Related Manuals for Harmar Mobility HELIX
Summary of Contents for Harmar Mobility HELIX
- Page 1 Curved Stair Lift Installation & Service Manual This image is for illustrative purposes only. Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B...
-
Page 2: Table Of Contents
Device Name: Harmar Helix Curved Stair Lift ASME A18.1-2014 "SAFETY STANDARD FOR Indications for Use: The intended use of the Helix PLATFORM LIFTS AND STAIRWAY CHAIR LIFTS" Stair Lift is to assist transfers of patients or mobility impaired persons up and down flights of stairs. -
Page 3: Whats In The Box
• Rails • Complete Seat Assembly and chassis • Power Supply • Wires • Bag of Screws • Pipe and Support Caps • Charge Station Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B... -
Page 4: Required Tools
Towels (for cleaning) Recommended: Volt OHM Meter Lightweight grease (white lithium) Optional: Pull Strap/Ratcheting Strap Tape Measure Mounting Screws could be needed, based on flooring (not shown) Angle Meter | www.harmar.com | 800-833-0478 © 2018 Harmar Mobility, LLC • All Rights Reserved... -
Page 5: Installation
Emery paper and add a small amount of grease to help slide the pipes together. [Figure 5-5] Figure 5-4 Figure 5-5 Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B... - Page 6 It may be necessary to bolt down one or two legs to hold the rail in place. CHECK If necessary, move the rail position to provide the best fit | www.harmar.com | 800-833-0478 © 2018 Harmar Mobility, LLC • All Rights Reserved...
- Page 7 Route wire of seat thru seat mounting hole. Install seat [Figures 7-5, 7-6]. Figure 7-5 Figure 7-6 Observe magnet switch for seat safety. [Figures 7-7, 7-8] Figure 7-7 Figure 7-8 Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B...
-
Page 8: Figure
Activate the rocker [Figure 8-7] to drive onto rack, watching the wheels to ensure they go on smoothly. Ensure the unit goes down the gear rack about 6". Figure 8-5 Figure 8-6 Figure 8-7 | www.harmar.com | 800-833-0478 © 2018 Harmar Mobility, LLC • All Rights Reserved... -
Page 9: Figure
6) Install Cover The unit will stop on this when driven with the wireless remote. It will stop for 5 to 6 seconds then continue. Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B... -
Page 10: Figure
[Figure 10-7] Figure 10-7 NOTE: The power supply charger needs to be placed out of the weather elements to be protected. | www.harmar.com | 800-833-0478 © 2018 Harmar Mobility, LLC • All Rights Reserved... -
Page 11: Figure
Install hard final limit on gear rack at both ends of rail. [Figures 11-5, 11-6] Rail end caps and support caps need to be installed Figure 11-5 Figure 11-6 Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B... - Page 12 Conflicting Switches STOP UP & STOP ... . .8 DOWN switches both not Detected Helix Only LIMIT Switch Dectected ....9 | www.harmar.com | 800-833-0478...
-
Page 13: Installation
On the wireless control board press and hold the little button on the board then hold the up button on the remote for 3 to 4 seconds and it should learn the remote. Hit other remote at same time. Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B... -
Page 14: Final Checks
The lift is now ready to use. Remember to leave the Owner’s Manual with the end-user and answer any questions they may have on the use of the Curved Stair Lift. | www.harmar.com | 800-833-0478 © 2018 Harmar Mobility, LLC • All Rights Reserved... -
Page 15: Technial Specifications
Warranty: ........... . 2-Year on Components *Note: Average incline must not exceed 45° per ASME A18.1. Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B... -
Page 16: Wiring
WIRING DIAGRAM BLUE | www.harmar.com | 800-833-0478 © 2018 Harmar Mobility, LLC • All Rights Reserved... -
Page 17: Maintenance
Rail Guard Down q Step Guard Up q Step Guard Down q Emergency Switch On q Emergency Switch Off q Chassis Lights On q Chassis Lights Off Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B... - Page 18 Bottom MOUNTING BOLTS q Check all rail bolts for tightness q Check all leg bolts for tightness ANNUAL CHECKLIST q Same as above q Replace Batteries | www.harmar.com | 800-833-0478 © 2018 Harmar Mobility, LLC • All Rights Reserved...
- Page 19 NOTES Helix Curved Stair Lift - Install and Service Manual 2016 TEC0067 P/N: 630-00063-01 Rev B...
- Page 20 2075 47 Street Sarasota, FL 34234 800.833.0478 harmar.com Helix Curved Stair Lifts Installation Manual TEC0067 P/N: 630-00063-01 Rev B | www.harmar.com | 800-833-0478 © 2018 Harmar Mobility, LLC • All Rights Reserved...