Table of Contents
Advertisement
Operation
Manual
LIMITED WARRANTY
This product is warranted to be free from defects in material and /or
workmanship for a period of 1 year from date of original installation, not to
exceed 18 months from the date of manufacture.
Any component which proves to be faulty in material and/or workmanship
will be replaced or repaired (at the option of Prince Castle, Inc.) without
cost to the customer for parts and labor. This warranty covers on location
service (i.e. trip charges and or mileage). Travel mileage is limited to
100 miles (200 Kilometers) round trip (one trip warranty) from an
authorized service agency or its sub-service agency.
This warranty is subject to the following exceptions/conditions:
• Use of any non-genuine Prince Castle parts voids this warranty.
• All labor to be performed during regular work hours. Overtime premium
(the incremental amount) will be charged to the customer.
• Damage caused by carelessness, neglect and/or abuse (e.g., dropping,
tampering or altering parts, equipment damaged in shipment, by fire,
flood or an act of God) is not covered under this warranty.
• All problems due to operation at voltages other than that specified on
equipment nameplates are not covered by this warranty. Conversion to
correct voltage is the customer's responsibility.
• This equipment must be serviced by Prince Castle Authorized Service
Agency or a Prince Castle Service Technician during the warranty
period.
541-520revD-EN
355 East Kehoe Blvd. • Carol Stream, IL 60188 USA
Telephone: 630-462-8800 • Toll Free: 1-800-PCASTLE
Fax: 630-462-1460 • www.princecastle.com
DHB-BK Series
TABLE OF CONTENTS
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Product Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Setting the Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Calibrating Heaters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Selecting Breakfast and Regular Menus . . . . . . . . . . . . . . . . . . . . . . .
Programming the Menus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Changing the Hold and Cook-More Times . . . . . . . . . . . . . . . . . . . . .
Changing Product Names . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
®
CastleNet
Communications Network . . . . . . . . . . . . . . . . . . . . . . . .
Factory Presets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exploded View and Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Product Holding Bin
(with Prince Castle Button Bar)
Printed in USA 1/06 © 2006
2
2
2
3
3
5
5
6
7
7
8
9
10
11
12
12
13
Advertisement
Table of Contents
Related Manuals for Prince Castle DHB-BK Series
Summary of Contents for Prince Castle DHB-BK Series
-
Page 1: Table Of Contents
Any component which proves to be faulty in material and/or workmanship will be replaced or repaired (at the option of Prince Castle, Inc.) without Installation .......... -
Page 2: Safety Information
REG (Regular Menu) LED Important Prince Castle reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Printed in USA 1/06 © 2006... -
Page 3: Installation
• contact your local dealer, or if purchased directly, the Prince Castle If the unit is to be networked with other Prince Castle units, refer to the Sales Department at 800-722-7853 or 1-630-462-8800 to arrange for a ®... - Page 4 Product Holding Bin DHB-BK Series Operation (continued) When any of the timer LEDs flash, cook more product or remove Product, along with any remaining time, can be transferred from and discard product as indicated. one cavity to another as follows: A.
-
Page 5: Cleaning
Product Holding Bin DHB-BK Series Operation (continued) Cleaning To shut down the unit, turn the power On/Off switch (A) to OFF. WARNING Before performing any maintenance, turn the power switch to the OFF position and unplug the power cord from the electrical receptacle. -
Page 6: Calibrating Heaters
Product Holding Bin DHB-BK Series Setting the Temperature (continued) Press the UP or DOWN Arrow button until the desired shelf Press and hold the SETPOINT button and the BURGER KING LED and upper (U) or lower (L) heater is selected. -
Page 7: Selecting Breakfast And Regular Menus
Product Holding Bin DHB-BK Series Selecting Breakfast and Regular Menus There are six menus available: When the desired menu is displayed, release the DAYPART/ ENTER button. The food products for the menu will be BKFT LED ON = Breakfast1 or Breakfast2 displayed in the upper and lower PAN displays. -
Page 8: Changing The Hold And Cook-More Times
Product Holding Bin DHB-BK Series Changing the Hold and Cook-More Times The SET PRODUCT TIME menu is used to change the Hold and Cook-More times. Press and hold the BURGER KING LOGO button, then immediately press and hold the DAYPART/ENTER button until the display shows one of four programming menus. -
Page 9: Changing Product Names
Product Holding Bin DHB-BK Series Changing Product Names The EDIT PRODUCT NAME menu is used to change a default product name to one of your own choosing. Press and hold the BURGER KING LOGO button, then immediately press and hold the DAYPART/ENTER button until the display shows one of four programming menus. - Page 10 Communications Network Telephone jack plugs are located on the back of the unit. The Prince Castle DHB-BK1PC, DHB-BK3PC Bins, Retro Bun Timer Connect the units using the cables provided as shown here. and New Bun Cabinet Timers can be inter-connected to form the ®...
-
Page 11: Factory Presets
Product Holding Bin DHB-BK Series Factory Presets Product Menu Details Product Display Name Hold Minutes Cook-More Minutes Eggs EGGS Biscuits BISC Sausage SAUS French Toast FR-T Fish FISH Chicken Crisp CRSP Chick Patty CHKN Chicken Tenders TEND Burgers BURG Whoppers... -
Page 12: Troubleshooting
Product Holding Bin DHB-BK Series Troubleshooting PROBLEM PROBABLE CAUSE SOLUTION Display flashes Open relay. Circuit inoperable. Replace power circuit board. Display flashes Shorted relay. Circuit inoperable. Replace power circuit board. Open heater. Test heater resistance (150.2 Ohms). Replace heater if necessary. -
Page 13: Exploded View And Parts List
Product Holding Bin DHB-BK Series Exploded View and Parts List Ref. Part No. Description Ref. Part No. Description 541-316 Side Panel Cover 541-329 Top Cover 541-735S Main P.C. Board Kit 541-324 Header 541-799 P.C. Board Bracket 541-650 Trim 541-317 Insulation... - Page 14 355 East Kehoe Blvd. • Carol Stream, IL 60188 USA Telephone: 630-462-8800 • Fax: 630-462-1460 Printed in USA 1/06 © 2006 Toll Free: 1-800-PCASTLE Prince Castle Inc. www.princecastle.com...