Table of Contents
Advertisement
Quick Links
LP GAS COMMERCIAL
#554C3H830 LP, #554C3H830DELLP, #554C3H860 LP, #554C3H860DELLP
WARNING
DANGER:
DO NOT use gas grill for indoor cooking or heating.
TOXIC fumes can accumulate and cause asphyxiation.
Do not use in or on boats or recreational vehicles.
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE. IF YOU
ARE ASSEMBLING THIS UNIT FOR SOMEONE ELSE, GIVE THIS
MANUAL TO HIM OR HER TO SAVE FOR FUTURE REFERENCE.
OUTDOOR GRILL
USER MANUAL
WARNING:
Improper installation, adjustment, alteration, service, or
maintenance could cause injury or property damage. Read
the installation, operation, and maintenance instructions
thoroughly.
Failure to follow these instructions could result in fire or
explosion that could cause property damage, personal injury
or death.
PROP 65 WARNING:
Chemicals known the the state of California to cause cancer,
birth defects or other reproductive harm are created by the
combustible propane.
03/2016
1
Advertisement
Table of Contents
Related Manuals for Backyard Pro 554C3H830 LP
Summary of Contents for Backyard Pro 554C3H830 LP
- Page 1 LP GAS COMMERCIAL OUTDOOR GRILL USER MANUAL #554C3H830 LP, #554C3H830DELLP, #554C3H860 LP, #554C3H860DELLP 03/2016 WARNING: WARNING Improper installation, adjustment, alteration, service, or maintenance could cause injury or property damage. Read the installation, operation, and maintenance instructions thoroughly. DANGER: DO NOT use gas grill for indoor cooking or heating.
-
Page 3: Warning For Your Safety
Warnings DANGER IF YOU SMELL GAS: Shut off gas to the appliance. Extinguish any open flame. Open lid. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. WARNING 1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. -
Page 4: For Your Safety
Warnings FOR YOUR SAFETY NOTE: The use and installation of this product must conform to local codes. In absence of local codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2. IMPORTANT NOTICE: Read all instructions prior to assembly and use. - Page 5 Warnings WARNING: 1. This grill is for outside use only, and should not be used in a building, garage or any other enclosed area. 2. The use of alcohol, prescription or non-prescription drugs may impair the operator’s ability to properly assemble or safely operate the grill. 3.
- Page 6 General Information and Instructions Your new Backyard Pro Grill has been designed and manufactured to high quality standards. It will provide you with many years of enjoyment with a minimal amount of maintenance. Please keep in mind the following FOR YOUR SAFETY.
-
Page 7: Cylinder Specifications
General Information and Instructions CYLINDER SPECIFICATIONS When purchasing or exchanging a cylinder for your gas grill, it must be constructed and marked in accordance with the specifications for LP gas cylinders of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339 Cylinders, Spheres and Tubes for Transportation of Dangerous Goods;... - Page 8 General Information and Instructions LP CYLINDER LEAK TEST A leak test should be done each time a cylinder is refilled or exchanged. Do not smoke or use any type of flammable material in the area during this leak test. Do not use an open flame to check for leaks. 1.
- Page 9 General Information and Instructions WARNING: 1. Do not connect this grill to any unregulated sources of propane. 2. Before each use, check the gas hose for excessive abrasion or wear, or cuts. Replace a hose assembly showing those signs with the hose assembly specified in the parts list before using the grill.
- Page 10 General Information and Instructions WARNING: 1. DO NOT USE THE GRILL if you cannot stop the leaks. Be sure the LP cylinder valve is closed. If the LP cylinder is still leaking, contact your LP dealer or local fire department. 2.
- Page 11 General Information and Instructions LIGHTING Always visually inspect your grill before lighting. Replace any hoses that are frayed or cracked before lighting your grill. Look for anything that may be blocking spaces for ventilation and remove. After lighting, always check the flame to ensure you have a good flame all along each burner. If not able to light, or the flame is not even along the entire burner(s), then see the Trouble Shooting section.
-
Page 12: Cleaning Your Grill
General Information and Instructions CLEANING YOUR GRILL WARNING: 1. Do not clean any part of your barbecue grill in a self-cleaning oven. 2. Do not use oven cleaners, abrasive kitchen cleaners, cleaners that contain citrus products, or mineral spirits. 3. Do not use any type of steel bristled brush. 4. -
Page 13: Cleaning The Burners
General Information and Instructions CLEANING THE BURNERS 1. Ensure the LP gas is turned off at the LP cylinder. 2. Remove the cooking grates, flame tamer, and grease tray. 3. Remove the cotter pins located underneath the back end of each burner. 4. - Page 14 Grilling with Your New Grill GRILLING WITH YOUR NEW GRILL Welcome to the world of grilling. Whether you’re already an established griller, or just starting out, your new grill should bring you much enjoyment and satisfaction, to say nothing of some phenomenal meals.
- Page 15 Grilling with Your New Grill GRILLING TIPS AND TRICKS 1. Always “Preheat” your grill before cooking. Light all main burners, turn to “HI”, and close the lid until the thermometer reads over 500°F (260°C), which should be 4 minutes. Then adjust the burner control knobs to the proper temperature.
-
Page 16: Troubleshooting Guide
Trouble Shooting Guide TROUBLE SHOOTING GUIDE BURNER WILL NOT LIGHT 1. Gas supply is turned off. Turn on gas at LP tank. 2. Out of propane. Check to be sure you still have propane in your tank. 3. Regulator is not properly seated into the tank valve. Remove and reattach. Hand tighten only. 4. -
Page 17: Frequently Asked Questions
Frequently Asked Questions FREQUENTLY ASKED QUESTIONS Can I convert my gas grill from one fuel source to another? No. Your gas grill is manufactured to specific standards developed by CSA and ANSI for your safety and grilling performance for either LP or Natural Gas. We do not offer conversion kits nor do we recommend you change the fuel type.