Philips 32PFL3007H/12 Service Manual

Philips 32PFL3007H/12 Service Manual

Colour television tpm9.1e chassis
Hide thumbs Also See for 32PFL3007H/12:
Table of Contents

Advertisement

Colour Television
Contents
6. Alignments
3000 32"
3000 37"
3000 42"
3000 47"
Published by XjL/MjX/SC 1264 BG TV Quality
©
2012
TP Vision Netherlands B.V.
All rights reserved. Specifications are subject to change without notice. Trademarks are the
property of Koninklijke Philips Electronics N.V. or their respective owners.
TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust
earlier supplies accordingly.
PHILIPS and the PHILIPS' Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Page
2
2
6
10
24
26
33
43
44
45
46
47
Drawing PWB
48
64-65
82-83
84
85
86
87
88
89
90
91
Printed in the Netherlands
Chassis
TPM9.1E
Subject to modification
EN 3122 785 19231
LA

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 32PFL3007H/12 and is the answer not in the manual?

Questions and answers

Summary of Contents for Philips 32PFL3007H/12

  • Page 1 Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
  • Page 2: Table Of Contents

    Notes: • Figures can deviate due to the different set executions. • Specifications are indicative (subject to change). Table 2-1 Described Model Numbers and Diversity Mechanics Block Diagrams Schematics 32PFL3007H/12 10.1 10.3 10.4 11.1 32PFL3007H/60 10.1 10.3 10.4 11.1 32PFL3007K/02 10.2...
  • Page 3 Technical Specs, Diversity, and Connections TPM9.1E LA EN 3 Connections Rear Connectors Side Connectors TV ANTENNA SERV .U SCART (RGB/CVBS) AUDIO IN USB2 DVI/VGA CVBS/Y USB1 NETWORK HDMI 2 HDMI1 DIGITAL AUDIO OUT HDMI 19240_001_120217.eps 120217 Figure 2-1 Connection overview (xxPFL30x7H/T) Rear Connectors Side Connectors SCART...
  • Page 4 EN 4 TPM9.1E LA Technical Specs, Diversity, and Connections Note: The following connector colour abbreviations are used - Audio L 0.5 V / 1 k (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, - Ground Audio Gy= Grey, Rd= Red, Wh= White, Ye= Yellow. - Ground Blue - Audio L 0.5 V...
  • Page 5 Technical Specs, Diversity, and Connections TPM9.1E LA EN 5 12 - EXT2: Video YPbPr - In, Audio - In - D2+ Data channel Gn - Video - Y / 75 W - Shield Bu - Video - Pb 0.7 V / 75 W - D2- Data channel...
  • Page 6: Precautions, Notes, And Abbreviation List

    Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
  • Page 7 Precautions, Notes, and Abbreviation List TPM9.1E LA EN 7 result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
  • Page 8 6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
  • Page 9 SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
  • Page 10: Mechanical Instructions

    EN 10 TPM9.1E LA Mechanical Instructions 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly Cable Dressing 19230_100_120301.eps 120309...
  • Page 11 Mechanical Instructions TPM9.1E LA EN 11 19230_101_120301.eps 120309 Figure 4-2 Cable dressing (37" DVB T/C/S2) 19230_102_120301.eps 120309 Figure 4-3 Cable dressing (42" DVB T/C/S2) back to 2012-Apr-27 div. table...
  • Page 12 EN 12 TPM9.1E LA Mechanical Instructions 19230_103_120301.eps 120312 Figure 4-4 Cable dressing (47" DVB T/C) Service Positions For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop tools.
  • Page 13 Mechanical Instructions TPM9.1E LA EN 13 3 × 16 3 × 7.5 M3 × 8 M4 × 10 19230_104_120301.eps 120316 Figure 4-5 Rear cover removal 4.3.2 Stand Refer to Figure 4-5 for details. 1. Remove fixation screws [4] that secure the base assembly, pull the base assembly downwards away from the catches.
  • Page 14 EN 14 TPM9.1E LA Mechanical Instructions 4.3.6 Keyboard Control unit 1. Gently release the tape that holds the board’s cable. 2. Gently push inwards the three clips at the PSU side of the unit. Release the unit at the PSU side and turn it away from the PSU.
  • Page 15: Service Modes, Error Codes, And Fault Finding

    Service Modes, Error Codes, and Fault Finding TPM9.1E LA EN 15 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: Life Timer 5.1 Test Points During the life time cycle of the TV set, a timer is kept (called 5.2 Service Modes “Op.
  • Page 16 EN 16 TPM9.1E LA Service Modes, Error Codes, and Fault Finding – Automatic user menu time-out (menu switches controls will not have I+ button, but an “INFO” button back/OFF automatically. instead. – Auto Volume levelling (AVL). How to Exit SDM How to Activate SDM •...
  • Page 17 Service Modes, Error Codes, and Fault Finding TPM9.1E LA EN 17 Main Menu Sub-menu 1 Sub-menu 2 Description Download from USB Copy Channel List from USB To download several settings from the USB stick to the TV Copy NVM from USB Copy Readable Info from USB Copy EDID from USB Initialize NVM...
  • Page 18 EN 18 TPM9.1E LA Service Modes, Error Codes, and Fault Finding Default value Item Itemvakue 32" 37" 42" 47" Description NVM COPY USB to TV Press OK Use this to store the NVM data from the USB memory stick to the TV. The TV will save the two files which were created in item 8 to the NVM of the set.
  • Page 19 Service Modes, Error Codes, and Fault Finding TPM9.1E LA EN 19 • 1.3 Installation date Indicates the date of the first • 3.1 Signal Quality Analog/digital signal strength. installation of the TV. This date is acquired via time • 3.2 Child lock Not active / active. This is a combined item extraction.
  • Page 20 A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
  • Page 21: Error Codes

    Service Modes, Error Codes, and Fault Finding TPM9.1E LA EN 21 • FUS_clustername_version.zip: Contains the “autorun.upg” which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair. 5.5.7 How to Copy NVM Data to/from USB When copying data to and from a USB memory stick, the folder...
  • Page 22: The Blinking Led Procedure

    EN 22 TPM9.1E LA Service Modes, Error Codes, and Fault Finding – ERROR: 034 013 000 000 000: Error code 13 was • It is assumed that the components are mounted correctly detected first and error code 34 is the last detected with correct values and no bad solder joints.
  • Page 23 Service Modes, Error Codes, and Fault Finding TPM9.1E LA EN 23 5.8.10 Display option code Attention: In case the SSB is replaced, always check the Panel Code in CSM, even when picture is available. Performance with the incorrect display option code can lead to unwanted side-effects for certain conditions.
  • Page 24: Alignments

    EN 24 TPM9.1E LA Alignments 6. Alignments Index of this chapter: In case you have a colour analyser: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyser (e.g. Minolta CA-210) in the centre of the screen. 6.3 Software Alignments Consequently, the measurement needs to be done in a 6.4 Option Settings...
  • Page 25: Option Settings

    Alignments TPM9.1E LA EN 25 Option Settings 6.5.1 SSB Indentification 6.4.1 Introduction SSB’s of this chassis are identified by a “715” code on the SSB. 715Axxxx-Nnn-MMM-OOOO • 715 main category, Printed Wiring Board The microprocessor communicates with a large number of I •...
  • Page 26: Circuit Descriptions

    EN 26 TPM9.1E LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPM9.1E LA platform makes use of two different SSBs. 7.2 Power Supply They both use the MT5366, as main processor. It combines a 7.3 DC/DC Converters transport de-multiplexer, a high definition video decoder, an 7.4 Front-End Analogue and DVB-T, DVB-C;...
  • Page 27 Circuit Descriptions TPM9.1E LA EN 27 7.1.3 SSB Cell Layout xxPFL30x7H/T DC/DC COMMON INTERFACE MT5366 TUNER SCART AUDIO AMP SERVICE CONNECTOR Headphone ANALOG I/O NETWORK HDMI SWITCH HDMI 19240_200_120224.eps 120224 Figure 7-1 xxPFL30x7H/T SSB layout cells (top view) back to 2012-Apr-27 div.
  • Page 28 EN 28 TPM9.1E LA Circuit Descriptions 7.1.4 SSB Cell Layout xxPFL30x7K COMMON INTERFACE DC/DC MT5366 TUNER NETWORK SCART Headphone TUNER ANALOG I/O SERVICE CONNECTOR HDMI SWITCH AUDIO AMP HDMI 19240_201_120224.eps 120224 Figure 7-2 xxPFL30x7K SSB layout cells (top view) back to 2012-Apr-27 div.
  • Page 29 This part is available in the regular market. PSL stands for Power Supply with integrated LED-drivers. Consult the Philips Service web portal for the order codes of the PSLS stands for a Power Supply with integrated LED-drivers boards.
  • Page 30 EN 30 TPM9.1E LA Circuit Descriptions Connector 3xPFL35x7 4xPFL35x7 CN801 CN802 CN8503 CN9901 Descr. to panel to panel to panel Mains inlet DC/DC Converters The on-board DC/DC converters deliver the following voltages (depending on set execution): • +5V2-STANDBY, permanent voltage for the Stand-by controller, LED/IR receiver and controls;...
  • Page 31 Circuit Descriptions TPM9.1E LA EN 31 19240_206_120224.eps 120224 Figure 7-7 Front-End DVB-T2 DTV block diagram 19240_208_120224.eps Front-End DVB-S(2) reception 120224 The Front-End for the DVB-S(2) application consist of the following key components: Figure 7-9 HDMI input configuration • AVL6211LA The hardware default I C addresses are: •...
  • Page 32 EN 32 TPM9.1E LA Circuit Descriptions Back-End The back-end of this chassis is integrated in the main processor and is connected via LVDS to the 50 Hz CCFL back lit LCD panel. Refer to section 7.2.2 Diversity for an in-depth explanation of the different power boards that are used.
  • Page 33: Ic Data Sheets

    IC Data Sheets TPM9.1E LA EN 33 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
  • Page 34 EN 34 TPM9.1E LA IC Data Sheets Pinning information MT5366CV [1/2] 19080_301_110316.eps 120102 Figure 8-2 Pin configuration [1/2] back to 2012-Apr-27 div. table...
  • Page 35 IC Data Sheets TPM9.1E LA EN 35 Pinning information MT5366CV [2/2] 19080_302_110316.eps 120102 Figure 8-3 Pin configuration [2/2] back to 2012-Apr-27 div. table...
  • Page 36: Block Diagram

    EN 36 TPM9.1E LA IC Data Sheets Diagram 10-1-6 Speaker B06, STA381BWTR (IC U602) Block diagram STA381BW OUT 1A OUT 1B 2.1 Channel Half MCLK OUT 2A Audio Processor Bridges OUT 2B Modulator STAudioFx FFX3A LRCKI STSpeakerSafe FFX3B Parametric EQ BICKI Binary Volume...
  • Page 37 IC Data Sheets TPM9.1E LA EN 37 Diagram 10-1-13 HDMI Switch & Connector B13, TMDS361BPAGR (IC U500) Block diagram Dx+_1 TMDS361B TMDS Rx w/ AEQ Dx–_1 CLK+_1 TMDS Rx CLK–_1 Clock Detect VSadj SCL1 Dx+_SINK TMDS Tx Dx–_SINK SDA1 CLK+_SINK TMDS Tx CLK–_SINK Dx+_3...
  • Page 38 EN 38 TPM9.1E LA IC Data Sheets Diagram 10-1-14 DVB T/C Demodulator MT5135 B14, MT5135AE/A LQFP-128 (IC U103) Block diagram Other demodulators PCMCIA interface interface MT5135AE RSSI PVR playback TS RSSI ADC PVR recording TS CI+ controller RF AGC Demod TS Demod TS DVB-C output...
  • Page 39 IC Data Sheets TPM9.1E LA EN 39 Diagram 10-1-15 DVB-T/C/T2 Tuner B15, AVL6211LA (IC U104) Block diagram Carrier PL Frame Phase Processor Recovery DVB FEC Viterbi/RS RFAGC Decoder MPEG TS ADC_I Dual Output Digital Front-end TS Output 10 - Bit Equalizer Down Converter Interface...
  • Page 40 EN 40 TPM9.1E LA IC Data Sheets Diagram 10-1-15 DVB-T/C/T2 Tuner B12, RTL8201EL-VC-GR (IC U4010) Block diagram RTL8201FL Pinning information RTL8201FL 19240_302_120221.eps 120221 Figure 8-8 Internal block diagram and pin configuration back to 2012-Apr-27 div. table...
  • Page 41 IC Data Sheets TPM9.1E LA EN 41 Diagram 10-2-2 System Power 2 B02, LNBH23QTR (IC U751) Block diagram ISEL ISEL ADDR ADDR SDA SCL SDA SCL Vcc- Vcc- Vcc- Preregulator Preregulator +U.V.lockout +U.V.lockout +P.ON reset +P.ON reset LNBH23 Rsense Rsense VSEL VSEL P-GND...
  • Page 42 EN 42 TPM9.1E LA IC Data Sheets Personal Notes: 10000_012_090121 back to 2012-Apr-27 div. table...
  • Page 43: Block Diagrams

    Block Diagrams TPM9.1E LA EN 43 9. Block Diagrams Wiring diagram 32" DVB T/C 3000 WIRING DIAGRAM 32" DVB T/C (3000) Board Level Repair Component Level Repair Only for authorized workshops to panel to panel to panel CN9002 CN4010 MAIN POWER SUPPLY (1054) (1053) USB2...
  • Page 44: Wiring Diagram 37" Dvb T/C/S2 3000

    Block Diagrams TPM9.1E LA EN 44 Wiring diagram 37" DVB T/C/S2 3000 WIRING DIAGRAM 37" DVB T/C/S2 (3000) Board Level Repair Component Level Repair Only for authorized workshops to panel to panel CN408 MAIN POWER SUPPLY (1054) (1053) SCART (RGB/CVBS) AUDIO IN DVI/VGA SERV.U...
  • Page 45: Wiring Diagram 42" Dvb T/C/S2 3000

    Block Diagrams TPM9.1E LA EN 45 Wiring diagram 42" DVB T/C/S2 3000 WIRING DIAGRAM 42" DVB T/C/S2 (3000) Board Level Repair Component Level Repair Only for authorized workshops CN408 MAIN POWER SUPPLY (1054) (1053) SCART (RGB/CVBS) AUDIO IN SERV.U DVI/VGA to panel to panel CN9901...
  • Page 46: Wiring Diagram 47" Dvb T/C 3000

    Block Diagrams TPM9.1E LA EN 46 Wiring diagram 47" DVB T/C 3000 WIRING DIAGRAM 47" DVB T/C (3000) Board Level Repair Component Level Repair Only for authorized workshops CN4010 MAIN POWER SUPPLY to panel (1053) (1054) to panel USB2 SERV .U SCART USB1 (RGB/CVBS)
  • Page 47: Block Diagram Dvb T/C

    Block Diagrams TPM9.1E LA EN 47 Block Diagram DVB T/C CI card slot (CAM) DDR3 1.33 GHz NAND Flash CI/CI+ 256 MByte 128 MByte × 2 DBV-T/C DEMUX DEMOD_TS Tuner I CI+ controller MT5366 SPDIF Out RF Tuner MT5135 UART (ISP & Factory alignment) MCU ARM11 MPEG/video/audio DIF +/-...
  • Page 48: Circuit Diagrams And Pwb Layouts

    Circuit Diagrams and PWB Layouts TPM9.1E LA EN 48 10. Circuit Diagrams and PWB Layouts 10.1 B 715G5155 DVB-T/C SSB 3000/3500 series 10-1-1 System Power 1 System Power 1 ANALOG POWER AVDD1V2 from AVDD3V3 PWR_ON/OFF PWR_ON/OFF 3 STANDBY POWER +5VSB from STB_PWR5V OPWRSB OPWRSB BRIGHT_ADJ...
  • Page 49 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 49 10-1-2 System Power 2 System Power 2 PANEL_VCC_ON/OFF PANEL_VCC_ON/OFF 13 TUNER POWER +5V_TUNER 2,4,5,6,7,8,9,10,11,12,13,14,15,16,17 PANEL_VCC PANEL POWER PANEL_VCC from +12V from +16V via 12V_TUN +5V_SW +12V PWR_ON/OFF PWR_ON/OFF 2 R7021 Q7004 NC/0R05 4A 1/4W R7026 R7030...
  • Page 50 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 50 10-1-3 Peripheral Peripheral DVDD3V3 MT5366 OSCL2 OSCL2 U4001A OSDA2 R4106 R4107 OSDA2 JTCK U0TX 4K7 1/10W 5% OSCL0 JTCK U0TX 4K7 1/10W 5% OSCL0 JTDI U0RX JTDI U0RX OSDA0 JTDO OSDA0 JTDO OSDA1 JTMS...
  • Page 51 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 51 10-1-4 Connector/USB/RS232 Connector & USB & RS232 3V3SB 3V3SB TO KEY PAD BOARD GPIO 21 LED_G: LIGHT_SENSOR_IN LIGHT_SENSOR_IN 13 Enable: High KEY _UP_DN_DCSW KEY _UP_DN_DCSW 13 KEY _MENU_L_R_SOURCE Disable(Stand_By): Low R4059 R4060 KEY _MENU_L_R_SOURCE 13 LED_R...
  • Page 52 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 52 10-1-5 Audio I/O & Headphone Audio I/O & Headphone HP_DET MT5366 HP_DET SPDIF_OUT SPDIF_OUT 8,14 U4001F SCART1_R_In Analog Power SCART1_R_In AR0O AE25 Y 23 SCART1_R_In 9 SCART1_L_In AIN0_R_AADC AR0_ADAC SCART1_L_In AB21 AA25 AL0O SCART1_L_In 9...
  • Page 53 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 53 10-1-6 Speaker Speaker AL0O AL0O AR0O AR0O OSDA1 OSDA1 OSCL1 OSCL1 AVDD OFF_MUTE OFF_MUTE FB6004 220R/2000mA AMP_MUTE AMP_MUTE AUD_VCC DVDD3V3 I2SAMP_RESET AVDD PWR_16V_24V DVDD3V3 I2SAMP_RESET 13 FB6005 AVDD_HP AOMCLK R6078 AOMCLK FB6009 FB6006 220R/2000mA...
  • Page 54 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 54 10-1-7 Video I/O & SPDIF Video I/O & SPDIF MT5366 U4001C TU_FAT_IN2- HSY NC AD17 Analog Power DVBT Only ADCINP_DEMOD HSY NC TU_FAT_IN2+ AE17 VSY NC ADCINN_DEMOD VSY NC AC10 5135_REFCLKM AVDD33_DEMOD AVDD1V2 AVDD3V3...
  • Page 55 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 55 10-1-8 Scart SCART SCART1R_PA SCART1R_PA 6 SCART1L_PA SCART1L_PA CVBS2P SCART (Full SCART) -- CVBS+SV+RGB+TV OUT CVBS2P SOY 0 SOY 0 Y 0P Y 0P COM0 COM0 PB0P PB0P PR0P PR0P SCART_FS0 SCART_FS0 TUNER_BY PASS_OUT TUNER_BY PASS_OUT 8...
  • Page 56 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 56 10-1-9 VGA Input VGA Input VGA Input VGA_UR_EN VGA_UR_EN U0TX U0TX 4,5,6 U0RX U0RX 4,5,6 OSCL0 OSCL0 4,14 OSDA0 OSDA0 4,14 VGA_R_In VGA_R_In VGA_L_In VGA_L_In HSY NC C1058 1.5nF 50V HSY NC +5V_SW VSY NC VSY NC...
  • Page 57 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 57 10-1-10 LVDS LVDS USB_PWR_EN0 USB_PWR_EN0 5,13 USB_OC_COM USB_OC_COM 5,13 USB_DP0 USB_DP0 USB_DM0 MT5366 USB_DM0 LVDS_CTRL LVDS_CTRL BRIGHT_ADJ BRIGHT_ADJ 2 INVERTER_ON_OFF INVERTER_ON_OFF 2 BL_DIMMING U4001D BL_DIMMING 13 BL_ON/OFF AVDD33_USB_2P AVDD33_LVDSTX BL_ON/OFF AVDD33_USB_2P AVDD33_LVDSA AVSS33_USB_2P AVDD33_LVDSA...
  • Page 58 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 58 10-1-11 DDR3 Interface DDR3 Interface DDR3#1 DDR3#2 MT5366 U4002 U4003 Damping and Termination for CLK U4001B RDQ0 B_A0 RDQ16 A_A0 DQL0 DQL0 RDQ0 1_A0 RDQ1 B_A1 RDQ17 A_A1 RDQ6//RDQ0 RCAS_//RA0 DQL1 DQL1 RDQ1 1_A1...
  • Page 59 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 59 10-1-12 GPIO & RJ45 GPIO & RJ45 KEY _UP_DN_DCSW KEY _UP_DN_DCSW 5 KEY _MENU_L_R_SOURCE DVBT Only KEY _MENU_L_R_SOURCE 5 USB_PWR_EN0 SPI_CLK USB_PWR_EN0 5 USB_OC_COM SPI_CLK SPI_DATA USB_OC_COM 5 MT5366 SPI_DATA SPI_CLE PWR5V_3 PWR5V_3 14 SPI_CLE...
  • Page 60 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 60 10-1-13 HDMI Switch & Connector HDMI Switch & Connector D5002 MT5366 HDMI Switch NC/BAT54C Analog Power +5V_SW +5V_SW U4001G M_RX1_0 RX_0 M_RX1_0B DV33_TMDS RX_0B AVDD3V3 5V Input Detect M_RX1_1 DVDD3V3 FB5002 NEAR IC RX_1 R5002...
  • Page 61 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 61 10-1-14 DVB T/C Demodulator MT5135 DVB T/C Demodulator MT5135 DEMODULATOR MT5135/MT5136 Co-layout MT5135AD+ MT5135AD+ 16 MT5135AD- R1212 NC/0R05 1/16W MT5135AD- 16 PIN13 R1224 NC/0R05 1/16W 5135_DV10 T/C/T2_TUNER_SDA R1213 0R05 1/16W PIN39 5135_DV33 16,17 T/C/T2_TUNER_SDA...
  • Page 62 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 62 10-1-15 DVB-T/C/T2 Tuner DVB-T/C/T2 Tuner MT5135AD+ MT5135AD+ 15 MT5135AD- MT5135AD- 15 T2_AINP T2_AINP T2_AINN T2_AINN T/C/T2_TUNER_SDA 15,17 T/C/T2_TUNER_SDA T/C/T2_TUNER_SCL 15,17 T/C/T2_TUNER_SCL TU_FAT_IN2+ TU_FAT_IN2+ 8 TU_FAT_IN2- TU_FAT_IN2- 8 T2_IFAGC T2_IFAGC T2_RFAGC T2_RFAGC Current Limit Switch RF_AGC_Control RF_AGC_Control 13...
  • Page 63 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 63 10-1-16 DVB T2 Demodulator MN88472 DVB T2 Demodulator MN88472 DVDD3V3 DVDD3V3 I2C to TUNER R1520 R1521 4K7 1/10W 5% 4K7 1/10W 5% T2_TUNER_SCL R1522 T/C/T2_TUNER_SCL 0R05 1/10W T2_TUNER_SDA R1523 T/C/T2_TUNER_SDA 0R05 1/10W DVDD3V3 3V3_IO R1510...
  • Page 64 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 64 10-1-17 SSB layout top CN4012 R4021 R7020 CN6005 CN4005 C4038 U4004 C7034 U7005 C7038 CN4010 U7008 TP7002 TP7001 R1161 R7237 R7238 C7027 C7029 RP4012 RP4011 C1086 R1221 TP7003 C1196 R1219 C4158 RP4010 C7022 R7039...
  • Page 65 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 65 10-1-18 SSB layout bottom R4112 R4111 C4071 R7030 R4086 R4085 FB4004 C7040 R7036 FB4005 R7038 Q7004 R1145 Q4001 R1124 C1076 R1123 R1128 C4068 C1075 R7013 TP1003 R1121 C4081 R1114 R1213 R1120 C1185 R1212 C4009 R4093...
  • Page 66 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 66 10.2 B 715G5163 DVB-S2 /T/C SSB 3000/3500 series 10-2-1 System Power 1 System Power 1 ANALOG POWER AVDD1V2 from AVDD3V3 DVDD3V3 DVDD3V3 3,4,5,6,7,10,11,12,13,14,15,16,17 3V3SB AVDD3V3 AVDD1V2 3V3SB 3,4,5,6,7,11,14 U702 AP1117DL-13 DC POWER INPUT +5V_STB STB_PWR5V +5V_STB...
  • Page 67 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 67 10-2-2 System Power 2 System Power 2 PANEL_VCC_ON/OFF PANEL_VCC_ON/OFF +5V_SW +12V PANEL_VCC 2,4,5,6,7,8,9,10,11,12,13,14,15,16,17 Panel VCC=12V +5V_STB TO DV33SB TUNER_LNB TUNER_LNB +5V_STB 3V3SB DISEQC_OUT R769 R768 DISEQC_OUT 0R051/8W Q750 DISEQC_IN NC/0R051/8W DISEQC_IN U750 G1117-33T63Uf S2_DEMO_SDA S2_DEMO_SDA...
  • Page 68 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 68 10-2-3 Peripheral Peripheral DVDD3V3 DVDD3V3 2,3,5,6,7,10,11,12,13,14,15,16,17 U4051 NAND Flash +5V_STB 3V3SB +5V_STB MT5366 DVDD3V3 +5V_STB 2,3,5,7 U401A JTCK U0TX DVDD3V3 OSDA1 JTCK U0TX OSDA1 JTDI U0RX R4037 R4008 OSCL1 JTDI U0RX JTDO OSCL1 4.7K1/16W...
  • Page 69 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 69 10-2-4 Connector & USB Connector & USB DVDD3V3 DVDD3V3 2,3,4,6,7,10,11,12,13,14,15,16,17 USB_DP1 USB_DP1 +5V_STB 3V3SB 3V3SB USB_DM1 +5V_STB 2,3,4,7 USB_DM1 TO KEY PAD BOARD Light_Sensor Light_Sensor TO IR/KEY BOARD LED_G: KEY _UP_DN_DCSW KEY _UP_DN_DCSW 13 R4052 KEY _MENU_L_R_SOURCE...
  • Page 70 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 70 10-2-5 Audio I/O & SPDIF & Headphone Audio I/O & SPDIF & Headphone MT5366 Bathroom_R Bathroom_R Bathroom_L Bathroom_L HP_MUTE HP_DET U401F HP_MUTE HP_DET DVDD3V3 SCART1_R_In AE25 Y 23 AR0O DVDD3V3 2,3,4,5,7,10,11,12,13,14,15,16,17 AIN0_R_AADC AR0_ADAC SCART1_L_In...
  • Page 71 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 71 10-2-6 Speaker & Sound Woofer Speaker & Sound Woofer +5V_STB PVDD +5V_STB 2,3,4,5 FB650 AUD_V33 +24V 220R/2000mA Main Speaker Circuit 3V3SB 3V3SB 2,3,4,5,6,11,14 DVDD3V3 DVDD3V3 2,3,4,5,6,10,11,12,13,14,15,16,17 FB652 220R/2000mA OSDA1 R684 OSDA1 OSCL1 NC/4.7K1/16W OSCL1...
  • Page 72 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 72 10-2-7 Video I/O & YPbPr Video I/O & YPbPr MT5366 U401C TU_FAT_IN2- R1011 AD17 HSY NC Analog Power ADCINP_DEMOD HSY NC TU_FAT_IN2+ R1012 AE17 VSY NC ADCINN_DEMOD VSY NC AC10 DVBT Only AVDD33_DEMOD AC19 AVDD1V2...
  • Page 73 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 73 10-2-8 Scart SCART CVBS_COM CVBS_COM SCART (Full SCART) -- CVBS+SV+RGB+TV OUT SCART1R_PA SCART1R_PA 6 SCART1L_PA SCART1L_PA CVBS2P CVBS2P SOY 0 SOY 0 Y 0P Y 0P COM0 COM0 PB0P PB0P PR0P PR0P SCART_FS0 SCT1_AUR_OUT...
  • Page 74 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 74 10-2-9 VGA Input VGA Input VGA_UR_EN VGA_UR_EN U0TX U0TX VGA Input U0RX U0RX VGA_R_In C1104 1.5nF 50V VGA_R_In VGA_L_In VGA_L_In R1100 0R05 1/16W HSY NC HSY NC +5V_SW VSY NC C1105 10N 50V VSY NC R1101...
  • Page 75 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 75 10-2-10 LVDS LVDS LVDS OUTPUT MT5366 3V3SB 3V3SB 2,3,4,5,6,7,14 DVDD3V3 U401D DVDD3V3 2,3,4,5,6,7,10,12,13,14,15,16,17 AVDD33_USB_2P AVDD33_LVDSTX USB_DP0 USB_DP0 AVDD33_USB_2P AVDD33_LVDSA USB_DM0 AVSS33_USB_2P AVDD33_LVDSA USB_DM0 LVDS_CTRL LVDS_CTRL BRIGHT_ADJ AVSS33_LVDSA USB_VRT BRIGHT_ADJ 2 INVERTER_ON_OFF USB_2P_VRT AVSS33_LVDSA INVERTER_ON_OFF 2...
  • Page 76 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 76 10-2-11 DRAM Interface DRAM Interface MT5366 U401B DDR3#1 - 64 M × 16 - 1333 MHz DDR3#2 - 64 M × 16 - 1333 MHz RDQ0 1_A0 RDQ6//RDQ0 RCAS_//RA0 RDQ1 1_A1 RDQ0//RDQ1 RA6//RA1 RDQ2...
  • Page 77 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 77 10-2-12 MII & GPIO & Service AD MII & GPIO & Service AD SPI_CLK SPI_CLK SPI_DATA SPI_DATA SPI_CLE SPI_CLE CI_INT CI_INT HP_DET HP_DET MT5366 DEMOD_RST DEMOD_RST DEMOD_TSCLK DEMOD_TSCLK DEMOD_TSVAL U401E DEMOD_TSVAL DEMOD_TSSY NC DEMOD_TSSY NC PWR5V_3...
  • Page 78 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 78 10-2-13 HDMI Switch & Connector HDMI Switch & Connector +5V_SW HDMI SWITCH D502 NC/BAT54C MT5366 Analog Power U401G M_RX1_0 FB503 RX_0 M_RX1_0B DVDD3V3 5V Input Detect RX_0B M_RX1_1 AVDD3V3 ( 17 mA ) RX_1 R502 NC/120R/3000mA...
  • Page 79 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 79 10-2-14 DVB T/C Demodulator MT5135 DVB T/C Demodulator MT5135 Demodulator 27MHz Crystal PIN109 PIN109 PIN112 PIN112 5135_DV10 5135_DV10 5366_XTALI XTALI R1175 T/C/T2_TUNER_SDA 16,17 T/C/T2_TUNER_SDA 0R05 1/16W T/C/T2_TUNER_SCL 16,17 T/C/T2_TUNER_SCL Should be 50ohm R1178 MT5135AD- 51R 1%...
  • Page 80 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 80 10-2-15 DVB T2 Demodulator DVB T2 Demodulator DVDD3V3 3V3_IO DVDD3V3 DVDD3V3 T2_IFAGC R1251 AGC_I NC/10K 1/16W 5% R1269 NC/0R05 1/10W R1252 R1253 C1259 C1288 NC/100N 16V NC/4K7 1/16W 5% NC/4K7 1/16W 5% NC/100N 16V 2,3,4,5,6,7,8,9,10,11,12,13,14,15,17 3V3_LM...
  • Page 81 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 81 10-2-16 DVB T2/C/S2 Tuner DVB T2/C/S2 Tuner DVB-T/C: Panasonic ENV57U09D5F Tuner power TU_FAT_IN2+ TU_FAT_IN2+ TH1300 NC/PTCR RF_AGC T2_RFAGC TU_FAT_IN2- DVB-T2: Panasonic ENV57U04D8F TU_FAT_IN2- MT5135AD+ +5V_SW RF_AGC_Control MT5135AD+ MT5135AD- TU101 MT5135AD- NC/G552B1TA1U RF_AGC_Control ENV57U09D5F U1300...
  • Page 82 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 82 10-2-17 SSB layout top R402 CN409 R4193 R753 R1212 C1167 R1208 R4192 C1169 R1210 R1199 R1220 C1168 C753 C722 C718 R768 U702 R418 U704 R750 R769 R4117 R401 R400 C751 R1174 R1211 R4116 C1170...
  • Page 83 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 83 10-2-18 SSB layout bottom X1150 R1175 C1159 RP1150 R1186 R1178 TP418 TP1150 TP415 TP404 TP416 TP417 TP419 TP400 TP402 TP403 TP401 R1182 R1181 C1305 TP413 R1346 R1331 R1180 R1303 R1335 C1306 TP422 TP411 R1179...
  • Page 84 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 84 10.3 J 715G5230 IR/LED 3000 series 10-3-1 IR/LED board IR/LED board 3V3SB 3V3SB LED_R R301 CN201 2.2K 1/10W CONN KEY1 LED301 KEY2 R302 1K 1/10W C201 LED_R Q301 10uF 10V BC847C KEY2 CN001 KEY1...
  • Page 85 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 85 10-3-2 IR/LED Board layout Layout IR/LED Board (Top Side) C201 U201 LED301 Layout IR/LED Board (Bottom Side) C204 CN201 CN001 2011-10-14 IR/LED board 715G5230 layout top/bottom 19230_537_120305.eps 120305 back to 2012-Apr-27 div.
  • Page 86 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 86 10.4 E 715G5199 Keyboard 3000 series 10-4-1 Keyboard control panel Keyboard SW01 470R 1/10W 1% KEY1 Power ZD01 SW02 2K2 1/10W 1% ZD02 CN01 SW03 5K6 1/10W +/-1% KEY2 KEY1 ZD03 CONN NC/0R05 OHM NC/1K 1/10W...
  • Page 87 Circuit Diagrams and PWB Layouts TPM9.1E LA EN 87 10-4-2 Key board layout Layout Key Board (Top Side) Layout Key Board (Bottom Side) 2011-10-14 Keyboard 715G5199 layout top/bottom 19230_539_120308.eps 120313 back to 2012-Apr-27 div. table...
  • Page 88: Styling Sheets

    Styling Sheets TPM9.1E LA EN 88 11. Styling Sheets 11.1 3000 32" 3000 series 32" 1053 1050 0031 1054 1057 0041 1056 0032 Pos No. Description Remarks 0031 Front bezel 0032 Deco bezel 0041 Rear cover 0030 Stand 1050 Display panel 1053 Panel SSB 1054...
  • Page 89 Styling Sheets TPM9.1E LA EN 89 11.2 3000 37" 3000 series 37" 1053 0041 0031 1054 1057 0032 1050 Pos No. Description Remarks 0050 0031 Front bezel 0032 Deco bezel 0041 Rear cover 0050 Stand 1050 Display Panel 1053 Panel SSB 1054 Power Supply Unit 1056...
  • Page 90 Styling Sheets TPM9.1E LA EN 90 11.3 3000 42" 3000 series 42" 1053 0041 1054 1057 Pos No. Description Remarks 1056 0031 Front bezel 0032 Deco bezel 0041 Rear cover 1050 0050 Stand 0050 1050 Display panel 1053 SSB panel 0032 1054 Power Supply Unit...
  • Page 91 Styling Sheets TPM9.1E LA EN 91 11.4 3000 47" 3000 series 47" 1053 0041 1057 1054 1050 0031 Pos No. Description Remarks 0031 Front bezel 0032 Deco bezel 0041 Rear cover 0050 Stand 1050 Display panel 1053 SSB panel 0050 1056 1054 Power Supply Unit...

Table of Contents