Table of Contents
Advertisement
--- Loosen the lower water pipe (2) (remove the finger
shield if necessary). The best way to drain the system is
to loosen the upper end of the pipe and then loosen the
lower end, then the pipe can be bent to the side and the
fluid drained into a container.
--- Open the plug (3) on the cylinder block
--- Turn on the heater control in cab. Drain the fluid into a
container.
--- Drain the water pump by cranking the engine a few revs
with the drain plugs removed.
H 7.1.2.
Mix the antifreeze and water according to the
manufacturer's instructions.
1
--- Fill up the radiator (1) with a mixture of anti---freeze fluid
and water completely full, close the filler cap. The
expansion tank's cap has to be open when filling.
--- Fill the expansion tank (2) with fluid up to the fluid level
sign (3).
NOTE! If the finger shield is removed make sure you
re ---fit it.
H. Periodic maintenance
3
69---84,3
Filling
2
3
69---84,4
H 7.1.3.
--- 600
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
--- 700
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
--- 800
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
--- 900
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ensure that a recommended coolant is always used.
WARNING: Never fill up with cold fluid while the
engine is warm. Do not use plain water as coolant.
After changing the fluid run the engine for a time and
check the level of fluid.
Check alternator (40)
H 7.2.
Check all leads and terminals. Oily or corroded contacts
can cause trouble in the battery circuit.
Cleaning and reconditioning of the alternator should be
carried out by an authorized workshop.
Check starter motor (41)
H 7.3.
Check that leads and terminals are clean and in good
condition. Correct any defects.
Overhaul and reconditioning of the starter motor should
be carried out by an authorized workshop.
---82---
Coolant volume
13.5 l
13.5 l
15.5 l
15.5 l
69---85
69---86
Advertisement
Table of Contents
