Table of Contents
Advertisement
Quick Links
English
ASSEMBLY INSTRUCTIONS
AND USE AND CARE MANUAL
THE INSTRUCTION MANUAL CONTAINS IMPORTANT INFORMATION
NECESSARY FOR THE PROPER ASSEMBLY AND SAFE USE OF THE APPLIANCE.
READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS BEFORE
ASSEMBLING AND USING THE APPLIANCE. FOLLOW ALL WARNINGS AND
7:30 AM to 3:30 P.M. CST • Monday through Friday
AND WARNINGS COULD RESULT IN FIRE, EXPLOSION, BURN HAZARD OR
CARBON MONOXIDE POISONING WHICH COULD CAUSE PROPERTY DAMAGE,
OUTDOOR COOKERS
9090, 9091 AND 4545
MODEL/SERIAL #
INSTRUCTIONS WHEN USING THE APPLIANCE.
KEEP THIS MANUAL FOR FUTURE REFERENCE.
METAL FUSION, INC.
712 St. George Avenue.
Jefferson, LA 70121
If you have any problems or questions
Call Us Toll Free at
1-800-783-3885
(504) 736-0201
www.kingkooker.com
FAILURE TO FOLLOW THESE INSTRUCTIONS
PERSONAL INJURY OR DEATH.
__________
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for King Kooker 9090
Summary of Contents for King Kooker 9090
- Page 1 English OUTDOOR COOKERS 9090, 9091 AND 4545 ASSEMBLY INSTRUCTIONS AND USE AND CARE MANUAL __________ MODEL/SERIAL # THE INSTRUCTION MANUAL CONTAINS IMPORTANT INFORMATION NECESSARY FOR THE PROPER ASSEMBLY AND SAFE USE OF THE APPLIANCE. READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS BEFORE ASSEMBLING AND USING THE APPLIANCE.
-
Page 2: Warnings
DANGER FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your Fire Department. FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN FIRE OR EXPLOSION WHICH COULD CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. - Page 3 READ AND UNDERSTAND BEFORE USING THIS PRODUCT Throughout this manual the words appliance, cooker, fryer/boiler, burner and stove will be used interchangeably to refer to the King Kooker Outdoor Cooker. ® This is an ATTENDED appliance. Do NOT leave this appliance unattended while the burner is lit or while heating oil, grease, water or cooking food.
-
Page 4: Warnings
Failure to follow these instructions and warnings could result in fire or explosion which could cause property damage, personal injury or death. 21) This appliance is not intended for commercial use. 22) Use King Kooker appliances only in accordance with state and local ordinances, ®... -
Page 5: Table Of Contents
READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE USING YOUR KING KOOKER ® PRODUCT TABLE OF CONTENTS Warnings ..................... . . 2-4 Table of Contents . -
Page 6: Warranty
METAL FUSION, INC. LIMITED ONE-YEAR WARRANTY WHAT THIS WARRANTY COVERS This warranty covers all components of this outdoor cooker to be free from defects in materials and workmanship, with the exceptions stated below. HOW LONG COVERAGE LASTS This warranty runs for one year from the date of purchase. Please keep your receipt with this manual for future reference. -
Page 7: Owners Registration
OWNER’S REGISTRATION Dear Customer, Thank you for purchasing a King Kooker ! Please take a moment to fill ® out your registration form and return it to us. We are always happy to hear suggestions and comments from our customers about our products. Completion of this registration allows us to contact you if the need arises. - Page 8 TAPE HERE FOLD ________________________ ________________________ Place Stamp ________________________ Here METAL FUSION, INC. 712 St. George Avenue Jefferson, LA 70121 FOLD...
-
Page 9: Section I - Outdoor Cooker Assembly
THE USE AND CARE MANUAL MUST BE READ AND UNDERSTOOD BEFORE USING THE APPLIANCE Throughout this manual the words appliance, cooker, fryer/boiler, burner and stove will be used interchangeably to refer to the King Kooker Outdoor Cooker. ® TOOLS REQUIRED: TORQUE WRENCH or ADJUSTABLE WRENCH, LEAK TESTING SOLUTION Before assembling, check that all cooker components are included in the shipping carton. -
Page 10: Assembly Instructions
ASSEMBLY INSTRUCTIONS * Models may vary from picture. 1. Remove unit from box and remove all packing materials between cooker frame and aluminum pot. All packaging materials must be removed before operation of the appliance. 2. Make sure the spigot drain valve is in the OFF/CLOSED position as pictured below. VALVE IN SPIGOT OFF/CLOSED... -
Page 11: Adjustable Lid Support Rod Instructions
ADJUSTABLE LID SUPPORT SYSTEM INSTRUCTIONS Your cooker includes an adjustable rod system that can be used to support the pot’s lid when opened. Food contents within the pot’s basket can be emptied onto the lid when supported by the support rod system and then distributed into food trays or containers. - Page 12 ANGLED LID POSITION FIGURE 2 FIGURE 3 LOWER “LOWER” “CENTER” LOWER TAB LOWER * Models may vary from picture * Models may vary from picture To install the adjustable lid support system in the angled position, remove the rods from the clamps. Rotate the “lower”...
-
Page 13: Operation Of Spigot Pot
OPERATION OF SPIGOT POT READ AND UNDERSTAND ALL INSTRUCTION BEFORE USING THIS PRODUCT. ALWAYS ALLOW COOKING LIQUID AND VALVE TO COOL BEFORE OPERATING SPIGOT (BELOW 100°F (38°C)). COOKING LIQUID CAN REMAIN DANGEROUSLY HOT HOURS AFTER USE. ALWAYS USE A THERMOMETER TO CHECK TEMPERATURE OF THE COOKING LIQUID BEFORE OPERATING THE SPIGOT. -
Page 14: 9091 - Steamer Tray Instructions
STEAMER TRAY INSTRUCTIONS (MODEL 9091 ONLY) The steamer tray provided in your package allows you to use your cooker as a steamer when as- sembled to your pot’s basket. Follow the below directions for proper assembly and use of the steam- er tray. -
Page 15: Section Ii - Use And Care
212°F(100°C). The temperature of hot oil should never be allowed to exceed 350°F(177°C). IMPORTANT: Oil can ignite at high temperatures. Most King Kooker ® thermometers have a Red Zone above 350°F(177°C) to signify Danger. Never allow the temperature to exceed 350°F(177°C). -
Page 16: Determining Proper Fill Levels For Cooking Vessels
This is the amount of cooking liquid the vessel is to be filled with to cook the food product. LP GAS CYLINDER INFORMATION King Kooker ® Outdoor Cookers are manufactured for use with 20lb. (9 kg) LP Gas Cylinders. Important information to remember about LP Gas cylinders include: Always read and follow the cylinder manufacturer’s instructions. -
Page 17: Connection Instructions
CONNECTION INSTRUCTIONS Check that your hose assembly valve is set to not allow gas flow. Turn the regulator control counterclockwise until it stops. This is the OFF position. Attach the regulator to the cylinder valve by turning the Type 1 fitting clockwise. Hand tighten with the regulator positioned upright. -
Page 18: Placement Instructions
PLACEMENT INSTRUCTIONS 1. Never operate this appliance within 10ft. (3.05m) of any structure, combustible material or other gas cylinder. Never operate this appliance within 25ft. (7.5m) of any flammable liquids or vapors 2. There must be no combustibles or roof overhead. 3. -
Page 19: Lighting And Operating Instructions
LIGHTING AND OPERATING INSTRUCTIONS THE COOKER MUST NOT BE LIT UNTIL THE PRECEDING PLACEMENT INSTRUCTIONS HAVE BEEN COMPLETELY FOLLOWED. Pot must be installed onto cooker frame and filled with water before lighting appliance. The lid support rod must be in straight or angled position before lighting appliance. Make certain that the regulator control is turned to OFF by turning it counterclockwise until it reaches the stop. -
Page 20: Turning Off And Storing The Cooker After Use
C)]. ® After each use turn OFF the King Kooker at the regulator first, then at the gas cylinder valve. Check to make sure there is no flame and all valves are off. Do not leave the cooker until it has cooled completely. -
Page 21: Caring For Aluminum Cookware
TIPS FOR CARING FOR ALUMINUM FRY PANS AND BOILING POTS It is not necessary to season aluminum pots before cooking with them. Wash with a liquid dish washing detergent and towel dry. After cooking, wash aluminum pots and fry pans in hot, sudsy detergent. If grease or black soot has cooked to the outside of the pot while cooking with your outdoor cooker, scrub the outside of the pot with a steel wool scouring pad. -
Page 22: Section Iii - Recipes
Add seafood. Gently stir. Cover the pot and return to boil. Boil crawfish for 5 minutes. Cut off the fire. Gently stir the seafood again and let it soak. Add two 8 ounce King Kooker ® Liquid Crab Boil. Let the crawfish soak for 15 - 20 minutes. -
Page 23: Section Iv - Frequently Asked Questions And Answers
SECTION IV READ AND UNDERSTAND ALL INSTRUCTIONS BEFORE USING YOUR KING KOOKER ® PRODUCT FREQUENTLY ASKED QUESTIONS AND ANSWERS What is the problem if the cooker takes too long or will not heat oil or cooking ingredients to desired temperature? My cooker’s flame appearance is very weak. - Page 24 KING GRILLERDINE ® , KING KOOKER ® , the KING KOOKER ® logo, THE KING ® THE KING OF OUTDOOR COOKING ® , MR. OUTDOORS ®...
Need help?
Do you have a question about the 9090 and is the answer not in the manual?
Questions and answers