Table of Contents
Advertisement
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
Lifting the Vehicle
Tool List
Floor Jack.................................................................... 1
Wheel Chocks ............................................................. 4
To raise the entire vehicle, install chocks in front and behind each front wheel. Center
the jack under the rear frame crossmember. Raise the vehicle enough to place a jack
stand under the outer ends of the rear axle.
Lower the jack and test the stability of the vehicle on the two jack stands.
Place the jack at the center of the front axle. Raise the vehicle enough to place jack
stands under the frame crossmember as indicated.
Lower the jack and test the stability of the vehicle on all four jack stands.
If only the front or rear of the vehicle is to be raised, place the chocks in front and
behind each wheel not being raised to stabilize the vehicle.
Lower the vehicle by reversing the lifting sequence.
WHEELS AND TIRES
A tire explosion can cause severe injury or death. Never exceed the inflation pressure rating on
To reduce the possibility of tire explosion, pressurize tire with small amounts of air applied inter-
mittently to seat beads. Due to the low volume of the small tires, overinflation can occur in sec-
onds. Never exceed the tire manufacturer's recommendation when seating a bead. Protect face
To reduce the possibility of severe injury caused by a broken socket when removing wheels, use
DO NOT use low inflation tires on any E-Z-GO or Cushman vehicle. DO NOT use any tire which
has a recommended inflation pressure less than the inflation pressure recommended in the
Use caution when inflating tires. Overinflation could cause the tire to separate from the wheel or
cause the tire to explode, either of which could cause severe injury.
the tire sidewall.
and eyes from escaping air when removing a valve core.
only sockets designed for impact wrench use.
Qty.
Tool List
Jack Stands................................................................. 4
Flat Portion
of Frame
Outside End
of Rear Axle
View from Underside of Vehicle
owner's guide.
Owner's Guide
MAINTENANCE
Center of
Front Axle
B
Qty.
en-41
Advertisement
Table of Contents
