Pre Start-Up Checklist - Nortec 132-3091 Installation, Operation And Maintenance Manual

Humidifier Mandatory Pre Start-up Checklist (p. 1 of 1)
Unit Serial #: _ _ _ _ _ _ _ _
Unit type:
Customer/Job:_______________
Inspected by: ________________ Date of inspection:____/____/____
_____________________________________________________________________________________________
WATER QUALITY:
Well water
Conductivity: _______mhmos
HUMIDIFIER MOUNTING:
Clearances around the unit
- Front (door opens freely?)
- Top (steam lines)
- Bottom (fill, drain, controls) 2ft min ____________________
- Right (main pwr)
STEAM LINES:
- Slope up 2" per 12"
- Slope down ½" per 12"
- Traps r
r
- Insulated
- Length/Size _____/_______
- 90 deg. elbows
- Can condensate be trapped anywhere in the steam line? Yes
WATER LINES:
- ½" at max 4ft from the unit
- water pressure: 30-80psig
DRAIN LINES:
- Air gap located within 3ft of the unit
CYLINDER:
- Cylinder properly installed and sitting upright
WIRING:
- No loose wires around the unit or on the PC board? yes
CONTROLS:
Installed Location / Wiring /Setting
- High limit:
- Mod controller:
POWER:
- Voltage, amperage rating and fuse correspond to Spec Label
- Disconnect switch located close to humidifier
# of humidifiers: _____
Voltage: _____V/___ph
Address: __________________________________
r City water r
Acceptable
2ft min ____________________
r
- Slopped back to drain
r
- Trapped 2" more than static duct pressure
r
qty: ____
r
- 3/8" connection at fill
r
- PVC
r
r
___________________
r
___________________
NH Electric Steam Humidifier
Softened wate r
Hardness: _____ gr.
Obstruction
3ft min ____________________
2ft min ____________________
CONDENSATE LINES:
r
- Size _______
r
- Stainless steel or plastic
- ________% Vertical _______% Horizontal
r
- 45 deg. Elbows
r
r
r
- Slopped to drain
r r
no
Installed Location / Wiring /Setting
r
- Air proving: ___________________
r
- Other: ___________________
r
r
- 26 -
Tag:_____________
Steam output: ____lbs/hr
r
RO / DI water
r
r
qty: ____
r r
no
r
- Stainless steel
- Size:________