Page 3
7UNoH Deutsch 3FF§Ï English .BHZBS Français FTLZ Italiano 4MPWFOTLZ Nederlands 1PMTLJ Español 3PN¹OFUF Português 4MPWFOTLP Dansk )SWBUTLJ Norsk 4SQTLJ Svenska b DSF§Ï Suomi cssotprh...
Function collection systems. The BR/BD 530 and BR/BD 530 XL is used for wet-cleaning of level floors. It can easily be adjusted to a particular cleaning task by setting the water flow rate and extraction of dirty water.
Page 5
Operating Instructions BR/BD 530/530 XL English Operating and function controls 1 Push handle 14 Suction bar** 2 Trigger lever for brush mode 15 Rating plate 3 Control console 16 Roller brushes (BR model) Disc brushes (BD model)* 4 Electronics module and fuses...
Page 6
English Operating Instructions BR/BD 530/530 XL Instrument panel 1 Detergent metering 3 Overload fuse 2 Master switch 4 Suction turbine switch Before switching on the unit n Raise the cleaning head and remove Unloading the unit the cardboard packaging. n Attach push handle with the 4 supplied n The unit can now be moved down the screws and fit the caps.
Operating Instructions BR/BD 530/530 XL English Attaching the brushes Recommended detergents BD 530 or BD 530 XL Application: Detergents Before switching on the unit, the disc Maintenance cleaning RM 745 brushes must be attached (see (also for alkaline-sensitive RM 746 “Maintenance procedures”).
Page 8
Swivel up the running gear and lock. n Press down the lever; the suction bar is lowered. n Clean the unit. Adjust the propulsion speed (only BD 530 or BD 530 XL) n Switch on the suction motor with the switch. Information: n Throttle speed: The suction bar automatically adapts rotate knob towards –.
Page 9
Operating Instructions BR/BD 530/530 XL English Stopping and switching off Drain off the fresh water. n Open the latch on the fresh-water tank the unit with a suitable implement (e.g. a coin). n Close control knob for water flow rate.
English Operating Instructions BR/BD 530/530 XL n Check the brushes for wear and, if Tilting the suction bar required, replace. If the suction result is unsatisfactory, the straight suction bar can be tilted. Monthly n Loosen the wing nuts. n Check the condition of the container n Tilt the suction bar.
Operating Instructions BR/BD 530/530 XL English n Remove both roller brushes, insert new Frost protection ones (note hexagon fixtures for the roller brushes). If there is a risk of frost n Drain the fresh-water and dirty-water tanks. n Put the unit in a room which is protected from frost.
English Operating Instructions BR/BD 530/530 XL Warranty EU Declaration of Conformity The warranty terms issued by our authorised marketing company are valid in We hereby declare that the equipment described below every country. We remedy any fault in the conforms to the relevant fundamental safety and health...
Operating Instructions BR/BD 530/530 XL English Troubleshooting n Drain off and dispose of dirty water and Risk of injury! Before working on the unit, always any residual cleaning liquid. set the master switch to “0” and pull out the If faults cannot be rectified with the aid of mains plug.
Page 14
English Operating Instructions BR/BD 530/530 XL Accessories The unit can be fitted with various Ask for our catalogue or visit us on the accessories for a particular cleaning task. Internet at www.karcher.com. Quantity Part no. Part no. Quan- Designation Description...
Page 15
Operating Instructions BR/BD 530/530 XL English Quantity Part no. Part no. Quan- Designation Description required tity BD 530 BD 530 XL for unit Disc brushes, natural 6.906-056 6.905-866 for polishing of floors (soft) Disc brush, white 6.906-054 6.905-864 for cleaning of slightly...