Related Manuals for Minuteman Ambassador Junior C45014-01
Summary of Contents for Minuteman Ambassador Junior C45014-01
- Page 1 OPERATION SERVICE PARTS CARE Ambassador Junior Model: C45014-01 (115V) C45014-02 (230V) 985808 Rev. B 11/16...
-
Page 2: Important Safety Instructions
FOR COMMERCIAL USE ONLY IMPORTANT SAFETY INSTRUCTIONS When using an electrical appliance, basic precautions should always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING WARNING - To reduce the risk of fi re, electric shock, or injury: • Do not leave appliance when plugged in. Unplug from outlet when not in use and before ser- vicing. -
Page 3: Table Of Contents
Table of Contents IMPORTANT SAFETY INSTRUCTIONS ......2 INSPECTION ........... 4 ELECTRICAL . -
Page 4: Inspection
INSPECTION Carefully unpack and inspect your machine for shipping damage. Each unit is tested and thoroughly inspected before shipment, and any damage is the responsibility of the delivery carrier who should be notifi ed immediately. ELECTRICAL 115V This machine is designed to operate on a standard 15 amp. 115 volt, 60 hz, AC circuit. Volt- ages below 105 volts AC or above 125 volts AC could cause serious damage to the motor. -
Page 5: Danger
DANGER Improper connection of the equipment-grounding conductor can result in a risk of electric shock. Check with a qualifi ed electrician or service person if you are in doubt as to whether the outlet is properly grounded. Do not modify the plug provided with the appliance — if it will not fi t the outlet, have a proper outlet installed by a qualifi... -
Page 6: Monthly/Bi-Monthly Maintenance
fl ow to the pump and spray jets. Carpet should be thoroughly vacuumed and obstacles relocated before beginning the cleaning cycle. Heavy traffi c lane areas should be pre-treated or spotted with Minuteman Pre-Treat order #902183 for best results. -
Page 7: Auxiliary Tool Hook Up
3. The vacuum lid assembly should be properly seated on the recovery tank for proper vacuum recovery. 4. See Control Panel section for switch identifi cations: Normal Cleaning Mode: 1. Turn on vacuum switch (1). 2. Turn on brush switch (2). 3. -
Page 8: Control Panels
CONTROL PANELS 1. Vacuum switch 2. Brush switch 3. Pump spray switch, continuous operation position. Pump supplies solution to spray bar for cleaning in large open areas. 4. Center position is “off ”. 5. Momentary position is for intermittent spray for cleaning in smaller more confi ned areas. When released, switch will return to center off... - Page 9 1. Waste Water Recovery Hose (Grey hose cuff to grey fi tting) 2. Recovery Waste Water Diff user 3. Vac Hose White Cuff (White hose cuff to white fi tting) 4. Vac Filter Screen Ambassador Jr. Page 9...
-
Page 10: Exploded Views
EXPLODED VIEWS TOP MAIN ASSEMBLY Ambassador Jr. Page 10... - Page 11 TOP MAIN ASSEMBLY BOM BILL OF MATERIAL ITEM PART NO. DESCRIPTION 130118 SOLUTION STRAINER M3-40 150004 RELIEF STRAIN HEYCO 3251 450043 DASHBOARD 450044 MOLDED RECOVERY DOME GASKET 450050 BUSHING HEYCO .875 X .875 X 1. 450057 HOSE 3/8 ID X 20.5 450059 FITTING BRASS 1/4 MPT 1/4 MPT 450062...
-
Page 12: Back Panel Assembly
BACK PANEL ASSEMBLY Ambassador Jr. Page 12... - Page 13 BACK PANEL ASSEMBLY BOM BILL OF MATERIAL ITEM PART NO. DESCRIPTION 169125 FILTER 1.44 X 3.5 X 3 381052 CLAMP PLASTIC 3/8 ID 410-4419AA RIVET POP 450012 CORD STRAIN RELIEF 450036 COVER TOP AMB 17 450050 BUSHING HEYCO .875 X .875 X 1. 450053 VAC HOSE ASSY.
-
Page 14: Bottom Main Assembly
BOTTOM MAIN ASSEMBLY Ambassador Jr. Page 14... - Page 15 BOTTOM MAIN ASSEMBLY BOM (PG 1 OF 2) BILL OF MATERIAL ITEM PART NO. DESCRIPTION 250038 RETAINER, BAG CLIP 380001 VAC MOTOR 6336-00 120V (115V MODEL) 740244 MOTOR-VAC 240V (230V MODEL) 380028 CARBON BRUSH REPLACEMENT 381020 CORD 16GA-3 50FT MED GREY (115V MODEL) 740600 CORD, EUROPEAN 1.5MM 50FT GREY (230V MODEL) 450019...
- Page 16 BOTTOM MAIN ASSEMBLY BOM (PG 2 OF 2) BILL OF MATERIAL ITEM PART NO. DESCRIPTION 711420 NUT-HEX JAM 5/16-18 ST PL 711427 NUT-FLANGED WIZZ 10-32 711503 WSR-FLAT #10 711506 WSR-FLAT (NARROW) 5/16 ST PL 711523 WSR-WAVE .37 X .68 X .08 711524 WSR-WAVE .52 X .87 X .01 711544...
-
Page 17: Wiring Diagrams
WIRING DIAGRAMS 115V Page 17... -
Page 18: 230V
230V Page 18... -
Page 19: Recommended Carpet Care Chemicals
RECOMMENDED CARPET CARE CHEMICALS and REPLACEMENT PARTS Part No. Description 828924 Hose Assembly 831255 Scrub Wand 390070 Stair & Upholstery Tool Ambassador Jr. Page 19... -
Page 20: Warranty
WARRANTY... - Page 22 “Excellence Meets Clean” Minuteman is a Full Line Manufacturer of Sweepers and Scrubbers, for Industrial Facilities. 14N845 U.S. Route 20, Pingree Grove, IL 60140 USA Phone (800) 323-9420 - www.minutemanintl.com A Member of the Hako Group Ambassador Jr 985808 Rev B 11/16...