Page 1
OPERATION AND PARTS MANUAL MODEL V305EH VIBRATORY ROLLER (HONDA GX340UT2QAE2 GASOLINE ENGINE) Revision #1 (06/21/16) To find the latest revision of this publication, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
All orders are treated as Standard Orders and will ship the same day if received prior to 3PM PST. WE ACCEPT ALL MAJOR CREDIT CARDS! V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 5...
Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY. NOTICE Pressurized fluid hazards Addresses practices not related to personal injury. Electric shock hazards Runover hazards PAGE 6 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 7
ALWAYS clear the work area of any debris, tools, etc. that would constitute a hazard while the equipment is in operation. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 7...
Page 8
ALWAYS keep the machine in proper running condition. Always turn the engine off before performing maintenance. Fix damage to machine and replace any broken parts immediately. PAGE 8 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 9
DO NOT fi ll the fuel tank while the engine is running plenty of water. or hot. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 9...
Page 10
ALWAYS make sure that roller is secured correctly when transporting on a trailer. Make sure all supports attaching the roller to the trailer are tight. PAGE 10 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
29.0 in. (736.6 mm.) 35.0 in. (889 mm.) 88.5 in. (2,248 mm.) 86.5 in. (2,197 mm.) 47 in. (1,193.8 mm.) 46.25 in. (1,175 mm.) 82.5 in. (2,095.5 mm.) V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 13...
A 7 gallon (26.5 liters) water tank with a gravity feed spray bar is provided for wetting the roll for asphaltic pavement rolling. The delivery system is controlled by a mechanical Figure 2. Lifting the Roller PAGE 14 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Figure 3. Recommended Slope NEVER operate the roller on side slopes. The roller may tip over causing injury to personnel and severe damage to the equipment. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 15...
This water tank is made of plastic to prevent rust, and holds 7 gallons (26.5 liters) of water. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 17...
Page 18
In normal operating outlined in the maintenance section of this manual. conditions this lever should be left in the engaged position (forward). PAGE 18 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
9. Muffler — Used to reduce noise and emissions. the engine is dry. 10. Fuel Tank — Holds unleaded gasoline. For additional information refer to engine owner's manual. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 19...
2. Visually inspect to see if the fuel level is low. If fuel is Winter 0°C or Lower SAE 10W-10 low, replenish with unleaded gasoline using a strainer PAGE 20 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 21
The deflection of the travel belt should HYDRAULIC OIL LEVEL COLD be approximately 1/2 of an inch (1.27 cm). Figure 13. Hydraulic Reservoir Filler Port V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 21...
2. Once released pin has been removed, position handle bar to desired height (Figure 16 and Figure 17). Figure 17. Handle Positions 2 3. Insert release pin and lock with hitch pin. PAGE 22 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
COLD engine. The OPEN position provides the correct fuel mixture for normal operation after starting, and for restarting a warm engine. Figure 19. Fuel Lever V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 23...
Page 24
1. With the engine running, both forward and reverse speed setting. travel levers (Figure 26) should be in their neutral positions. PAGE 24 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 25
(Figure 29) to the ON position. The roller will now produce a vibratory frequency of 4,400 vps. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 25...
After first 25 hours then DRAIN SEALING Engine Oil Replacement BOLT WASHER every 50 to 100 hours Air Filter Cleaning Every 50 hours Figure 32. Engine Oil (Draining) PAGE 26 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 27
2. Drain water tank completely. 3. Cover the machine to prevent dust and store in dry place away from sun exposure. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 27...
Page 28
The scraper blades should be cleaned daily after each deflection should be approximately 3/4 of an inch (2 cm.). use to prevent the build-up of dirt, mud, tar and any other PAGE 28 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 29
The roller should not move once adjustment is PUMP complete. Figure 35. Hydrostatic Pump Drive Belt 5. Retighten all hardware. CAUTION Use caution when adjusting control rods, since engine is running. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 29...
Page 30
Remove ignition key, and store in a safe place. LUBRICATE CLUTCH WITH EP-3 GREASE .33 OZ. (A SHOT EVERY 50 HOURS) Figure 37. Lubrication Points (Zerk Fittings) PAGE 30 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Unit does not vibrate or has weak vibration. Damaged vibration cable and linkage? Replace or repair vibration cable and linkage. Defective clutch vibrator pulley V-belt? Replace V-belt. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 31...
Page 32
Fuel fi lter/lines clogged? Replace fuel fi lter. Fuel tank cap breather hole clogged? Clean or replace fuel tank cap. Air in fuel line? Bleed fuel line. PAGE 32 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 33
Check cable connections. Charge or replace Will not start, no power with key "ON". (if Battery disconnected or discharged? applicable) battery Ignition switch/wiring defective? Replace ignition switch. Check wiring. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 33...
“Remarks” Column. assembly/kit that can be purchased, or is not available for sale through Multiquip. PAGE 34 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
1....800796 ....WATER FILTER 1....35111880013 ..IGNITION KEY NOTICE Part numbers on this Suggested Spare Parts list may supersede/replace the part numbers shown in the following parts lists. V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 35...
8. Always stop engine and allow engine to cool before adding fuel or oil. CIP520935 WATER QUALITY TANK MANAGEMENT SYSTEM CERTIFIED ON ISO 9001:2008 518524 511724 511724 511724 PAGE 36 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 37
DECAL: POWDER COATED 948438 DECAL: WATER TANK SERIAL PLATE ..........1....CONTACT MQ PARTS DEPT. 520935 DECAL: SAFETY INSTRUCTIONS 511768 DECAL: HYD. OIL CHECK EVERY 50 HRS. 491757 RIVET V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 37...
CLUTCH ROD ASSY. HYDRAULIC OIL LEVEL HOT IMPORTANT HYDRAULIC OIL LEVEL COLD NOTES: SEE VIBRATORY ROD ASSY. PAGE 38 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
TRANSMISSION ROD ASSY. LEFT RIGHT HYDROSTATIC PUMP HYDRAULIC OIL LEVEL HOT IMPORTANT HYDRAULIC OIL LEVEL COLD PAGE 42 — V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16)
Page 43
804131TT LEVER, WATER RETAINER 804130 SPRING, RATCHET LEVER 492581 NUT, NYLON LOCKNUT 1/4"-20 G8 EM963007 CAP SCREW 1/4" NC X 1-1/2" G5 ....1....REPLACES P/N EM492359 V305EH VIBRATORY ROLLER • OPERATION AND PARTS MANUAL — REV. #1 (06/21/16) — PAGE 43...