Maintenance - MQ Power DCA25SSIU4F Operation Manual

Table 14. Inspection/Maintenance
Check Engine Oil and Coolant Levels
Check Fuel Filter/Water Separator Bowl
Check Air Cleaner
Check Air Cleaner Element
Check for Leaks/Hoses/Clamps
Check for Loosening of Parts
Change Engine Oil and Oil Filter *
Clean Unit, Inside and Outside
Replace Fuel Filter Elements
Check Engine Mounts
Service Battery
Check Air Intake Hoses
Engine
Check Fan Belt Condition
Check Automatic Belt Tensioner
Check Electrical Ground Connection
Clean Radiator, Check Cooling System
Coolant Solution Analysis, Add SCA's As Required
Pressure Test Cooling System
Check Engine Speed
Test Thermostats
Test Glow Plugs
Flush and Refill Cooling System
Clean Inside of Fuel Tank
Replace Air Cleaner Elements *
Measure Insulation Resistance Over 3M ohms
Generator
Check Rotor Rear Support Bearing
* During initial operation of a new engine, change oil and filter between a minimum of 100 hrs. and a maximum of 250 hrs. Service interval depends
1
on type of oil.
* Replace primary air filter element when restriction indicator shows a vacuum of 625 mm (25 in. H
2
PAGE 34 — DCA25SSIU4F 60 HZ GENERATOR • OPERATION MANUAL — REV. #4 (01/17/18)
10 Hrs
DAILY
X
X
X
X
X
X
1
2
500 Hrs
250 Hrs or Every
12 Months
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
0).
2

MAINTENANCE

3000 Hrs
or Every OTHER
36 Months
X
X
2 yrs. or 2000 hrs.
1000 hrs.
As Required