Weil-McLain GOLD CGa Installation And Maintenance Manual page 45

Boiler Manual
10b
Service & maintenance —
The boiler should be
service technician
following pages must be performed to assure maximum boiler efficiency and reliability. Failure to service and
maintain the boiler and system could result in equipment failure.
❏
Inspect . . . . . . . . . .
Reported problems
Inspect any problems reported by owner and correct
before proceeding.
Boiler area
1. Verify that boiler area is free of any
materials
liquids.
2. Verify that boiler area (and air intake) is free of any
of the
this manual. If any of these are present in the boiler
intake air vicinity, they must be removed. If they
cannot be removed, install combustion air piping
to the boiler in accordance with national, provincial
or local codes.
Air openings
1. Verify that combustion and ventilation air openings
to the boiler room and/or building are open and
unobstructed
automatic combustion air dampers, if used.
Part Number 550-110-593/1099
inspected and started annually
. In addition, the maintenance and care of the boiler designated in
, gasoline and other flammable vapors and
listed in
contaminants Table 1
. Check operation and wiring of
The boiler contains ceramic fiber and fiberglass materials. Use care when handling these
materials per instructions on
personal injury.
annual start-up
, at the beginning of the heating season,
2. Verify that boiler vent discharge and air intake are
clean and free of obstructions
Flue gas vent system
1.
Visually inspect entire flue gas venting system
for blockage, deterioration or leakage. Repair any
joints that show signs of leakage in accordance with
vent manufacturer's instructions.
2. Verify that masonry chimneys are lined, lining is in
combustible
good condition, and there are not openings into the
chimney.
on page 9 of
Pilot and main burner flames
1. Visually inspect pilot burner and main burner
flames as directed under section
manual.
Water piping
1. Check the boiler interior piping and all system
piping for signs of leaks.
2. Repair any leaks before proceeding.
of this manual. Failure to comply could result in severe
page 68
only by a qualified
and explained on the
Table 6
.
for the above
Failure to inspect
conditions and have them repaired
can result in severe personal injury
or death.
6d , page 32 of this
45