Download Print this page
SPX 1727 Operating Instructions
SPX 1727 Operating Instructions

SPX 1727 Operating Instructions

Service jack

Advertisement

Quick Links

Application: Designed to lift a wide range of motor vehicles.
This parts list covers OTC No. 1727 Service Jacks
stamped with a date code of 109286 and later. (The
date code can be found on a silver plaque located
inside the frame rail above the pump.) This date
code indicates the model of your jack.
When you receive a repair parts kit, parts for all
models will be included. Use only the parts for your
jack; discard the other parts.
Saddle Low Point:
Saddle High Point:
Lifting Range:
Handle Length:
2
1
21
19, 20
17, 18
23
16
14, 15, 11
© SPX Corporation
SPX Corporation
655 Eisenhower Drive
Owatonna, MN 55060-0995 USA
Phone: (507) 455-7000
Tech. Serv.: (800) 533-6127
Fax: (800) 955-8329
Order Entry: (800) 533-6127
Fax: (800) 283-8665
International Sales: (507) 455-7223
Fax: (507) 455-7063
Service Jack
Max. Capacity: 2 Tons
3
3
/
in.
4
1
22
/
in.
2
3
18
/
in.
4
48 in.
5
(parts list
3, 4
on back
of this sheet)
12, 13
10, 11
Parts List and
Operating Instructions
for:
Item
No.
1
501238
2
12368
3
509167
4
10549
5
501294
6
502032
7
501237
8
217176
9
501800
10
15953
11
14855
12
501814
13
513781
14
501394
15
501803
16
501288
17
10252
18
10397
19
501818
20
501805
21
501817
22
501401
6
7
23
10236
501234
516675
8
22, 11
9
Form No. 107191
Part
No.
Qty.
Description
1
Handle Ass'y
1
Hex Hd. Cap Screw
1
U-joint
1
Roll Pin
1
Hydraulic Ass'y
1
Decal
1
Saddle
(1/8-2")
1
Cotter Pin
2
Front Wheel
(3/4")
2
Washer
6
Retaining Ring
2
Anchor Pin
2
Spring
1
Rod
2
Spacer Bushing
2
Caster
2
Lockwasher
(3/4")
2
Hex Nut
4
Spacer
(5/8-11 x 1")
4
Bolt
1
Grease Fitting
1
Load Block
2
Washer
Parts Included but not Shown
1
Pump Roller
1
Groove Pin
1 of 2
Sheet No.
Issue Date:
Rev. F (9-18-03)
1727
(not shown)
(3/8-16)
(see back)
(3/4")
(3/4")
(not shown)

Advertisement

loading
Need help?

Need help?

Do you have a question about the 1727 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for SPX 1727

  • Page 1 Max. Capacity: 2 Tons Application: Designed to lift a wide range of motor vehicles. Item Part Qty. Description This parts list covers OTC No. 1727 Service Jacks stamped with a date code of 109286 and later. (The (not shown) 501238 Handle Ass'y (3/8-16) 12368 Hex Hd.
  • Page 2 Parts List & Operating Instructions Form No. 107191, Back of Sheet 1 of 2 Verify yours No. 501294 Hydraulic Assembly Item Part Qty. Description 512958 Rod Assembly (includes items 5, 6, & 18) 501351 Retaining Ring 501299 Retaining Wire 10913 O-ring 201433 Retaining Ring...
  • Page 3: Safety Precautions

    6. Place approved support stands under the vehicle at points that will provide stable support. Before making repairs on the vehicle, lower it onto the support stands by SLOWLY and CAREFULLY turning the handle counterclockwise (CCW). 2 of 2 Sheet No. Issue Date: Rev. F (9-18-03) © SPX Corporation...
  • Page 4: Troubleshooting Guide

    Parts List & Operating Instructions Form No. 107191, Back of Sheet 2 of 2 Preventive Maintenance IMPORTANT: The greatest single cause of failure in hydraulic units is dirt. Keep the service jack clean and well lubricated to prevent foreign matter from entering the system. If the jack has been exposed to rain, snow, sand, or grit, it must be cleaned before it is used.