIELD CASE COVER (DRAM) RA1438500 PANEL-2-7 DR-1X/XE Technical Supplement...
  • Page 68 1/16W RMC1/16 000JATP J24185000 R 4008 CHIP RES. 1/16W RMC1/16 000JATP J24185000 R 4009 CHIP RES. 1/16W RMC1/16 000JATP J24185000 R 4010 CHIP RES. 1/16W RMC1/16 000JATP J24185000 R 4011 CHIP RES. 1/16W RMC1/16 000JATP J24185000 JACK-1 DR-1X/XE Technical Supplement...
  • Page 72 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5068 CHIP CAP. GRM1553C1H3R0BA01D K22178290 C 5069 CHIP CAP. GRM1552C1H6R0BA01D K22178293 C 5070 CHIP CAP. 12pF GRM1552C1H120JA01D K22178214 C 5071 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5072 CHIP CAP. GRM1552C1H6R0BA01D K22178293 RX-MAIN-4 DR-1X/XE Technical Supplement...
  • Page 73 0.5pF GRM1554C1HR50BA01D K22178285 C 5144 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5145 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5146 CHIP CAP. 47pF GRM1552C1H470GA01D K22179709 C 5147 CHIP CAP. GRM1554C1H2R0BA01D K22178289 C 5148 CHIP CAP. GRM1553C1H3R0BA01D K22178290 RX-MAIN-5 DR-1X/XE Technical Supplement...
  • Page 74 C 5225 CHIP CAP. 100pF GRM1552C1H101JA01D K22178236 C 5226 CHIP TA.CAP. 22uF 6.3V TMCMA0J226MTRF K78080047 C 5227 CHIP CAP. 0.01uF GRM155B11E103KA01D K22148834 C 5228 CHIP TA.CAP. 10uF TAJA106M010Y K78100072 C 5229 CHIP CAP. 220pF GRM1552C1H221JA01D K22179713 RX-MAIN-6 DR-1X/XE Technical Supplement...
  • Page 75 K22148834 C 5296 CHIP CAP. 0.047uF GRM155B11A473KA01D K22108801 C 5297 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 5298 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 5299 CHIP CAP. 0.0047uF GRM155B11H472KA01D K22178838 C 5300 CHIP CAP. 150pF GRM1552C1H151JA01D K22178240 RX-MAIN-7 DR-1X/XE Technical Supplement...
  • Page 76 EMVA160ADA221MF80G K48120021 C 5368 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5369 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5370 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5371 CHIP CAP. 100pF GRM1552C1H101JA01D K22178236 C 5372 AL.ELECTRO.CAP. 100uF RVZ-10V101MF55U-R2 K48100008 RX-MAIN-8 DR-1X/XE Technical Supplement...
  • Page 77 K22178228 C 5500 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5501 CHIP CAP. 200V GRM1882C2D4R0CV01D K22234206 C 5502 CHIP CAP. 200V GRM1882C2D4R0CV01D K22234206 C 5504 CHIP CAP. 200V GRM1884C2D2R0CV01D K22234204 C 5505 CHIP CAP. 200V GRM1883C2D3R0CV01D K22234205 RX-MAIN-9 DR-1X/XE Technical Supplement...
  • Page 78 GRM155B11H102KA01D K22178809 C 5715 CHIP CAP. GRM1554C1H1R0BA01D K22178287 C 5716 CHIP CAP. 18pF GRM1552C1H180GA01D K22179701 C 5717 CHIP CAP. 18pF GRM1552C1H180GA01D K22179701 C 5718 CHIP CAP. 0.001uF GRM188B11H102KA01D K22174821 C 5719 CHIP CAP. 15pF GRM1552C1H150GA01D K22178300 RX-MAIN-10 DR-1X/XE Technical Supplement...
  • Page 79 K22178809 C 5823 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5824 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5825 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5826 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 C 5827 CHIP CAP. 0.001uF GRM155B11H102KA01D K22178809 RX-MAIN-11 DR-1X/XE Technical Supplement...
  • Page 80 GRM1552C1H470JA01D K22178228 C 5961 CHIP CAP. 820pF GRM155B11H821KA01D K22178808 C 5962 CHIP CAP. 6.3V GRM155B30J105KE18D K22088803 C 5963 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 5964 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 5966 CHIP CAP. GRM155B31A105KE15D K22108809 RX-MAIN-12 DR-1X/XE Technical Supplement...
  • Page 81 DIODE DAN222 TL G2070174 D 5059 DIODE DA221 TL G2070178 D 5505 SURGE ABSORBER RHCA-301Q43U Q9000827 D 5517 DIODE HSC277TRF-E G2070584 D 5518 DIODE HVC375B-TRF-E G2070856 D 5519 DIODE HVC375B-TRF-E G2070856 D 5520 DIODE HSC277TRF-E G2070584 RX-MAIN-13 DR-1X/XE Technical Supplement...
  • Page 82 L1690843 FB5521 FERRITE BEADS BLM15AG121SN1D L1690843 FB5522 FERRITE BEADS BLM15AG121SN1D L1690843 FB5523 FERRITE BEADS BLM15AG121SN1D L1690843 FB5524 FERRITE BEADS BLM15AG121SN1D L1690843 FB5525 FERRITE BEADS BLM15AG121SN1D L1690843 FB5526 FERRITE BEADS BLM15AG121SN1D L1690843 FB5527 FERRITE BEADS SMB304729 L9190094 RX-MAIN-14 DR-1X/XE Technical Supplement...
  • Page 83 L 5027 M.RFC 0.082uH C1608CB-82NG-RF L1691044 L 5028 M.RFC 0.082uH C1608CB-82NG-RF L1691044 L 5029 M.RFC 0.082uH C1608CB-82NG-RF L1691044 L 5030 M.RFC 0.047uH TFL0816-47 L1690499 L 5030 M.RFC 0.047uH LL1608-FSL47NJ L1690367 L 5031 M.RFC LK1608 1R0K-T L1690687 RX-MAIN-15 DR-1X/XE Technical Supplement...
  • Page 84 L 5544 M.RFC 0.022uH LL1608-FSL22NJ L1690865 L 5545 M.RFC 0.39uH C1608CB-R39G-RF L1691107 L 5547 M.RFC 0.01uH C1608CB-10NG-RF L1691032 L 5548 M.RFC 0.22uH LL1608-FSLR22J L1691072 L 5549 M.RFC 0.15uH LK1608 R15K-T L1690409 L 5550 M.RFC 0.039uH C1608CB-39NG-RF L1691039 RX-MAIN-16 DR-1X/XE Technical Supplement...
  • Page 85 DTC144EE TL G3070075 Q 5058 CD4053BPWR G1093864 Q 5059 CD74HCT4053PWR G1094273 Q 5060 TRANSISTOR DTC144EE TL G3070075 Q 5100 LM2904PWR G1094010 Q 5102 LM2904PWR G1094010 Q 5105 LM2902PWR G1094009 Q 5106 LM2902PWR G1094009 Q 5109 LM2902PWR G1094009 RX-MAIN-17 DR-1X/XE Technical Supplement...
  • Page 86 TRANSISTOR DTC144EE TL G3070075 Q 5585 TC7W53FU(TE12L_F) G1094158 Q 5586 TC7W53FU(TE12L_F) G1094158 Q 5588 TRANSISTOR DTC144EM T2L G3070309 Q 5903 TRANSISTOR DTC144EE TL G3070075 Q 5904 TRANSISTOR DTC144EE TL G3070075 Q 5905 TRANSISTOR DTC144EE TL G3070075 RX-MAIN-18 DR-1X/XE Technical Supplement...
  • Page 87 RMC1/16S 220JTH J24189005 R 5068 CHIP RES. 4.7k 1/16W RMC1/16S 472JTH J24189033 R 5069 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 R 5070 CHIP RES. 220k 1/16W RMC1/16S 224JTH J24189053 R 5071 CHIP RES. 1/16W RMC1/16S 473JTH J24189045 RX-MAIN-19 DR-1X/XE Technical Supplement...
  • Page 88 1/16W RMC1/16S JPTH J24189070 R 5144 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 R 5145 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 R 5146 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 R 5147 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 RX-MAIN-20 DR-1X/XE Technical Supplement...
  • Page 89 1/16W RMC1/16S 223JTH J24189041 R 5226 CHIP RES. 1/16W RMC1/16S 223JTH J24189041 R 5227 CHIP RES. 1/16W RMC1/16S 223JTH J24189041 R 5228 CHIP RES. 1/16W RMC1/16S 223JTH J24189041 R 5229 CHIP RES. 1/16W RMC1/16S 223JTH J24189041 RX-MAIN-21 DR-1X/XE Technical Supplement...
  • Page 90 RMC1/16S 102JTH J24189025 R 5302 CHIP RES. 1/16W RMC1/16S 102JTH J24189025 R 5303 CHIP RES. 4.7k 1/16W RMC1/16S 472JTH J24189033 R 5304 CHIP RES. 1/16W RMC1/16S 150JTH J24189003 R 5305 CHIP RES. 1/16W RMC1/16S 150JTH J24189003 RX-MAIN-22 DR-1X/XE Technical Supplement...
  • Page 91 J24189049 R 5379 CHIP RES. 8.2k 1/16W RMC1/16S 822JTH J24189036 R 5380 CHIP RES. 1/16W RMC1/16S 153JTH J24189039 R 5382 CHIP RES. 470k 1/16W RMC1/16S 474JTH J24189057 R 5383 CHIP RES. 150k 1/16W RMC1/16S 154JTH J24189051 RX-MAIN-23 DR-1X/XE Technical Supplement...
  • Page 92 1/16W RMC1/16S 103JTH J24189037 R 5619 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 R 5620 CHIP RES. 1/16W RMC1/16S 102JTH J24189025 R 5621 CHIP RES. 1/16W RMC1/16S 102JTH J24189025 R 5622 CHIP RES. 1/16W RMC1/16S 473JTH J24189045 RX-MAIN-24 DR-1X/XE Technical Supplement...
  • Page 93 J24189040 R 5707 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 R 5708 CHIP RES. 1/16W RMC1/16S 470JTH J24189009 R 5709 CHIP RES. 4.7k 1/16W RMC1/16S 472JTH J24189033 R 5715 CHIP RES. 330k 1/16W 0.5% MCR01MZPD3303 J24189330 RX-MAIN-25 DR-1X/XE Technical Supplement...
  • Page 94 RMC1/16S 221JTH J24189017 R 5817 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 R 5818 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 R 5819 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 R 5820 CHIP RES. 1/16W RMC1/16S 391JTH J24189020 RX-MAIN-26 DR-1X/XE Technical Supplement...
  • Page 95 RMC1/16S 474JTH J24189057 R 5894 CHIP RES. 100k 1/16W RMC1/16S 104JTH J24189049 R 5896 CHIP RES. 1/16W 0.5% RR0510R-473-D J24189159 R 5897 CHIP RES. 1/16W 0.5% RR0510R-473-D J24189159 R 5898 CHIP RES. 2.2k 1/16W RMC1/16S 222JTH J24189029 RX-MAIN-27 DR-1X/XE Technical Supplement...
  • Page 96 TTS14VSB-A3 15.60MHZ H9501310 X 5502 VCTCXO 15.6MHz TTS14VSB-A3 15.60MHZ H9501310 X 5502 VCTCXO 15.6MHz TTS14VSE-A3 15.60M H9501460 X 5503 XTAL VT-200 32.768KHZ 20PPM/6PF H0103267 X 5504 XTAL U4B 12.288MHz 12.288MHZ H0103411 XF5001 XTAL FILTER 47R15A9 47.250MHZ H1102400 RX-MAIN-28 DR-1X/XE Technical Supplement...
  • Page 97 RX-MAIN Unit Parts List DESCRIPTION VALUE TOL. MFR'S DESIG YAESU P/N VERS. LOT SIDE LAY ADR XF5002 XTAL FILTER 47R15A9 47.250MHZ H1102400 XF5003 XTAL FILTER MFT44R 44.85MHZ H1102443 GASKET (6612) RA1058400 GASKET (10x15) RA1262000 SPACER (5X5) RA1564100 RX-MAIN-29 DR-1X/XE Technical Supplement...
  • Page 101 R 6004 CHIP RES. 1/16W RMC1/16 681JATP J24185681 R 6004 CHIP RES. 1/16W RMC1/16 681JATP J24185681 INTERNAL PS 6- R 6004 CHIP RES. 1/16W RMC1/16 681JATP J24185681 W/O CE R 6005 CHIP RES. 1/16W RMC1/16 000JATP J24185000 RELAY-4 DR-1X/XE Technical Supplement...
  • Page 102 R 6058 CHIP RES. 1/16W RMC1/16 000JATP J24185000 EXTERNAL PS 6- R 6058 CHIP RES. 1/16W RMC1/16 000JATP J24185000 W/ CE RL6001 RELAY DC12V ACP131 DC12V M1190152 S 6001 SLIDE SWITCH SSSS912N-2A-OR N6090094 TH6001 THERMISTOR NCP15WL473J03RC G9090175 RELAY-5 DR-1X/XE Technical Supplement...
  • Page 103 CS2270101 J 7001 CONNECTOR B3B-ZR(LF)(SN) P0090648 R 7002 CHIP RES. 1/16W RMC1/16 000JATP J24185000 R 7003 CHIP RES. 1/16W RMC1/16 000JATP J24185000 R 7004 CHIP RES. 1/16W RMC1/16 000JATP J24185000 VR7001 POT. RH96N289 B103 RY-7950 J60800289 VR-1 DR-1X/XE Technical Supplement...

  • Page 106: Filter Unit

    K22108802 C 8073 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 8074 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 8075 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 8076 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 C 8077 CHIP CAP. 0.1uF GRM155B11A104KA01D K22108802 FILTER-4 DR-1X/XE Technical Supplement...
  • Page 107 1/16W RMC1/16S 101JTH J24189013 R 8023 CHIP RES. 1/16W RMC1/16S 101JTH J24189013 R 8024 CHIP RES. 1/16W RMC1/16S 331JTH J24189019 R 8025 CHIP RES. 1/16W RMC1/16S 221JTH J24189017 R 8026 CHIP RES. 1/16W RMC1/16S 221JTH J24189017 FILTER-5 DR-1X/XE Technical Supplement...
  • Page 108 RMC1/16S 473JTH J24189045 R 8064 CHIP RES. 1/16W RMC1/16S 473JTH J24189045 R 8065 CHIP RES. 1/16W RMC1/16S JPTH J24189070 R 8066 CHIP RES. 1/16W RMC1/16S JPTH J24189070 X 8001 XTAL TSS-3225A 36.864MHz 36.864MHZ H0103395 SHEET (40X25) RA1563700 FILTER-6 DR-1X/XE Technical Supplement...
  • Page 111 Q 9009 TAR5S33U(TE85L.F) G1094549 Q 9009 TPS62172DSGR G1095062 Q 9010 TRANSISTOR UMW1 TR G3070078 Q 9012 TPCF8105 G3070456 R 9004 CHIP RES. 4.7k 1/16W RMC1/16S 472JTH J24189033 R 9005 CHIP RES. 6.8k 1/16W RMC1/16S 682JTH J24189035 DSP-4 DR-1X/XE Technical Supplement...
  • Page 112 R 9100 CHIP RES. 1/16W RMC1/16S 2R2JTH J24189602 R 9101 CHIP RES. 100k 1/16W RMC1/16SK104FTH J24189529 R 9102 CHIP RES. 1/16W RMC1/16S JPTH J24189070 SC9001 SHIELD CASE (DSP) RA1357400 X 9001 TCXO 18.432MHz TTS18NSE-A11 18.432M H9501220 DSP-5 DR-1X/XE Technical Supplement...
  • Page 113 Copyright 2014 YAESU MUSEN CO., LTD. YAESU MUSEN CO., LTD. All rights reserved Tennozu Parkside Building 2-5-8 Higashi-Shinagawa, Shinagawa-ku, Tokyo 140-0002 Japan No portion of this manual YAESU USA may be reproduced without 6125 Phyllis Drive, Cypress, CA 90630, U.S.A.

This manual is also suitable for:

Dr-1xe

Table of Contents