Wayne-Dalton 8000 Quick Start Manual
  1. Manuals
  2. Brands
  3. Wayne-Dalton Manuals
  4. Garage Door Opener
  5. 8000 Series
  6. Quick start manual

Wayne-Dalton 8000 Quick Start Manual

Extension residential standard lift
Hide thumbs Also See for 8000:
Table of Contents

Advertisement

Quick Links

See also: Installation Instructions & Owner's Manual
Models 8000 / 8100
/ 8200
E
x t E n s i o n
r
EsidEntial
s
l
tandard
ift
Q
s
G
uick
tart
uidE
PLEASE DO NOT RETURN THIS PRODUCT
TO THE STORE
If you need assistance, please call 1-866-
569-3799 (press Option 1) and follow the
prompts to contact a customer service
representative. They will be happy to handle
any questions that you may have.
©Copyright 2018
Wayne Dalton, a division of Overhead Door Corporation
T a b l e O f C o n t e n t s
QUICK START GUIDE IMPORTANT NOTICES!
This Quick Start Guide is only meant to be used as an aid and
/ or introduction to garage door installation, and does not replace the
complete Installation Instructions and Owner's manual available on the
web at www.Wayne-Dalton.com. Wayne Dalton highly recommends
that you read and fully understand the Installation Instructions and
Owner's Manual before you attempt this installation.
To avoid possible injury, read and fully understand the enclosed
instructions carefully before installing and operating the garage door. Pay
close attention to all warnings and notes. After installation is complete,
fasten this manual near garage door for easy reference.
The complete Installation Instructions and Owner's Manual are available at no
charge from:
- Your local Wayne Dalton Sales Center, or
- Online at www.Wayne-Dalton.com, or
- By mailing to: Wayne Dalton, a division of Overhead Door Corporation, P.O. Box
67, Mt. Hope, OH., 44660
Part Number
356246
2
2
2
3
4
6
8
8
8
8
8
9
REV5_03/13/2018

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 8000 and is the answer not in the manual?

Questions and answers

Related Manuals for Wayne-Dalton 8000

Summary of Contents for Wayne-Dalton 8000

  • Page 1: Table Of Contents

    If you need assistance, please call 1-866- complete Installation Instructions and Owner’s manual available on the web at www.Wayne-Dalton.com. Wayne Dalton highly recommends 569-3799 (press Option 1) and follow the that you read and fully understand the Installation Instructions and prompts to contact a customer service Owner’s Manual before you attempt this installation.

  • Page 2: Pre-Installation

    Existing Door & Prepar- 12. On electrically operated doors, pull down ropes must be removed and locks must be ing the Opening. These are available for download at www.Wayne-Dalton.com or at your removed or made inoperative in the open (unlocked) position.

  • Page 3: Breakdown Of Parts

    BREAKDOWN OF PARTS NOTE: The illustrations shown on this page are general representations of the door parts. Each specific door models may have unique variations. J10. J10. A. FLAG ANGLES (AS REQUIRED): I3. Left Hand Vertical Track A1. Fully Adjustable (F.A.) Flag Angles I4.

  • Page 4: Door Installation Instructions

    Hand tighten the left hand flag angle to the left hand vertical track using (2) 1/4” - 20 x 5/8” carriage bolts and (2) 1/4” - 20 flange hex nuts. Strutting Schedule For Models 8000 and 8100 NOTE: The bottom jamb bracket is always the shortest bracket, while the center jamb...
  • Page 5 NOTE: Depending on your door, you may have two different kinds of Step Plates or two of the SHIMMED SIDE MUST BE RAISED THE HEIGHT OF THE SHIM. same kind of Step Plates. Refer to Package Contents, to determine which Step Plates you NOTE: Make sure the counterbalance lift cable is located between the track rollers and the have.

  • Page 6: Counterbalance Installation Instructions

    COUNTERBALANCE INSTALLATION INSTRUCTIONS Perforated angle bolted using (2) 5/16” x 2” hex Attaching Rear Back Hangs head lag screws to ceiling member and parallel to door Raise the door until the top section and half of the next section are in the horizontal track radius.
  • Page 7 IMPORTANT: CLOSE “S” HOOKS AND EYE BOLTS WITH LOCKING PLIERS, TO PREVENT NOTE: This illustration shows the outside of the door in the open position. SPRINGS FROM COMING LOOSE. WARNING Track roller FAILURE TO CLOSE “S” HOOKS AND EYE BOLTS CAN RESULT IN SEVER Locking OR FATAL INJURY IF SPRINGS COME LOOSE.

  • Page 8: Maintenance

    Installation Instructions and Owner’s Manual for the garage door. These instructions are available at no charge from Wayne Dalton, a division of Overhead Door Corporation, P.O. Box 67, Mt. Hope, OH., 44660, or at www.Wayne-Dalton.com. For additional information on garage door/operator maintenance go to www.dasma.com and reference TDS 151, 167 and 179.

  • Page 9: Warranty

    Models 8000, 8100, 8200 Wayne Dalton, a division of Overhead Door Corporation ("Seller") war- rants to the original purchaser of the Models 8000, 8100, 8200 (“Product”), subject to all of the terms and conditions hereof, that the Product and all...
  • Page 10 Thank you for your purchase. PLEASE DO NOT RETURN THIS PRODUCT TO THE STORE If you need assistance, please call 1-866-569-3799 (press Option 1) and follow the prompts to contact a customer service representative. They will be happy to handle any questions that you may have.

This manual is also suitable for:

81008200

Table of Contents