Daikin RDT Installation And Maintenance Manual page 150

Warranty Registration Form (continued)
VI . GAS BURNER CHECK, TEST, & START
Specifications:
Refer to IM 684 Modulating Forced Draft Gas Fired Furnace and IM 685 SuperMod Forced Draft Gas Fired Furnace
A. (Gas) Furnace model no. _____________________
B. (Gas) Burner model no. _____________________
C. (Gas) Type firing:
D. (Gas) Rated firing rate: _________________ MBH input
E. (Gas) Altitude:______________________ ft. above sea level
F. Is there a circulating tank? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
VII . GAS BURNER CHECK, TEST, & START
A. Input:________________________________ CFH
B. Gas pressure at burner: ________________inches w.c.
C. CO : __________________________ %
2
D. CO : __________________________ %
2
E. Pilot flame only: ______________ microamps (steady at low fire)
F. Pilot Tap-gas pressure: _________________inches w.c.
G. Motor only/burner: FLA __________________ running amps
H. High limit control OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
I. Flame safeguard: ________________ microamps
J. Flame failure shutoff: _______________ seconds
K. Airswitch OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
L. High Gas Pressure Switch OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
M. Low Gas Pressure Switch OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
N. Main Gas Valve Close-off OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
VIII . Design Flow Calibration
A. Verify power is supplied to the MicroTech III unit controller. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
B. Verify that the shipping screws have been removed from the measuring station vane. . . . . . . . . . . . . . . . . . . . . . . . . . Yes
C. Examine station for shipping damage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
D. Refer to IM 893 or IM 987 for Design Flow Setup Procedure and Calibration Procedure . . . . . . . . . . . . . . . . . . . . . . .
E. Record Level Positions after final calibration.
LH Level Position:
RH Level Position:
Note: This is viewed in the MicroTech III Controller, in the Min OA setup menu.
.
IX Have all electronic or electrical controls been checked, adjusted, and tested for proper operation per the
installation and maintenance bulletins?
X . MAINTAINING MICROTECH CONTROL PARAMETER RECORDS
After the unit is checked, tested, and started and the final control parameters are set, record the final settings. Keep these records on file and
update whenever changes to the control parameters are made. Keeping a record facilitates any required analysis and troubleshooting of the
system operation and facilitates restoration after a controller replacement.
Signature: ______________________________________________________
RETURN COMPLETED FORM TO:
Daikin Warranty Department, 13600 Industrial Park Boulevard, Minneapolis, MN 55441
Please list any additional comments that could affect the operation of this unit; e.g., shipping damage, failed components, adverse installation
applications, etc., on a separate sheet and attach to this form.
Daikin IM 893-4
IM 893-10 • ROOFPAK SINGLEZONE UNITS
Rooftop Equipment Warranty Regist . Form
Serial no. ___________________
_________ Single _________Stage 2 _________Stage Modulation
______________
______________
r e
oofToP quIPMenT
Startup date:____________________________________
150
W r
arranTy egIsTraTIon
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
Yes No N/A
127
www.DaikinApplied.com
f
orM