Prince Castle DCFT-MINI-MCD Series Operation Manual
  1. Manuals
  2. Brands
  3. Prince Castle Manuals
  4. Toaster
  5. DCFT-MINI-MCD Series
  6. Operation manual

Prince Castle DCFT-MINI-MCD Series Operation Manual

Vertical artisan toaster
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
Operations
Operations
Manual
Manual
Heel and Crown
Bun In-Feed
Power Switch
Compression
Adjustment
Display
Out Feed
LIMITED WARRANTY
This product is warranted to be free from defects in material and/or work-
manship for a period of two (2) years from date of original installation, not
to exceed 30 months from date of shipment from our factory. Any part or
component which proves to be faulty in material and/or workmanship within
the warranty period will be replaced or repaired (at the option of Prince
Castle, Inc.) without cost to the customer for parts or labor.
This warranty is subject to the following exceptions/conditions:
• Use of any non-genuine Prince Castle parts voids this warranty and all
work must be performed by an authorized Prince Castle Service Agent.
• All labor shall be performed during regular work hours. Overtime premium
will not be covered.
• Travel charges are limited to 200 kilometers (100 miles) round trip, 2
hours travel time, one trip per repair.
• Damage caused by carelessness, neglect, and/or abuse (e.g., using
wrong current, dropping, tampering with or altering electrical components,
or improper cleaning) is not covered.
• Equipment damaged in shipment, by fire, flood or an act of God is not
covered.
• Damage to non-stick coated surfaces is not covered by this warranty.
DCFT-MINI-MCD Series

Product Identification

WARNING! Before first use of this equipment, read these instructions!
355 East Kehoe Blvd. • Carol Stream, IL 60188 USA
Telephone: 630-462-8800 • Toll Free: 1-800-PCASTLE
Fax: 630-462-1460 • www.princecastle.com
LCD Display
LEFT and RIGHT
Scroll Buttons
MENU
Button
Product Identification.........................................Page 1
Warranty Statement...........................................Page 1
Table of Contents..............................................Page 1
Electrical Specifications......................................Page 2
Safe Service Practices.......................................Page 2
Serial Number Matrix.........................................Page 2
Installation.......................................................Page 3
Powering Up Unit..............................................Page 4
Toasting Buns....................................................Page 4
Cleaning...........................................................Page 5
Management Programming.................................Page 7
Troubleshooting..................................................Page 9
Parts List..........................................................Page 10
Additional Information..........................................Page 12
1
Vertical Artisan Toaster
Vertical Artisan Toaster
DCFT-ART-MCD Series
DCFT-MINI-MCD SERIES

TABLE OF CONTENTS

Printed in USA 06/04/2019
OK Button
TEMPERATURE
Button
353-985 Rev. E

Advertisement

Table of Contents
loading

Related Manuals for Prince Castle DCFT-MINI-MCD Series

Summary of Contents for Prince Castle DCFT-MINI-MCD Series

  • Page 1: Table Of Contents

    Castle, Inc.) without cost to the customer for parts or labor. Serial Number Matrix…………………….…………….Page 2 This warranty is subject to the following exceptions/conditions: • Use of any non-genuine Prince Castle parts voids this warranty and all Installation……………….…………….……………..…Page 3 work must be performed by an authorized Prince Castle Service Agent.

  • Page 2: Electrical Specifications

    Vertical Artisan Toaster DCFT-MINI-MCD Series Safety Information Electrical Specifications 200-240V, 50/60Hz, 1250-1800W WARNING Single Phase Power Indicates information important to the proper operation of the unit. Failure to observe may result in damage to the equipment Important and/or severe bodily injury or death.

  • Page 3: Installation

    WARNING • Contact your local dealer, or if purchased directly, the Prince Castle Sales Department at 1-800-722-7853 or All electrical connections must be in accordance with local 630-462-8800 to arrange for a replacement unit. electrical codes and any other applicable codes.

  • Page 4: Powering Up Unit

    Vertical Artisan Toaster DCFT-MINI-MCD Series Toasting Buns Power Up Unit Plug in unit as shown in Figure 3. Feed product into top of Artisan Toaster. Heels are toasted in the front slot and crowns are toasted in the rear slot. The sides to be toasted should face the platen (Black Teflon sheet).

  • Page 5: Cleaning

    Vertical Artisan Toaster DCFT-MINI-MCD Series Cleaning (Daily) Ensure the unit is powered off before initiating any cleaning Spray a clean, sanitizer-soaked towel with approved sink procedures. Allow unit to cool for at least 20 minutes before detergent solution then wipe down release sheets on both attempting to clean.
  • Page 6 Vertical Artisan Toaster DCFT-MINI-MCD Series Cleaning (Cont..) Wipe out crumbs from landing zone with a clean, sanitizer- Clean front and rear conveyor and club belts. soaked towel. • With power off, remove gloves from hands to lift lid and open front conveyor door.

  • Page 7: Management Programming

    Vertical Artisan Toaster DCFT-MINI-MCD Series Management Programming To Adjust PLATEN To Enter Programming screens TEMPERATURE from the Press and hold the MENU SELECT LANUGAGE Screen, button for 6 seconds. The PROGRAMMING VERSION press the RIGHT scroll button. screen will appear in the LCD Press the OK button to enter the display.
  • Page 8 Vertical Artisan Toaster DCFT-MINI-MCD Series Management Programming (Continued) To adjust set TOAST TIME To enter SERVICE CODES from from the SELECT F/C LON SERVICE CALL screen, screen, press the RIGHT press the RIGHT scroll button. scroll button From the SERVICE CODES...

  • Page 9: Troubleshooting

    Vertical Artisan Toaster DCFT-MINI-MCD Series Troubleshooting Steps WARNING BURN/ELECTRICAL SHOCK HAZARD! Platen is HOT and can cause severe burns or severe shock. Keep hands and objects out of the toaster unit! Failure to exercise caution may result in serious injury! Turn the unit off, unplug it and let it cool down completely before touching or working on internal apparatus.

  • Page 10: Parts List

    Vertical Artisan Toaster DCFT-MINI-MCD Series Parts List Exploded View Diagram See Page 11 for Parts List MINI-DCFT-MCD Series Printed in USA 06/04/2019 353-985 Rev. E...
  • Page 11 Vertical Artisan Toaster DCFT-MINI-MCD Series Parts List ITEM NO. PART NUMBER DESCRIPTION 353-856S PCB A, USER INTERFACE 526-281S TSTAT,HI-LIMIT BULB & CAP,700F 353-262MS PCB ASSEMBLY, MAIN CONTROLLER 526-013S ASSY,RTD TEMPERATURE INTERFACE 353-807S 3 HEATER DRIVE PCB ASSEMBLY 37146S POWER SUPPLY...

  • Page 12: Additional Information

    Vertical Artisan Toaster DCFT-MINI-MCD Series Additional Information European Distributors and Service Correct Disposal of this Product Catequip 19, Rue de la Paix This marking indicates that this product should not be 10320 Bouilly disposed with other household wastes throughout the France EU.

Table of Contents