Typical Tenders: 4 To 14 Inches - KSB S 100D Booklet

Typical Tender for S 100D
No. Q Quan-
tity i
Submersible borehole pump(s) type S 100D
for well diameters of 100 mm (4 inches) and above
Make:
Pump + motor: S 100D - -
Multistage centrifugal pump for vertical / angled / horizontal
grated, anti-blockage check valve with double-guided valve disc. Plain bearing
lubricated by the fluid pumped and protected against ingress of sand. Discharge
nozzle with threaded end.
Submersible canned motor for 1-phase a.c. current (including starter with ther-
mal overcurrent relay) / three-phase current
expansion diaphragm for pressure equalization and cable kit / 1.5 / 2.5
power supply cable.
Fluid pumped:
Outer pump casing, suction casing and
check valve housing
Stage casing (diffuser)
Impellers
Shaft (pump)
Bearing (pump)
Motor (shaft and housing)
Capacity
Head . . . . . . . . . . . . . . . . . . .
Temperature (fluid handled) t =
Rated power (motor)
Speed / Frequency
Voltage / Starting
Pump end
Outside diameter
Pump set length / weight
Adapter from G 1''
Adapter from threaded end G
Pair of supporting and installation clamps for risers
1
R1'' / (DN 32) / R2'' (DN 50)
4
Cooling shroud with suction strainer and pedestals for horizontal
installation.
Power supply cable
Cable connector, separable / non-separable
motor supply cable not connected and sealed/connected and sealed
factory.
Cable tie
UPA CONTROL box for 1
relay with phase failure protection, temperature-compensated, insulating en-
closure, with 3 electrodes and integrated "Dry running protection" / "Water level
control" selector switch.
Motor contactor for 1
insulating enclosure.
Dry running protection equipment:
-- for semi-automatic operation with 2
-- for fully automatic operation with 3
control current lines with a length of
Lightning protection with earthing terminal for 1
Automatic control unit Controlmatic E / Cervomatic EDP
1)
Delete as applicable
KSB
. . . . . .
clean or slightly contaminated water with a permissible sand
content of up to 50 g/m
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . Q =
H =
. . . . . . P
N =
. . . . . . . n
≈
. . . . . . . . . U =
. . . . . . . . . . . . . . . G
. . . . . . . . . D =
max
. . L
≈
A
1 1
/ to R 1'' / .
4 2
1)
.
x mm
/ 230 V and 3
µ
/ 230 V with ON/OFF switch for automatic operation,
µ
50 Hz
Item
/ . . . . . + . . . . . . . . . . . . . .
1)
installation. Inte-
1)
, with self--aligning thrust bearing,
3
!
CrNi steel
glass fibre reinforced NORYL
glass fibre reinforced NORYL
Chrome steel
Rubber
CrNi steel
3
m /h /
rpm / f =
V / d.o.l.
1
1'' / (DN 32) / 2'' (DN 50)
4
mm / G
≈
A
to flanged end DN
2 1)
, separate/connected , length
1)
, with sealing compound,
/ 400 V with thermal overcurrent
µ
1)
1)
m each.
230 V / 3
µ µ
1)
Submersible Borehole Pumps
Unit price p
E Euro
kW
1)
m
l/s
m
o
C
kW
Hz
1)
mm
kg
.
m.
1)
at the
1)
400 V .
.
Sum total
Amount
Euro E
91