General Repairs/Service - Titan Epic 660HPX Owner's Manual

Epic 660HPX
General Repair & Service Notes:
WARNING: Before proceeding, follow the Pressure
Relief Procedure outlined on Page 5. Additionally,
follow all other warnings to reduce the risk of an
injection injury, injury from moving parts or electric
shock. Always unplug the sprayer before servicing!
The following tools are needed when repairing this
sprayer:
Phillips Screwdriver
Needle Nose Pliers
Adjustable Wrench
Rubber Mallet
Flat-blade Screwdriver
1/2" Open End Wrench
1. Before repairing any part of the sprayer, read the
instructions carefully, including all warnings.
2. When disconnecting wires, use needle nose pliers to
separate mating connectors.
Electrical Box
Motor
Figure 1
3/8"Allen Wrench
5/16" Allen Wrench
1/4" Allen Wrench
3/16" Allen Wrench
1/8" Allen Wrench
120V Pump Only - 702-405
230V Pump Only - 702-102-CE
Syphon Tube
Bypass Valve
NOTE: A Repacking Kit (730-401) is available. All parts included
in the kits are listed in the parts list chart on page 24. For best
results use all parts supplied in the Repacking Kit.
CAUTION: Never pull on a wire to disconnect it.
Pulling on a wire could loosen the connector from the
wire.
3. Test your repair before regular operation of the sprayer
to be sure that the problem is corrected. If the sprayer
does not operate properly, review the repair procedure to
determine if everything was done correctly. Refer to the
Troubleshooting Charts to help identify other possible
problems.
4. Make certain that the service area is well ventilated in
case solvents are used during cleaning. Always wear
protective eyewear while servicing. Additional protective
equipment may be required depending on the type of
cleaning solvent. Always contact the supplier of solvents
for recommendations.
5. If you have any further questions concerning your
TITAN Airless Sprayer, call TITAN:
Customer Service Department Tel.1-800-526-5362
3
120V Complete -
230V Complete -
Pressure Control
Return Hose
Paint Filter
Add P.S.L. here
(Piston Seal Lubricant)
Fluid Section
Outlet Fitting
Outside the U.S. Call 1-201-405-7520
Canada Tel 1-800-565-8665
702-410
702-104-CE
Fax 1-800-528-4826
Fax 1-201-405-7449
Fax 1-905-856-8496