Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Page 3
Technical Specs, Diversity, and Connections TPN10.1E LA EN 3 Directions for Use http://www.philips.com/support Directions for use can be downloaded from the following http://www.p4c.philips.com websites: Connections ( for 32" & 39") Side Connectors Side Connectors Rear Connectors HDMI 1 TV ANTENNA...
Page 4
EN 4 TPN10.1E LA Technical Specs, Diversity, and Connections 3 - HDMI2 : Digital Video - In, Digital Audio - In/Out 10000_017_090121.eps 090428 Figure 2-4 HDMI (type A) connector - D2+ Data channel - Shield - D2- Data channel - D1+ Data channel - Shield - D1-...
Page 5
Technical Specs, Diversity, and Connections TPN10.1E LA EN 5 Connections ( for 40"/42"/47"PFL31x8H/12) Rear Connectors Side Connectors HDMI 1 DIGITAL AUDIO IN AUDIO OUT HDMI 2 SERV.U TV ANTENNA SCART (RGB/CVBS) 19530_002_130719.eps 130719 Figure 2-6 Connection overview Note: The following connector colour abbreviations are used - D2+ Data channel (acc.
Page 6
EN 6 TPN10.1E LA Technical Specs, Diversity, and Connections - Shield - D0- Data channel 10 - CLK+ Data channel 11 - Shield 12 - CLK- Data channel 13 - Easylink/CEC Control channel 14 - ARC Audio Return Channel 15 - DDC_SCL DDC clock 16 - DDC_SDA DDC data...
Page 7
Technical Specs, Diversity, and Connections TPN10.1E LA EN 7 Connections ( for 40"/47"PFL31x8T/60) Rear Connectors Side Connectors HDMI 1 USB 1 DIGITAL AUDIO OUT TV ANTENNA AUDIO IN SCART (RGB/CVBS) SERV.U USB 2 19530_003_130722.eps 130722 Figure 2-11 Connection overview Note: The following connector colour abbreviations are used 5 - HDMI3 : Digital Video - In, Digital Audio - In/Out (acc.
Page 8
EN 8 TPN10.1E LA Technical Specs, Diversity, and Connections - D2+ Data channel - UART_TX Transmit - Shield - UART_RX Receive - D2- Data channel - D1+ Data channel 12 - EXT1: Video RGB/YC - In, CVBS - In/Out, Audio - In/Out - Shield - D1- Data channel...
Page 9
Technical Specs, Diversity, and Connections TPN10.1E LA EN 9 Connections ( for 20"/22"/24"PFL3108H) Rear Connectors Side Connectors HDMI 1 AUDIO IN VGA / DVI S CART (RGB/CVBS) TV ANTENNA 19531_001_130923.eps 130923 Figure 2-18 Connection overview Note: The following connector colour abbreviations are used 5 - PC IN:VGA (acc.
Page 10
EN 10 TPN10.1E LA Technical Specs, Diversity, and Connections - D1+ Data channel 10 - EXT1: Video RGB/YC - In, CVBS - In/Out, Audio - In/Out - Shield - D1- Data channel - D0+ Data channel - Shield 10000_001_090121.eps - D0- Data channel 090121 10 - CLK+...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 12
EN 12 TPN10.1E LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 13
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 14
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPN10.1E LA EN 15 4. Mechanical Instructions Index of this chapter: 4.6 Set Re-assembly 4.1 Cable Dressing Notes: 4.2 Service Positions • Figures below can deviate slightly from the actual situation, 4.3 Assembly/Panel Removal (for 32" & 39") due to the different set executions.
Page 16
EN 16 TPN10.1E LA Mechanical Instructions 19530_100_130725.eps 130725 Figure 4-2 Cable dressing (32" 3000 series) 19530_101_130729.eps 130729 Figure 4-3 Cable dressing (39" 3000 series) back to 2013-Oct-18 div. table...
Page 17
Mechanical Instructions TPN10.1E LA EN 17 19530_102_130729.eps 130729 Figure 4-4 Cable dressing (40" 31x8H/12 series) 19530_103_130729.eps 130729 Figure 4-5 Cable dressing (40" 31x8T/60 series) back to 2013-Oct-18 div. table...
Page 18
EN 18 TPN10.1E LA Mechanical Instructions 19530_104_130729.eps 130729 Figure 4-6 Cable dressing (47" 31x8H/12 series) 19530_105_130729.eps 130729 Figure 4-7 Cable dressing (47" 31x8T/60 series) back to 2013-Oct-18 div. table...
Page 19
Mechanical Instructions TPN10.1E LA EN 19 Service Positions 4.3.1 Rear Cover For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop Refer to Figure 4-8 for details.
Page 20
EN 20 TPN10.1E LA Mechanical Instructions Q3 × 8 19530_108_130723.eps 130723 Figure 4-9 Rear cover removal [2] 4.3.2 Speakers Refer toFigure 4-9 Figure 4-10 for details. 1. Remove fixation screws [1] that secure the speakers cover, Refer to Figure 4-9 for details.
Page 21
Mechanical Instructions TPN10.1E LA EN 21 19530_110_130723.eps 130723 Figure 4-10 Speakers removal 4.3.3 Small Signal Board (SSB) + PSU combination panel Refer to Figure 4-11 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB + PSU combination panel.
Page 22
EN 22 TPN10.1E LA Mechanical Instructions 2. Unplug the connector from the Control Board IR/LED Assembly/Panel Removal (for 40" & 42" & 47") panel. Instructions below apply to the 40PFL3188T/60, but will be 3. Gently release the clip that holds the panel and take it out similar for other series models.
Page 23
Mechanical Instructions TPN10.1E LA EN 23 Q3 × 8 19530_109_130723.eps 130723 Figure 4-13 Rear cover removal [2] 4.4.2 Speakers Refer to Figure 4-10 Figure 4-13 for details. 1. Remove fixation screws [1] that secure the speakers cover, Refer to Figure 4-13 for details.
Page 24
EN 24 TPN10.1E LA Mechanical Instructions 4.4.5 Stand bracket When defective, replace the whole unit. 1. Remove all fixation screws of the bracket. Assembly/Panel Removal (for 20" & 22" & 24") 2. Lift the bracket from the set. Instructions below apply to the 24PFL3108H/12, but will be similar for other series models.
Page 25
Mechanical Instructions TPN10.1E LA EN 25 Notes: • While re-assembling, make sure that all cables are placed and connected in their original position. See Figure 4-1. • Pay special attention not to damage the EMC foams on the SSB shields. Ensure that EMC foams are mounted correctly.
EN 26 TPN10.1E LA Service Modes and Fault Finding 5. Service Modes and Fault Finding Index of this chapter: Life Timer 5.1 Test Points During the life time cycle of the TV set, a timer is kept (called 5.2 Service Modes “Op.
Page 27
Service Modes and Fault Finding TPN10.1E LA EN 27 – Auto Volume levelling (AVL). controls will not have I+ button, but an “INFO” button instead. How to Activate SDM To activate SDM, use the following methods: How to Exit SDM •...
Page 28
EN 28 TPN10.1E LA Service Modes and Fault Finding How to Exit SAM Specifications Use one of the following methods: • Displaying and or changing Panel ID information. • Switch the set to STANDBY by pressing the mains button • Displaying and or changing Tuner ID information.
Page 29
Service Modes and Fault Finding TPN10.1E LA EN 29 Default value Item Item value 20" 22" 24" 32" 39" 40" 42" 47" Description DDR SSC Freq 30KHz DDR SSC frequency Panel H.Flip Flip panel Panel V.Flip Flip panel Panel ABSwap ABSwap panel Watchdog 5sec...
Page 30
EN 30 TPN10.1E LA Service Modes and Fault Finding Stepwise Start-up Standby Soft Mode Command Received, Switch previously in Standby Off(Mains Soft Mode (Power tact Standby Power Plug) switch) Digital Digital background background tasks started tasks completed TV Wakeup commands Received Standby (TV Wakeup...
Page 31
A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
Page 32
EN 32 TPN10.1E LA Service Modes and Fault Finding • FUS_clustername_version.zip: Contains the file downloaded which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair. 5.5.7 How to Copy NVM Data to/from USB When copying data to and from a USB memory stick, the folder “repair”...
Page 33
Service Modes and Fault Finding TPN10.1E LA EN 33 Fault Finding and Repair Tips 5.7.10 Display option code Note: • It is assumed that the components are mounted correctly Attention: In case the SSB is replaced, always check the Panel with correct values and no bad solder joints.
EN 34 TPN10.1E LA Alignments 6. Alignments Index of this chapter: In case you have a colour analyser: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyser (e.g. Minolta CA-210) in the centre of the screen. 6.3 Software Alignments Consequently, the measurement needs to be done in a 6.4 Option Settings...
Page 35
Alignments TPN10.1E LA EN 35 Option Settings 6.5.1 Reset of Repaired SSB 6.4.1 Introduction Instruction After NVM replacement, reload MAC address via SAM menu.This ensures the correct MAC address to be available in The microprocessor communicates with a large number of I CSM for future repair actions.
EN 36 TPN10.1E LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPN10.1E LA is a new chassis launched in Europe in 7.2 Power Supply 2013. The whole range is covered by NT72567. 7.3 DC/DC Converters The major deltas versus its predecessor support DVB-TC;...
Page 37
Circuit Descriptions TPN10.1E LA EN 37 7.1.3 SSB Cell Layout COMMON INTERFACE DC/DC AUDIO AMP NT72567BG-BA HDMI HDMI SERVICE CONNECTOR SPDIF OUT SCART TUNER 19530_200_130807.eps 130807 Figure 7-1 SSB layout cells (top view) ( for 32" & 39") back to 2013-Oct-18 div.
Page 38
EN 38 TPN10.1E LA Circuit Descriptions 7.1.4 SSB Cell Layout COMMON INTERFACE DC/DC NT72567BG SPDIF OUT HDMI AUDIO IN SERVICE CONNECTOR Headphone TUNER SCART 19530_201_130807.eps 130807 Figure 7-2 SSB layout cells (top view) ( for 40" & 42" & 47"PFL31x8H/12) back to 2013-Oct-18 div.
Page 39
Circuit Descriptions TPN10.1E LA EN 39 7.1.5 SSB Cell Layout DC/DC COMMON INTERFACE NT72567BG SPDIF OUT HDMI AUDIO IN SERVICE CONNECTOR Analog Input Headphone TUNER SCART Power Button 19531_200_130923.eps 130923 Figure 7-3 SSB layout cells (top view) ( for 20" & 22" & 24") back to 2013-Oct-18 div.
Page 40
EN 40 TPN10.1E LA Circuit Descriptions 7.1.6 SSB Cell Layout COMMON INTERFACE DC/DC NT72567BG HDMI SPDIF OUT TUNER AUDIO IN Headphone SCART SERVICE CONNECTOR 19530_202_130808.eps 130808 Figure 7-4 SSB layout cells (top view) ( for 40" & 47"PFL31x8T/60) back to 2013-Oct-18 div.
Page 41
Circuit Descriptions TPN10.1E LA EN 41 Power Supply Refer to figure Figure 7-5 Figure 7-6 for the power architecture of this platform. LVDS AMP CN8501 Platform power BL-ON/OFF Display power Platform NT72567BG-BA CN701 FOR 715G6094 Low stby CN601 FOR 715G6092 power Ac-input + Mains filter 1 power- PCB...
Page 42
- direct-view LED with 2D-dimming: PSDL power panel. specifications! This part is available in the regular market. Consult the Philips Service web portal for the order codes of the boards. PSL stands for Power Supply with integrated LED-drivers.
Page 43
Circuit Descriptions TPN10.1E LA EN 43 DC/DC Converters • +3V3, genenal supply voltage The on-board DC/DC converters deliver the following voltages • +3V3-TUN, supply voltage for tuner (depending on set execution): • +3V3 from the power supply for the scaler IC NT72567 •...
Page 44
EN 44 TPN10.1E LA Circuit Descriptions AUDIO AMP POWER SWITCH PVDD PWR_12V_AUD AON4421 STA381BWTR Q757 Depend on panel PANEL_T-CON POWER SWITCH PWR_12V +5V or +12V PWR_12V AON4421 PANEL_22" +5V_STB ~55" Q750 PWR_12V/5V PANEL_VCC_ON/OFF BUCK CONVERTER MAIN CHIP <2.5A +5V_STB RT8079ZQW DV11 <1820mA +5V_STB...
Page 45
Circuit Descriptions TPN10.1E LA EN 45 AUDIO AMP PWR_16_24V PWR_12V_AUD ST381BWTR Depend on panel PANEL_T-CON POWER SWITCH PWR_12V PWR_12V AON4421 +5V or +12V PANEL +5V_STB Q750 PANEL_VCC_ON/OFF BUCK CONVERTER MAIN CHIP +5V_STB DV11 <1820mA STB_PWR5V RT8079 NT72568 U701 PWR_ON MAIN CHIP NAND FLASH +5V_STB LM1108SF...
Page 46
EN 46 TPN10.1E LA Circuit Descriptions • TUNER EUROPE system ST03CS-2-E • SCALER NT72567BG-BA LFBGA-576 • DEMODULATOR NT78820TLMFG/B LQFP-64 NT72567BG-BA TMDS Below find a block diagram of the front-end application for DVB-T2 DTV part. ST03CS-2-E CN1003 TMDS HDMI 2 T2 Demod CN1002 NT78820TLMFG/B IF_AGC...
IC Data Sheets TPN10.1E LA EN 47 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 48
EN 48 TPN10.1E LA IC Data Sheets Diagram 10-3-1 Power, B01, TPS54519RTE (IC U701) Block diagram PWRGD Shutdown Thermal UVLO Shutdown Enable Comparator Logic Shutdown Shutdown Logic 107% Enable Threshold Boot Voltage Charge Reference Boot Minimum Current UVLO COMP Clamp Sense ERROR AMPLIFIER...
Page 49
IC Data Sheets TPN10.1E LA EN 49 Diagram 10-3-3 NT72567_ADC/DAC/AUDIO/SIF, B03, NT72567BG-BA (IC U4001D) Block diagram DDR3 NT72567BG-BA TS Demux Visual Display Effect LVDS TX LVDS Processor Multi- Processor Media COFDM Decoder /QAM Graphic interlace VGA/YPbPr Noise HDMI_A/MHL Reduction TMDS RX HDMI_B HDMI_C CVBS...
Page 50
EN 50 TPN10.1E LA IC Data Sheets Pinning Information NT72567BG-BA 19530_302_130724.eps 130724 Figure 8-4 Internal pin configuration [1/6] back to 2013-Oct-18 div. table...
Page 51
IC Data Sheets TPN10.1E LA EN 51 Pinning Information NT72567BG-BA 19530_303_130724.eps 130724 Figure 8-5 Internal pin configuration [2/6] back to 2013-Oct-18 div. table...
Page 52
EN 52 TPN10.1E LA IC Data Sheets Pinning Information NT72567BG-BA 19530_305_130724.eps 130724 Figure 8-6 Internal pin configuration [3/6] back to 2013-Oct-18 div. table...
Page 53
IC Data Sheets TPN10.1E LA EN 53 Pinning Information NT72567BG-BA 19530_306_130724.eps 130724 Figure 8-7 Internal pin configuration [4/6] back to 2013-Oct-18 div. table...
Page 54
EN 54 TPN10.1E LA IC Data Sheets Pinning Information NT72567BG-BA 19530_307_130724.eps 130724 Figure 8-8 Internal pin configuration [5/6] back to 2013-Oct-18 div. table...
Page 55
IC Data Sheets TPN10.1E LA EN 55 Pinning Information NT72567BG-BA 19530_308_130724.eps 130724 Figure 8-9 Internal pin configuration [6/6] back to 2013-Oct-18 div. table...
Page 56
EN 56 TPN10.1E LA IC Data Sheets Diagram 10-3-11 SPEAKER AMPLIFER/HEADPHONE OUT, B11, STA381BWTR (IC U601) Block diagram STA381BW OUT 1A OUT 1B 2.1 Channel Half MCLK OUT 2A Audio Processor Bridges OUT 2B Modulator STAudioFx FFX3A LRCKI STSpeakerSafe FFX3B Parametric EQ BICKI Binary...
Page 57
IC Data Sheets TPN10.1E LA EN 57 Diagram 10-4-1 Power-1, B01, RT8079ZQW (IC U701) Block diagram RT8079ZQW Internal pull up Over Temperature current Protection UVLO Enable Comparator Shutdown Current EN Threshold Control Sense BOOT RT/SYNC Oscillator Control Driver Slope Logic Compensation Comparator SS/TR...
Block Diagrams TPN10.1E LA EN 59 9. Block Diagrams Wiring diagram 3000 series 24" WIRING DIAGRAM 24" (3000 series) See note in Chapter 6 about cable position numbers Board Level Repair Component Level Repair Only for authorized workshops CN701 MAIN POWER SUPPLY (1054) DIGITAL HDMI 1...
Block Diagrams TPN10.1E LA EN 60 Wiring diagram 3000 series 32" WIRING DIAGRAM 32" (3000 series) See note in Chapter 6 about cable position numbers Board Level Repair Component Level Repair Only for authorized workshops TO PANEL SSB + PSU (1052) HDMI 1 HDMI 2...
Block Diagrams TPN10.1E LA EN 61 Wiring diagram 3000 series 39" WIRING DIAGRAM 39" (3000 series) See note in Chapter 6 about cable position numbers Board Level Repair Component Level Repair Only for authorized workshops TO PANEL SSB + PSU (1052) HDMI 1 HDMI 2...
Block Diagrams TPN10.1E LA EN 62 Wiring diagram 31x8H/12 series 40" WIRING DIAGRAM 40" (31x8H/12 series) See note in Chapter 6 about cable position numbers Board Level Repair Component Level Repair Only for authorized workshops CN9101 TO PANEL CN701 MAIN POWER SUPPLY (1054) DIGITAL (1053)
Block Diagrams TPN10.1E LA EN 63 Wiring diagram 31x8T/60 series 40" WIRING DIAGRAM 40" (31x8T/60 series) See note in Chapter 6 about cable position numbers Board Level Repair Component Level Repair Only for authorized workshops CN9101 CN701 (1053) MAIN POWER SUPPLY (1054) HDMI 1 USB 1...
Block Diagrams TPN10.1E LA EN 64 Wiring diagram 31x8H/12 series 42"- 47" WIRING DIAGRAM 42"- 47" (31x8H/12 series) See note in Chapter 6 about cable position numbers Board Level Repair Component Level Repair Only for authorized workshops CN9101 CN701 MAIN POWER SUPPLY (1054) DIGITAL (1053)
Block Diagrams TPN10.1E LA EN 65 Wiring diagram 31x8T/60 series 47" WIRING DIAGRAM 47" (31x8T/60 series) See note in Chapter 6 about cable position numbers Board Level Repair Component Level Repair Only for authorized workshops CN9101 CN701 (1053) MAIN POWER SUPPLY (1054) HDMI 1 USB 1...
Circuit Diagrams and PWB Layouts TPN10.1E LA EN 77 10.3 BA 715G6079 SSB+PSU combination panel 10-3-1 Power POWER BA01 BA01 GND_AC 17,18 GND_AC 2K13 EU NT72567 - 2 Layers 125mm X 186mm +12V_PWR TO +12V +5V_STB to +5V_SW PANEL_VCC PANEL_VCC 7 +5V_STB +5V_SW +12V_PWR...