Advertisement
INSTRUCTION MANUAL
INTENDED USE
Your Black & Decker battery charger is designed to
charge lead-acid batteries. This product is intended for
household, consumer use only.
SAFETY INSTRUCTIONS
IMPORTANT SPECIFICATION NOTE: Battery
capacity: lead acid type, maximum 12VDC, 360Ah.
Warning! When using appliances, basic safety
precautions, including the following, should always be
followed to reduce the risk of fire, leaking batteries,
personal injury and material damage.
• Read all of this manual carefully before using the
appliance.
• The intended use is described in this manual.
The use of any accessory or attachment or the
performance of any operation with this appliance
other than those recommended in this instruction
manual may present a risk of personal injury.
• Retain this manual for future reference.
Using your appliance
Always take care when using the appliance.
• This appliance is not intended for use by persons
(including children) with reduced physical, sensory
or mental capabilities, or lack of experience and
knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a
person responsible for their safety.
• The appliance is not to be used as a toy.
• Use in a dry location only. Do not allow the appliance
to become wet.
• Do not immerse the appliance in water.
• Do not open body casing. There are no user-
serviceable parts inside.
• Do not operate the appliance in explosive
atmospheres, such as in the presence of flammable
liquids, gases or dust.
• To reduce the risk of damage to plugs and cords
never pull the cable to remove the plug from a
socket outlet.
After use
• When not in use, the appliance should be stored in a
dry, well ventilated place out of the reach of children.
• Children should not have access to stored
appliances.
• When the appliance is stored or transported in a
vehicle it should be placed in the boot or restrained
to prevent movement following sudden changes in
speed or direction.
• The appliance should be protected from direct
sunlight, heat and moisture.
BC20BDAU_Manual_091216.indd 4-5
Inspection and repairs
• Before use, check the appliance for damaged or
defective parts. Check for breakage of parts, damage
to switches and any other conditions that may affect
its operation.
• Do not use the appliance if any part is damaged or
defective.
• Have any damaged or defective parts repaired or
replaced by the manufacturer.
• Never attempt to remove or replace any parts other
than those specified in this manual.
Power cord safety
Warning! Never alter the mains cord or plug. If it will
not fit, have a proper outlet installed by a qualified
electrician. Improper connection may result in an
electric shock.
The following symbols are marked on
the appliance:
This tool is double insulated; therefore
no earth wire is required. Always check
that the power supply corresponds to
the voltage on the rating plate.
Read all of this instruction manual
carefully.
This appliance is intended for indoor
use only.
Electrical safety
Always check that the power supply corresponds to
the voltage on the rating plate.
• The supply cord cannot be replaced. If the cord is
damaged the appliance should be scrapped.
Specific safety instructions for battery
chargers
• Charge only lead-acid type (GEL, WET, AGM)
rechargeable batteries.
• Never attempt to charge non-rechargeable batteries.
• Have defective cords replaced immediately.
• Do not expose the battery charger to water.
• Do not open the battery charger.
• Do not probe the battery charger.
• Never allow the red and black clamps to touch each
other or another common metal conductor. This
could cause damage to the appliance and/or create a
spark/explosion hazard.
BATTERIES
Warning! Never attempt to charge a frozen battery.
• Under extreme conditions, battery leakage may
occur. When you notice liquid on the batteries,
carefully wipe the liquid off using a cloth. Avoid skin
contact.
4
• In case of skin or eye contact, follow the instructions
below.
– Warning! Battery fluid is a diluted sulphuric acid
and may cause personal injury or damage to
property. In case of skin contact, immediately rinse
with water. If redness, pain or irritation occurs seek
medical attention. In case of eye contact, rinse
immediately with clean water and seek immediate
medical attention.
• When disposing of batteries, follow the instructions
given in the section "Protecting the environment".
• Add distilled water in each cell until the battery
acid reaches the level specified by the battery
manufacturer. This helps to purge excess gas from
the cells. Do not overfill. For a battery without
cell caps (maintenance free), carefully follow the
manufacturer's charging instructions.
• Study all the battery manufacturer's specific
precautions, such as removing or not removing cell
caps while charging, and the recommended charging
rates.
• Make sure that the initial charging rate does not
exceed the battery manufacturer's requirement.
• Warning! Risk of explosive gas mixtures. Working
in the vicinity of a lead-acid battery is dangerous.
Batteries generate explosive gases during normal
battery operation. For this reason, it is of utmost
importance that each time, before using your
battery charger, you read this manual and follow the
instructions exactly.
• Use of an attachment not recommended or sold by
Black & Decker may result in a risk of fire, electric
shock, or injury to persons.
• An extension cord should not be used unless
absolutely necessary. Use of an improper extension
cord could result in a risk of fire and electric shock,
and will void the warranty.
PERSONAL SAFETY
Wear complete eye protection and suitable clothing to
give protection from contact with battery fluid.
Avoid touching the eyes while working with a battery.
Acid, acid particles or corrosion may get into the eyes.
Remove personal metal items such as rings, bracelets,
necklaces and watches when working with a lead-acid
battery. A lead-acid battery can produce a short circuit
current high enough to cause a severe burn.
Be extra cautious to reduce the risk of dropping a
metal object onto the battery. This might cause sparks
or short-circuit the battery or other electrical part,
which can cause an explosion.
LCD – Liquid Crystal Display
If any liquid crystal comes in contact with your skin:
Wash area thoroughly with plenty of water. Remove
contaminated clothing.
If liquid crystal gets into your eye: Flush the affected
eye with clean water and then seek medical attention.
If liquid crystal is swallowed: Flush your mouth
thoroughly with water. Drink large quantities of water
and induce vomiting. Seek medical attention.
FEATURES
1. Positive (red) clamp
2. Engine start button
3. Alternator check button
4. Battery charge button
5. LCD screen
5a. Digital display (varies by function)
5b. Amperes/ voltage/ seconds indicator
5c. Battery recondition indicator
5d. Battery charge gauge
5e. Clamp icons
5f. Fault icon
5g. Battery reconditioning icons
5h. Arrow icons
5i.
Battery icon
5j.
Alternator icon
5k. Low surrounding temperature icon
5l.
Overheat alarm icon
5m. Engine start icon
5n. High surrounding temperature icon
6. Battery voltage check button
7. Battery recondition button
8. Negative (black) clamp
9. Mains cord storage compartment
PREPARATION BEFORE CHARGING
The appliance must only be connected to a 12V
lead-acid battery. Before charging, confirm that
the voltage of the battery is 12V by referring to
the label on the battery or from the information
available relating to its application e.g. car user
manual.
Do not use the appliance for charging dry-cell batteries
that are commonly used with home appliances. These
batteries may burst and cause injury to persons and
damage to property.
Warning! Explosive gas may be vented from lead
acid batteries when charging. The battery must be
placed in a well-ventilated area and you must remove
any sources of ignition when conducting charging
procedures.
• Never place the battery charger directly above the
battery; gases from the battery will corrode and
damage the battery charger.
• Never allow battery acid to drip on the battery
charger.
5
9/12/2016 11:45:36 AM
Advertisement
