Superior DRT4036TEN Installation And Operation Instructions Manual page 19

Figure 30 - Installing Lava Rock
Ember Flakes
Figure 31 - Installing Ember Flakes
Scrap Log Pieces
Figure 32 - Installing Scrap Log Pieces
REMOVING LOG SET/BURNER MODULE
Connecting and Disconnecting Gas Line
WARNING: A qualified service person must con-
nect and disconnect fireplace with gas supply. Follow
all local codes.
1. Using a 5/16" hex socket wrench or nut-driver, connect or discon-
nect flexible gas line and control valve (see Figure 33).
2. After connecting gas line to control valve, always test for leaks.
126721-01B
FIREPLACE INSTALLATION Continued
Lava Rock
Figure 33 - Connecting/Disconnecting Gas Line to Millivolt Valve
leak. Apply noncorrosive leak detection fluid to joints.
Bubbles forming show a leak. Correct leaks at once.
to disconnecting the electrical power, if any, before
proceeding with this installation.
burner module from your firebox. Some metal edges
may be sharp. Use caution with log sets as logs are
fragile.
1. Remove glass door (see page 17).
2. Remove grate and all floor media (see Removing Log Set/Burner
3. Carefully lift and remove 3 hearth refractories from fireplace.
4. Remove 3 spacers from firebox bottom (see Figure 34).
5. For 36" models only: Remove 3 loose logs from log set (see
6. Remove 9 screws from front and sides of firebox burner base. Lift
7. If needed, replace burner gasket before reinstalling log set/burner
Superiorfireplaces.US.com
To Gas Supply
(Natural)
To External
Regulator
(Propane/LP)
Flexible Gas
Line, Do NOT
Kink
WARNING: Never use an open flame to check for a
CAUTION: The gas supply shall be shut off prior
CAUTION: Use gloves when removing the log set/
Module).
Figures 29, 29a, and 29b, page 18).
entire base from unit by pulling forward to disengage from rear
flange and then lifting up (see Figure 34).
module (see replacement parts list on page 27).
Burner Base
Spacers
Firebox Bottom
Figure 34 - Removing/Installing Burner Base
Equipment
Shutoff Millivolt
Valve Control
Valve
Log Assembly
Screws
19