Page 1
Important: Retain these instructions for future use. For any queries or assistance call Customer Service (Australia Only) Charmate® is a registered trademark of 1300 174 876 Sitro Group Australia Pty Ltd www.gasmate.com.au Hours of operation: Monday to Friday 8am - 5pm EST Aber, N.Z.
IMPORTANT SAFETY WARNINGS READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING AND OPERATING YOUR GRILL. • Never use charcoal that has been pre treated with WARNING lighter fluid. Use only a high grade plain charcoal or charcoal/wood mixture. • Only use this barbecue on a hard, level, non- •...
Page 3
• Never leave coals and ashes in barbecue CAUTION unattended. Before barbecue can be left unattended, remaining coals and ashes must • This grill is for use with charcoal only. be removed from barbecue. Use caution to • Never attempt to attach this grill to the self- protect yourself and property.
TABLE OF CONTENTS Rust can appear on the inside of your grill. Maintaining a light coat of vegetable oil on the Section Page interior surfaces will aid in the protection of Important Safety Information your grill. Exterior surfaces of the grill may need occasional touch up.
Maintenance: COOKING TIPS Do not do a burn-off after you grill, but rather Building Your Fire leave the cooking residues on the grates to keep a Stack charcoal briquettes or wood into a protective coating on the cast iron. Do a burn-off pyramid-shaped pile on top of the just before you grill.
Page 6
Know When Your Fire is Ready DIRECT AND INDIRECT GRILLING Successful charcoal grilling depends on a good fire. Direct Grilling: The general rule for knowing when your coals are For most grilling, the ignited coals are spread in ready for grilling is to make sure that 80 percent a single layer under the food.
Page 7
Grilling with Wood Chips/Wood Chunks For a more robust smoke flavor while using charcoal briquettes or lump charcoal, try adding wood chips or several wood chunks to the fire. Wood chunks are available in a variety of natural flavors, and can be used alone or in addition to charcoal.
PARTS LIST Part Description Part No. Image Part Description Part No. Image Bottom Shelf Smoke Stack Firebox Leg (LF) Bottom Leg (LB) Firebox Lid Leg (RF) Air Vent Firebox Lid Leg (RB) Cover Triangular Limiting Film Connector Triangular Charcoal Grate 1 Bracket Cooking Grate Axle...
STEP 1 Assemble the bottom shelf (1) to the legs (2, 3, 4 & 5), then assemble each two legs together, as shown in IMAGE 1. STEP 2 Assemble the triangular bracket (7) to the left legs (2, 3) using BOLT M6 (A) - 2pcs. Assemble triangular connector (6) to the right legs (4, 5) using BOLT M6 (A) - 4pcs.
Page 11
STEP 4 Assemble the bottom of the body bottom (10) to the legs with Bolts M6 (A) - 4pcs. Attach the body bottom to the triangular connector (6) with Bolts M6 (A) -1pc and NUT M6 FLANGE LOCK (E) - 1pc. STEP 5 Assemble lid (11) to the body bottom with Bolts M6 (D) - 2pcs.
Page 12
STEP 7 Assemble the firebox lid (16) and the firebox bottom (15) together with Bolts M5*10 (C) - 4pcs. IMAGE 5 STEP 8 Assemble the firebox lid cover (18) to the firebox lid with Bolts M4 (B) - 4pcs and SPACERS (H) - 2pcs. Attach the limiting film (19) to the firebox lid with Bolt M6 (A) - 1pc and NUT M6 FLANGE LOCK (E) - 1pc.
Page 13
STEP 10 Attach the firebox to the body with Bolts M6 (A) - 6pcs and attach to the triangular bracket (7) with BOLTS M6 (A) - 1pc as shown in IMAGE 6. Then tighten all screws. STEP 11 Place Charcoal Grate (20) into the Firebox Bottom (15).
Control heat with amount and type of FUEL, GRILL PREPARATION AND OPERATING INSTRUCTIONS DUAL DAMPERS and ADJUSTABLE FIRE GRATE. Read all safety warnings and instructions carefully Adjust GRATE one end at a time. Wood burns before assembling and operating your grill. hotter than coals.
BBQ RANGE - LIMITED WARRANTY SITRO GROUP AUSTRALIA (S.G.A.) warrants the purchaser of this Barbecue against defects in workmanship and material, for a period of 12 months from the date of purchase. Barbecues are warranted for 12 months for domestic use only. Commercial use will void warranty. Warranty and purchase receipt of this product are to be retained as proof of purchase and must be presented if making a claim under the terms of the S.G.A.