Listing And Code Approvals; Insert Certification; Btu & Efficiency Specifications; Mobile Home Approved - Quadra-Fire VOYAGEUR-MBK Owner's Manual

1

Listing and Code Approvals

A. Insert Certification
Model:
Voyageur Wood Insert
Laboratory: Intertek
Report No:
100116597
Type:
Solid Fuel Type, Listed Room Heater
Standard:
UL1482 and ULC S628-93 and
(UM) 84-HUD, Mobile Home
Approved.
NOTE: This installation must conform with local codes. In the
absence of local codes you must comply with the UL1482, (UM)
84-HUD and NPFA211 in the U.S.A. and the ULC S628-93 and
CAN/CSA-B365 Installation Codes in Canada.
B. BTU & Efficiency Specifications
EPA Certification #: 790
EPA Certified Emissions: 4.1 grams per hour
*LHV Tested Efficiency: 77.0 %
**HHV Tested Efficiency: 71.1 %
***EPA BTU Output: 11,200 to 23,500 / hr.
****Peak BTU/Hour Output: 49,100
Vent Size: 6 inches
Firebox Size: 1.83 cubic feet
Maximum Wood Length: 18 inches
Ideal Wood Length: 16 inches
* Weighted average LHV efficiency using Douglas Fir dimension-
al lumber and data collected during EPA emissions test.
**Weighted average HHV efficiency using Douglas Fir dimen-
sional lumber and data collected during EPA emissions test.
***A range of BTU outputs based on EPA Default Efficiency and
the burn rates from the low and high EPA tests, using Douglas
Fir dimensional lumber.
****A peak BTU out of the unit calculated using the maximum first
hour burn rate from the High EPA Test and the BTU content of
cordwood (8600) times the efficiency.
The Quadra-Fire Voyageur (ACC) meets the U.S. Environ-
mental Protection Agency's crib wood emission limits for
wood heaters sold after May 15, 2015.
This wood heater needs periodic inspection and repair for
proper operation. It is against federal regulations to operate
this wood heater in a manner inconsistent with operating
instructions in this manual.
July 8, 2015
Fuel Seasoned Cord Wood
C. Mobile Home Approved
• This appliance is approved for mobile home installa-
tions when not installed in a sleeping room and when
an outside combustion air inlet is provided.
• The structural integrity of the mobile home floor, ceil-
ing, and walls must be maintained.
• The appliance must be properly grounded to the frame
of the mobile home with #8 copper ground wire, and
chimney must be listed to UL103 HT or a listed UL-
1777 full length six inch (152mm) diameter liner must
be used.
• Outside Air Kit, part OAK-ACC must be installed in a
mobile home installation.
D. Glass Specifications
This stove is equipped with 5mm ceramic glass. Replace
glass only with 5mm ceramic glass. Please contact your
dealer for replacement glass.
Fire Risk.
Hearth & Home Technologies disclaims any
responsibility for, and the warranty will be
voided by, the following actions:
• Installation and use of any damaged appliance.
• Modification of the appliance.
• Installation other than as instructed by Hearth & Home
Technologies.
• Installation and/or use of any component part not approved by
Hearth & Home Technologies.
• Operating appliance without fully assembling all components.
• Operating appliance without legs attached (if supplied with unit).
• Do NOT Overfire - If appliance or chimney connector glows,
you are overfiring.
Any such action that may cause a fire hazard.
Improper installation, adjustment, alteration, service or
maintenance can cause injury or property damage.
For assistance or additional information, consult a qualified
installer, service agency or your dealer.
NOTE: Hearth & Home Technologies, manufacturer of
this appliance, reserves the right to alter its products, their
specifications and/or price without notice.
Quadra-Fire is a registered trademark of Hearth & Home
Technologies.
7063-512E
VOYAGEUR
WARNING
7