Table of Contents
Advertisement
Colour Television
Contents
Wiring diagram 3000 series 32"
10. Circuit Diagrams and PWB Layouts
A 715G5827 PSU
11. Styling Sheets
3000 series 32"
Published by MjX/SC 1364 Quality
©
2013
TP Vision Netherlands B.V.
All rights reserved. Specifications are subject to change without notice. Trademarks are the
property of Koninklijke Philips Electronics N.V. or their respective owners.
TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust
earlier supplies accordingly.
PHILIPS and the PHILIPS' Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Page
Contents
2
2
5
9
23
25
30
33
34
35
36
Drawing PWB
37
39-40
41
46-47
48
51-52
53
63-64
65
66
67
68
69
70
71
Printed in the Netherlands
Chassis
TPS10.1L
Page
Subject to modification
EN 3122 785 19500
LA
2013-Apr-26
Advertisement
Table of Contents
Related Manuals for Philips 32PFL3008D/78
Summary of Contents for Philips 32PFL3008D/78
-
Page 1: Table Of Contents
Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V. -
Page 2: Revision List
& Notes: drivers. • Figures can deviate due to the different set executions. Table 2-1 Described Model Numbers and Diversity Mechanics Block Diagrams Schematics 32PFL3008D/78 10.1 10.4 10.5 10.6 11.1 32PFL3008D/77 10.1 10.4 10.5... -
Page 3: Side Connectors
Technical Specs, Diversity, and Connections TPS10.1L LA EN 3 Connections Side Connectors Rear Connectors TV ANTENNA CVBS R AUDIO SERV .U HDMI 2 (option) 19500_001_130408.eps 130408 Figure 2-1 Connection overview Note: The following connector colour abbreviations are used - D0+ Data channel (acc. - Page 4 Technical Specs, Diversity, and Connections EN 4 TPS10.1L LA - Shield 6 - Service / UART - D0- Data channel - Ground 10 - CLK+ Data channel - UART_TX Transmit 11 - Shield - UART_RX Receive 12 - CLK- Data channel 13 - Easylink/CEC Control channel 7- Cinch: Video YPbPr - In, Audio - In...
-
Page 5: Precautions, Notes, And Abbreviation List
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage. - Page 6 Precautions, Notes, and Abbreviation List EN 6 TPS10.1L LA result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
- Page 7 6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
- Page 8 SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
-
Page 9: Mechanical Instructions
Mechanical Instructions TPS10.1L LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly Cable Dressing 19500_100_130411.eps 130411... - Page 10 Mechanical Instructions EN 10 TPS10.1L LA 19500_101_130411.eps 130411 Figure 4-2 Cable dressing (39" 3000 series) 19500_102_130411.eps 130411 Figure 4-3 Cable dressing (42"-46" 3000 series) back to 2013-Apr-26 div. table...
- Page 11 Mechanical Instructions TPS10.1L LA EN 11 Service Positions For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop tools. Ensure that a stable situation is created to perform measurements and alignments.
- Page 12 Mechanical Instructions EN 12 TPS10.1L LA 4.3.1 Rear Cover screws [2], [3]that secure the rear cover. Refer to Figure 4-4 for details. 2. Gently lift the rear cover from the TV. Make sure that wires Refer to Figure 4-4 for details. and cables are not damaged while lifting the rear cover Warning: Disconnect the mains power cord before removing from the set.
- Page 13 Mechanical Instructions TPS10.1L LA EN 13 4.3.3 Power Supply Unit (PSU) Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the PSU. 1. Gently unplug all connectors from the PSU. 2.
-
Page 14: Service Modes, Error Codes, And Fault Finding
Service Modes, Error Codes, and Fault Finding EN 14 TPS10.1L LA 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: Life Timer 5.1 Test Points During the life time cycle of the TV set, a timer is kept (called 5.2 Service Modes “Op. - Page 15 Service Modes, Error Codes, and Fault Finding TPS10.1L LA EN 15 – Automatic user menu time-out (menu switches controls will not have I+ button, but an “INFO” button back/OFF automatically. instead. – Auto Volume levelling (AVL). How to Exit SDM How to Activate SDM •...
- Page 16 Service Modes, Error Codes, and Fault Finding EN 16 TPS10.1L LA Main Menu Sub-menu 1 Sub-menu 2 Description Download from USB Copy Channel List from USB To download several settings from the USB stick to the TV Copy NVM from USB Copy Readable Info from USB Copy EDID from USB Initialize NVM...
- Page 17 Service Modes, Error Codes, and Fault Finding TPS10.1L LA EN 17 Default value Item Item value 32" 39" 42" Description W/B Pattern W/B Pattern Gain ADC Gain Offset Offset RGB ColorTemp cool The current set of color temperature Scaler MST6931XP Scaler model Gain R137...
- Page 18 Service Modes, Error Codes, and Fault Finding EN 18 TPS10.1L LA • Press the MENU/HOME button on the remote control • Press the POWER button on the remote control transmitter. transmitter. • Press the POWER button on the television set. Stepwise Start-up Standby Soft Mode Command Received,...
- Page 19 A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
-
Page 20: Error Codes
Service Modes, Error Codes, and Fault Finding EN 20 TPS10.1L LA • FUS_clustername_version.zip: Contains the “autorun.upg” which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair. 5.5.7 How to Copy NVM Data to/from USB When copying data to and from a USB memory stick, the folder... -
Page 21: The Blinking Led Procedure
Service Modes, Error Codes, and Fault Finding TPS10.1L LA EN 21 – ERROR: 034 013 000 000 000: Error code 13 was Fault Finding and Repair Tips detected first and error code 34 is the last detected Note: (newest) error •... - Page 22 Service Modes, Error Codes, and Fault Finding EN 22 TPS10.1L LA 5.8.10 Display option code Attention: In case the SSB is replaced, always check the Panel Code in CSM, even when picture is available. Performance with the incorrect display option code can lead to unwanted side-effects for certain conditions.
-
Page 23: Alignments(Option)
Alignments(Option) TPS10.1L LA EN 23 6. Alignments(Option) Index of this chapter: In case you have a colour analyser: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyser (e.g. Minolta CA-210) in the centre of the screen. 6.3 Software Alignments Consequently, the measurement needs to be done in a 6.4 Option Settings... -
Page 24: Option Settings
Alignments(Option) EN 24 TPS10.1L LA Option Settings 6.5.1 Reset of Repaired SSB 6.4.1 Introduction Instruction After NVM replacement, reload MAC address via SAM menu.This ensures the correct MAC address to be available in The microprocessor communicates with a large number of I CSM for future repair actions. -
Page 25: Circuit Descriptions
Circuit Descriptions TPS10.1L LA EN 25 7. Circuit Descriptions Introduction Index of this chapter: 7.1 Introduction The TPS10.1L LA is a new chassis launched in LATAM in 7.2 Power Supply 2013. The whole range is covered by SCALER MST6931. 7.3 DC/DC Converters The major deltas versus its predecessor support ATV, DTV;... - Page 26 Circuit Descriptions EN 26 TPS10.1L LA 7.1.3 SSB Cell Layout DC/DC TUNER MST6931XP HDMI Headphone AUDIO AMP HDMI ANALOG I/O SERVICE CONNECTOR 19500_200_130415.eps 130415 Figure 7-1 SSB layout cells (top view) back to 2013-Apr-26 div. table...
- Page 27 The following displays can be distinguished: specifications! This part is available in the regular market. • CCFL/EEFL backlight: power panel is conventional IPB Consult the Philips Service web portal for the order codes of the • LED backlight: panels. - side-view LED without scanning: PSL power panel - side-view LED with scanning: PSLS power panel Important delta’s with the TPS10.L LA classis platform are:...
- Page 28 Circuit Descriptions EN 28 TPS10.1L LA • +3V3-STANDBY, power supply for LED/IR receiver and Connector controls Number CN8101 CN9101 CN8101 CN9101 CN8501 CN9101 • +12V, input from the power supply for the panel Descriptio common(active mode) to panel to SSB to panel to SSB to panel...
- Page 29 Circuit Descriptions TPS10.1L LA EN 29 7.4.2 Front-End DTV part • RealMedia Decoder The Front-End for DVB part consist of the following key The MST6931XP combines front-end video processing components: functions, such as NTSC/PAL/SECAM Video Decoder, MPEG-2/H.264 decode, analog video decode and HDMI reception, with advanced back-end video picture •...
-
Page 30: Ic Data Sheets
IC Data Sheets EN 30 TPS10.1L LA 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs). - Page 31 IC Data Sheets TPS10.1L LA EN 31 Diagram 10-4-8 MSB1400 Demod, B08, MSB1400 Demod(IC U101) Pinning Information I 2CS _SCL TS_D[6] TS_D[7] Pin 1 XTAL_OUT TS_CLK SSPI_C LK XTAL_IN SSPI_ DI AVDD33 RFAGC SSPI_ DO IFAGC RESE TZ SSPI_C SZ VDD33 19500_300_130409.eps 130409...
-
Page 32: Block Diagram
IC Data Sheets EN 32 TPS10.1L LA Diagram 10-4-10 Earphone pre amp, B10, APA2176A(IC U606) Block diagram APA 2 1 7 6 A ROUT LOUT PVDD Shutdown Charge Power and circuit Pump Depop circuit circuit PGND CVSS Pinning information 16 LSD 15 GND PVDD 2 14 RIN... - Page 33 KEYBOARD CONTROL (1057) CN601 CN701 HDMI 1...
-
Page 34: Wiring Diagram 3000 Series 39
KEYBOARD CONTROL (1057) CN601 CN701 HDMI 1... -
Page 35: Wiring Diagram 3000 Series 42"-46
KEYBOARD CONTROL (1057) CN601 CN701 HDMI 1... - Page 39 D9106 J9902 J9901 J8113 J8101 SG20 J8112 J8102 SG14 J8105 R8120 J8106 J8107 J8108 J9102 J8103 J9101 J9104 J9103 J9106 J8109 J8111 J9108 J9109 J9107...
- Page 40 C9358 R9145 C9357 R9146 C9118 C9133 C9354 C9115 C9360 R9359 C8107 R9356 R9357 R9139 R8112 R9132 R8113 C8106 R8111 D8102 R8110 C9114 R8133 R8108 R9141 C8110 R9128 R9133 C9121 C9119 R8138 R9127 R9129 C8118 D8103 C8104 C8108 C8120 ZD8102 R8118 R8130 C9109 C8111...
- Page 41 C9906 470NF 275V IC9901 CAP004DG-TL R9906 R9904 R9901 R9902...
- Page 42 R9818 20K 1/8W 1% R9823 390K 1/8W 1% COMP RAMP R9815 200K 1/8W 1%...
- Page 43 C9113 10N 50V C9103 330P 50V R9405 100K 1/8W 1% ZD9401 IC9401 IC9102 BZT52-B16 PS2561DL1-1 PS2561DL1-1 R9128 200K 1/8W 1% C9401 R9127 9.1K 1% C9403 100N 50V C9108 330UF 35V C9109 330UF 35V C9110 R9152 R9162 330UF 35V 20K 1/4W 2K 1/8W 5% C9102 IC9106...
- Page 44 R8161 D8118 10 OHM RB160M R8157 10K 1/8W 1%...
-
Page 46: A 715G5792 Psu
J914 J915 J934 J916 J917 MH44 J918 J919 MH43 J942 J938 J920 J921 J935 J923 J907 J908 J924 J909 J910 J905 J906 J901 R9907 J913 J945 J940 J925 J931... - Page 47 C9145 C9112 C9138 R9138 R9123 R9132 R9122 C9115 C9129 R9133 R9115 C9147 R9152 R9162 R9150 R9904 R9902 R9906 R9901 R9129 R9140 R9102 R9136 R9126 C9118 R9339 R9139 R9143 R9125 R9402 R9131 R9114 R9178 R9103 R8513 R9113 R9144 R8511 R9403 R9404 R9308 C8517 C9131...
- Page 48 IC9901 CAP004DG-TL R9906 R9901...
- Page 49 IC9102 PS2561DL1-1 D9104 SK84C C9108 R9152 R9162 330UF 35V 20K 1/4W 2K 1/8W 5% C9109 330UF 35V C9116 IC9106 220UF 35V AS431AN-E1 C9110 330UF 35V-NC C9115 100N 50V R9156 C9102 1K OHM 330UF 35V-NC R9157 1K OHM C9138 100N 50V C9401 C9111 330UF 35V-NC...
-
Page 51: A 715G6050 Psu
J903 MH43 MH44 J919 MH46 MH47 J914 J916 J918 J915 J930 J907 J908 J901 J913 J929 R9907 J928 J917 J920 J925 J923... - Page 52 C9145 C9112 C9138 R9138 R9132 C9115 R9154 R9115 C9129 R9133 C9147 R9152 R9162 R9150 R9906 R9159 R9902 R9901 R9160 R9904 R9128 R9339 R9141 R9136 R9131 R9143 R9127 C9118 R9124 R9125 R9408 C9403 RJ902 R9407 R9135 R9142 R9112 R9107 R8129 C8108 R8119 R8130 C8114...
- Page 54 E-Pad LINEIN_R3 HOTPLUGA LINEIN_L4 RX2P_D LINEIN_R4 RX2N_D LINEIN_L5 DDCDD_CK LINEIN_R5 RX1P_D LINEOUT_L3 RX1N_D LINEOUT_R3 DDCDD_DA LINEOUT_L0 RX0P_D LINEOUT_R0 RX0N_D XOUT RXCKP_D RXCKN_D AVDD_DMPLL HOTPLUGD GND-EFUSE AVDD_REF RESET TAGC IRIN SAR2 VDDIO_CMD SAR1 GPIO55 SAR0 GPIO56 VDDIO_DATA AVDD_PLL DDCA_DA VDDC DDCA_CK LVA4P PWM1 LVA4M...
- Page 57 56R 1/16W 1% 56R 1/16W 1% 56R 1/16W 1% 100R 1/10W 5%...
- Page 60 AVDD33_ADC I2CS_SDA SAR_RSSI AVDD_SAR VDD33 TS_SYNC TS_VLD AMP_BOND_MODE TS_D[0] I2CM_SCL TS_D[1] I2CM_SDA TS_D[2] TS_D[3] VDD33 TS_D[4] TS_ERR TS_D[5]...
- Page 62 CVSS PVDD /LSD LOUT...
-
Page 63: B 715G5749 Ssb
ZD701 R737 C625 C628 C626 R621 R623 C630 C739 R707 C712 R620 C642 C641 R622 R624 R625 D2901 Q2902 Q2901 Q407 C710 Q503 C701 R533 D501 R4011 C723 R4012 R719 R4015 R721 R717 R4014 FB405 R484 FB401 R440 R483 C479 C480 ZD408 ZD409... -
Page 66: J 715G5772 Ir/Led Panel 65
R302 R301 C203 C201 D201 D202 C204 R202 R201... - Page 67 R020 R016 470R 1/8W 1% 470R 1/8W 1% C019 C016 NC/100N 50V NC/100N 50V R021 R017 2K2 1/8W 1% 2K2 1/8W 1% C017 C020 NC/100N 50V NC/100N 50V R022 R018 5K6 +-1% 1/8W 5K6 +-1% 1/8W C018 C021 NC/100N 50V NC/100N 50V...
-
Page 68: E 715G5771 Keyboard Control Panel 67
SW11 SW12 C016 R020 SW14 C018 R022 SW16 C017 R021 R016 C019 SW20 SW13 R018 C021 SW18 R017 C020 SW15 R024 R023 R025 C024 C023 SW17...